Transcript
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 SCHEMATIC SCH18
BATTERY RED
SOLENOID
STARTER
M
RED
A
FUSE
AMMETER (OPTIONAL)
BLACK
WHITE
S B G
WHITE
M A1
L
A2
ATTACHMENT CLUTCH (CLUTCH OFF) BLACK
CLUTCH/BRAKE (PEDAL UP)
GRAY
REVERSE SWITCH (NOT IN REVERSE)
BLACK BLACK
BLACK
2
BLACK
3
BLACK BLACK
BLACK BLACK
1 6
SEAT SWITCH (NOT OCCUPIED)
GRAY
SHORTING CONNECTOR
CHASSIS HARNESS
IGNITION UNIT
(OPTIONAL)
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
HOUR METER
BLUE
BLACK
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
BLACK /WHITE
JUNCTION CONNECTOR
BLACK
FUEL LINE
12V POWER OUTLET (OPTIONAL)
BLUE
FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED)
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
RED
DIODE
ALTERNATOR
IGNITION SWITCH POSITION
CIRCUIT
OFF RUN/OVERRIDE
M+G+A1 B+A1
RUN START
B+A1 B + S + A1
“MAKE”
L+A2
3
6
6
3 2 1
2
5
5
1
4
4
CHASSIS HARNESS CONNECTOR (MATING SIDE)
DASH HARNESS CONNECTOR (MATING SIDE)
3
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.
NON-REMOVABLE CONNECTIONS
REMOVABLE CONNECTIONS
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 ELECTRICAL T31K 33
With 12V Outlet Option 30 103 87 59
With Service Minder Option
27 43 42
46
41
40
26
25
16
71
90
2
94 29
28
55
92 93
4
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 ELECTRICAL
KEY NO.
PART NO.
DESCRIPTION
1 2 8 16 25 26 27 28 29 30 33 40 41 42 43 55 71 87 90 92 93 94
144924 74760412 193228 176138 412894 175158 73510400 198885 192749 193350 411933 401098 17720408 131563 192507 17060512 400449 197802 400725 196615 192540 191834
Battery Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Cable Starter Battery 6 Ga. BL/Red 14.5 Fuse Nut Keps Hex 1/4-20 unc Cable Ground 18" Rear Battery Blk 6 Ga. Switch Seat Switch Ign Key/Chain Harness Ign Screw 1/4-20 unc x 1/2 Cover Terminal Red Solenoid Screw 5/16-18 x 3/4 Harness Ign. Chass. Switch Interlock Clutch Cover Terminal Harness Pigtail Reverse Switch Screw Plastic 10-14 x 2.0 Modual Reverse ROS
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
5
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 CHASSIS
18 14
5 176 151 137
176
176
177 175
182
236
235
130 68
34
68 36 196 181
235
176 194
37
68
183 194
236
213
68 183
138 68
68
180 287
181 162
218
228
58
189 217
189 194 52 189
228
189 152
Chassis-tex_ALPHA_1
6
189
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 CHASSIS
KEY NO.
PART NO.
