Transcript
COPPER-FIN II POOL HEATER START-UP CHECKLIST Job Name: _____________________________________________
Model Number: ________________________________________
Address: _____________________________________________
Serial Number: ________________________________________
City: _______________________ ST: _______ Zip: ________
Start-up Date: ________________________________________
OVERVIEW Retrofit New Project How many units are installed at this location? Boiler(s): _____________ Water Heater(s):
_____________
Inspect gas pipe, regulator and meter sizing. Y Is it sized correctly for Btu/Hr requirement? N Total Equiv. Length Gas Piping: _____________
Gas Supply Gas Pipe Dia. (in.):
water SUPPLY _____________
Is there an inlet gas lockup regulator on the supply? If Yes, is it ten feet upstream from the appliance?
Y N Y N
Water Pipe Dia. (in.):
_________________
Set Point:
_________________
Differential:
_________________
Record in. of water column -
At full fire, read and record -
Static Pressure: _____________
Inlet Temp: _________________
Dynamic Pressure: _____________
Outlet Temp: _________________
Manifold Pressure: _____________
electrical Supply Voltage: __________ Total Amp Draw: __________ External Remote?
Which contacts are used? Ws Wp R Other: ______________
Delta T: _________________
Air Pres. Differential: _____________
venting (Select the venting option being used): Outdoor Conventional venting - Single pipe vertical termination E-Rite Sidewall direct vent - Two pipe sidewall termination Powered Sidewall - Single pipe sidewall termination Powered DirectAire Horizontal - Two pipe sidewall termination DirectAire Vertical w/rooftop inlet - Two pipe vertical termination DirectAire Vertical w/sidewall inlet - Single pipe vertical and single pipe sidewall termination Other: __________________________________ Combustion and Ventilation Openings: Two openings to outside Two ducts from outside One opening to outside Two ducts from interior space Combustion & Vent Louver Openings Clearance between Openings (total sq. in.): (total sq. in.): inlet & outlet (DV): ______________ ______________ ______________ Comments/Corrections for air inlet piping, openings, or venting:
VENTILATION Air Inlet Dia. (in.): ____________ Air Inlet Material: ____________ Total Eqv. Length (ft.): ____________ Flue Dia. (inches): ____________ Flue Material: ____________ Total Eqv. Length (ft.): ____________
Y N
COMBUSTION Low Fire: High Fire: O2 % ______________ ______________ CO ppm ______________ ______________ CO2 %
______________ ______________
Draft Readings
Record in. of water column -
Unit On:
_____________
Unit Off:
_____________
Barometric Dampers properly adjusted?
Y N
This Startup Sheet is for use only by a qualified heating installer/service WARNING ! technician. Refer to the Installation and Operation Manual for your reference.
Have this unit serviced/inspected by a qualified service technician, at least annually. Failure to comply with the above could result in severe personal injury, death, or substantial property damage.
_____________________________________________________
Start-up performed by:
_____________________________________________________ clearances Measure and record (inches) the service clearances from the
Company: ____________________________________________
nearest obstruction (min. 24” required for service):
Name:
____________________________________________
Front: __________
L Side: __________ Top: __________
Phone:
____________________________________________
Rear: __________
R Side: __________
Start-up approved by:
Corrections needed or General Job Notes:
Company: ____________________________________________
_____________________________________________________
Name:
____________________________________________
_____________________________________________________
Phone:
____________________________________________
Send completed form to: Email:
[email protected]
Internal Use: S/O #: _____________________
Fax:
(615) 882-2963
Routed:
_____________________
Service Dept/Lochinvar 300 Maddox Simpson Pkwy. Lebanon, TN 37090
Tech:
_____________________
Mail:
— The information on this form verifies operation of the Lochinvar product only. — This does not imply other system components or overall system operation is certified. Component and system verification should be performed by the designated commissioning agent or installing contractor.
Save Then Submit Form
App: Denied:
CPX-STARTUP REV A