DESCRIPTION
5 14 18 34 36 37 52 58 68 130 137 138 151 152 162 175 176 177 180 181 182 183 189 194 196 213 217 218 228 235 236 287 ---
197783X428 187559X428 433994X428 196125 17060512 414872X505 73680500 412280 17490508 416358 184921 193224X428 187568 199535 142432 193243 400776 195228 414685 193102X428 193057 74520520 17000512 73900500 414579 74760512 409167 196395 195161 406129 73930500 17600406 193640X428
Dash Hood Grille Plate Engine Screw 5/16-18 x 3/4 Fender Nut Lock 5/16-18 Drawbar Upper Screw Thdrol 5/16-18 x 1/2 Screw #10 x 0.750 Bumper Hood Cupholder Bracket Pivot Shield Browning/Debris Screw Hex Wsh Hi-Lo 1/4 x 1/2 Crossmember Screw 10-24 x 5/8 Wshd Qdrx Bushing Steering Chassis Bushing Mtg. Fender Crgo. Dash Lower Bolt 5/16-18 x 1-1/4 Screw 5/16-18 x 3/4 Nut Lock Hex Flange 5/16-18 Console Asm. Deck Lift Bolt 5/16-18 x 3/4 Rod Pivot Hood X-Piece Hood Stop Stud Fastener Spacer Fender Nut Center Lock 5/16-18 Screw 1/4-20 x 3/8 Plug Switch Light
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
7
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 DRIVE
70
185 56 74
221 172
184
42
125
35 160
172
160 139
125
202
140
160
141
167 203
134
186 64
159
187
157
161
188
192 155
189
49
15
50
190
51
176
61
192
23
174
52
165 166 233
51
232 178
195 166
22
125 29
175 17
158
116 287 2
15
193
159
73
26
1 2 1
183
37 205
8
33
drive-tex_peerless_fender_39
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 DRIVE
KEY NO. 1 2 15 17 22 23 26 29 33 35 37 42 49 50 51 52 56 61 64 70 73 74 116 125 134 139 140 141 155 157 158 159
PART NO. -----123583X 19131316 197297 197660 106933X 197455 197267 12000001 197722 121749X 8883R 72110614 194327 73900600 194326 138255 165999 196200 429581X428 74490544 142432 73900500 17000512 197857 74550412 10040400 19091210 12000028 105701X 194352 76020412
KEY NO. 160 161 165 166 167 172 174 175 176 178 183 184 185 186 187 188 189 190 192 193 195 202 203 205 221 232 233 287
DESCRIPTION Transaxle, Peerless 203-569 Key Square Washer 13/32 x 13/16 x 16 Ga. Spring, Brake Rod Shift Knob Spring Brake RTN Rod, Brake Ring E Rod, Brake, Park Washer 25/32 x 1-1/4 x 16 Ga. Cover, Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/8-16 Idler V-Groove V-Belt, Drive Pulley Transaxle Shaft Asm. Pedal Brake Control Console Bolt 5/16-18 Gr. 5 Screw 1/4 x 1/2 Nut Lock Hex Flange 5/16-18 Screw 5/16-18 x 3/4 Arm Shift Bolt 1/4-20 unf Gr. 8 w/Patch Washer Lock Hvy Helical 1/4 Washer 9/32 x 3/4 x 10 Ga. Ring Retainer Washer Plate Shf Keeper T/A Pin Cotter 1/8 x 3/4
PART NO. 169484 105709X 196212 429164 405257 197657 197289 197858 196214 197456 137057 198403X505 72110622 194321 19133210 194323 194317 194318 150360 17060512 197332 197859 19111116 121748X 403187 74780716 405296 421648
DESCRIPTION Retainer Clip Spring, Return, Clutch Busing Shaft Brake Hand Control Nut Push .625 Latch Brake Parking Strap Torque LH Nut Push Shaft Asm Shift Arm Clevis Rod Shift Spring Shift Spacer, Axle Handle Parking Brake Bolt Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Nut Lock Center 1/4-28 Screw 5/16-18 x 3/4 Bracket Brake Rod Link Shift Washer 11/32 x 11/16 x 16 Ga. Washer 25/32 x 1-5/8 x 16 Ga. Retainer Spring Clip Handle Bolt 7/16-14 x 1 Gr. 5 Washer Serrated Keeper Pulley T/A
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
9
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 ENGINE
1
21 45
20
122
79
84
97
18
96
15
69
2
12
37 42
28 29
85 90 9
OPTIONAL EQUIPMENT Spark Arrester
engine-tex_BS_30
10
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 ENGINE
KEY PART NO. NO. 1
-- ----
2 9 12 15 18 20 21 28 29 37 42 45 69 79 84 85 90 96 97 122
179758 194319 140186 407545 430220 170545 416358 401137 137180 123487 10040700 73510400 165291 192334 17060620 71170764 17000616 19091416 17670412 421922
DESCRIPTION Engine Briggs Model No. 219807-0389-B1 Muffler Keeper Belt Engine Pulley Engine Tank Fuel 1.5 Cap Control Throttle Screw #10 x 0.750 Fuel Line Spark Arrester Kit Clamp Hose Washer Lock 7/16 Nut Keps Hex 1/4-20 unc Gasket Screw 5/16 - 18 x .75 Screw 3/8-16 x 1-1/4 Bolt Hex 7/16-20 x 4 Gr. 5 Screw 3/8-16 x 1 Washer 9/32 x 7/8 x 16 Ga. Screw 1/4-20 x 3/4 Extension Drain Oil
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton
1-800-233-3723
Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 2002-05). Torque values are derived at 3060 RPM; horsepower values are derived at 3600 RPM. Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual “on-site” or net power). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-toengine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine.
11
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 STEERING 26
72 33 45
1
20
71
21
13
16
63
28 22
64
63 28
60
9
57
8
63
74
66
7 67
2
9 7
8
59 19
74 6
35
74
58
74
67
6 4 61
5 14
15
8
14
69 68
13
62 70
15
13 53
steering-tex_STDHRS_10
12
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 STEERING
KEY NO.
PART NO.
DESCRIPTION
1 2 4 5 6 7 8 9 13 14 15 16 19 20 21 22 26 28 33 35 45 53 57 58 59 60 61 62 63 64 66 67 68 69 70 71 72 74
414803X428 418168 416845 416846 6266H 121748X 12000029 121232X 121749X 10040600 73540600 429374 194729 198375X428 186737 420537 414854X428 17000612 10040500 194732 19113812 188967 407465 194747 194748 73971000 194740 194741 17000512 199849 71020748 194737 73900700 199162 417065 190752 428982 3366R
Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Washer Thrust 0.75 x 1.23 Washer 25/32 x 1-5/8 x 16 Ga. Ring, Clip #T5304-75 Cap, Spindle Washer 25/32 x 1-1/4 x 16 Ga. Washer Lock 3/8 Nut, Crown Lock 3/8-24 unf Shaft Steering Plate Steering Boot, Steering Adapter, Wheel Steering Support, Strg. Lower Insert, Wheel Steering Screw 3/8-16 x 3/4 Washer Lock 5/16 Gear, Sector Plate Washer 11/32 x 2-3/8 x 12 Ga. Washer Hardened .793 x 1.637 x .060 Bracket Upstop Bolt Shoulder Sector Pivot CFM Washer Thrust Sector Steering Nut Flange Lock 5/8-11 Draglink, LH Draglink, RH Screw 5/16-18 x 3/4 Retainer Clip Spring Steering Bolt Hex Fghd 7/16-14 x 3 Serr Bushing PM Front Axle Nut Lock Flange 7/16-14 Gr. 5 Washer 1.5 x .505 x .118 Bracket Deck Susp. Front Shaft Ext. Steering Bolt 5/16-18 x 4 w/Patch Bearing
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
13
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 7
11
9
3
3
20
8
6 2
2
1
14
14
KEY NO.
PART NO.
DESCRIPTION
1 2 3 6 7 8 9 11
408813 433818 431983 431912 431986 411658 425112 431982
Decal Engine HP Decal, Fender RH/LH Decal Hood Decal Warning, Keep Hand Away Decal Replacement Parts Decal Fender Warn S/F Decal Fender Logo Decal Ins Strg Whl
WHEELS AND TIRES 1 2
11 3 4 7
10 5
6
9 8
KEY NO.
PART NO.
DESCRIPTION
14 20 ---
421543 145005 193226X428 193227X428
Decal V-Belt Schematic Decal Bat Dan/Psn Pad Footrest LH Pad Footrest RH
KEY NO. 1 2 3 4 5 6 7 8 9 10 11 --
PART NO. DESCRIPTION 59192 Cap Valve Tire 65139 Stem Valve 421554X471 Rim Asm Front 421652 Tube Front (Service Item Only) 123410X Tire F T 278H Fitting Grease (Front Wheel Only) 9040H Bearing Flange (Front Wheel Only) 104757X421 Cap Axle Blk 1 50 x 1 00 106230X Tire R T 7154J Tube Rear (Service Item Only) 421533X471 Rim Asm 8" Rear Service 144334 Sealant, Tire (10 oz. Tube)
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
wheel_art_1-tex
14
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 SEAT
1
8 8 7
8 7 8
10
14
42 19
16
6
21
37 5
15
6
37
12
21 13
2
17 3 seat-tex_knob_1 KEY NO.
PART NO.
DESCRIPTION
1 2 3 5 6 7 8 10 12 13 14
403017 180166 140675 145006 73800600 124181X 171877 199180 199370 121248X 72050412
Seat Bracket Pivot Fender Strap, Asm Fender Clip Push-In Hinged Nut, Lock w/Ins. 3/8-16 unc Spring, Seat Cprsn Bolt 5/16-18 unc x 3/4 w/Sems Pan, Seat Bracket Seat Mounting Bushing Snap Bolt 1/4 - 20 X 1-1/2
KEY NO.
PART NO.
DESCRIPTION
15 16 17 19 21 37 42
134300 123740X 123976X 199372 171852 73800500 199371
Spacer Split Spring CPRSN Plate SW 1.310 Ga. Nut Lock 1/4 Gr.5 Knob Seat Bolt, Shoulder 5/16-18 Nut, Lock 5/16-18 unc Washer Cup Seat
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
15
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 MOWER DECK
11
70
67 7
152
11
11
7
37
42
40
16 26
11
10
27
15
9
42
14
12
41
17 43
8 32 13
20
18
19
23 22
21
20
24 5
6
38
71 25
4
1
30
2
39
3 33 6
2 38
34
35
tex-deck_SRD_1_r1
36
16
31
29
28
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 MOWER DECK KEY PART NO. NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31
Deck Weldment 30"Srd Stud Fastner w/'d'anti-Rotatio Nut Lock Hex Flange 5/16 - 18 Bracket Clutch Cable Bolt 5/16-18 Arm Susp Mower Rear Srd Screw #10 x 0.750 BOS Thread Arm Idler 30"Srd Spacer Retainer Screw 3/8 - 16 X 1 Smgml Tap/R Blk Screw Thd Roll 1/4 - 20 X 5/8 Arm Brake Mower 38" RH Tex Bolt Carr Sh 3/8 - 16 X 1 - 1/2 Gr5 Keeper Belt Idler Pulley Idler V-Groove Dim 4.25 Nut Lock FlG 3/8 - 16 unc Nut Flange Lock Top Washer Spacer Mandrel Bearing Ball Mandrel Screw Thd Roll Dod Pt Hex Keeper Belt Mandrel 30" Pulley Idler Flat Unplated Screw Thdrol 3/8 - 16 X 1-3/4 Washer 13/32 X 1 - 1/4 X 12 Ga Keeper Belt 30"Srd Cover Mandrel Mwr 30"Black Drive, Belt Deflector Hinge Pin Spring Torsion Nut Push
419272 195161 73900500 417645 17000510 418863 416358 420252 199092 17000616 137729 199470 72110612 156085 146763 73900600 400234 187690 110485X 173984 416910 193198 17490628 19132012 420253 420255 419271 417344 420895 197026 110452X
KEY PART NO. NO. 32 33 34 35 36 37 38 39 40 41 42 43 67 70 71 152 --
401872 187281 192872 419274 193003 19131316 196539 105304X 419270 419265 17000612 416877 198398X505 198332 17670608 408714 192870
--
431888
DESCRIPTION Spring Return Deck 38/46" Housing Mandrel 4pt Service Shaft Asm Mndrl N/Greaseable 38 Blade Mower Bagging Srd Bolt/Washer Asm 7/16 - 20 unf Washer 13/32 x 13/16 x 16 Ga. Bolt Shoulder Cap Sleeve Keeper Belt Engine LH Keeper Belt Engine RH Screw Hexwsh THDR 3/8-16 x 3/4 BL Pulley Mandrel 6 5 Pd 30" Handle clutch cable Clutch Asm. Manual Screw 3/8-16 x 1/2 Manual Clutch Cable Mandrel Assembly (Includes Housing, Shaft Assembly, And Bearing Only -Pulley/Nut/Washer And Blade Bolt/Washers Not Included) Replacement Mower Complete
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
17
TRACTOR - MODEL NO. PO12530LT (96042010500), PRODUCT NO. 960 42 01-05 MOWER LIFT
87
7
87
90
98
113
10 3 97
100 2
88
97
91
101*
89
lift-tex_11_r1
KEY NO. 2 3 7 10 87 88 89 90 91
PART NO. 422027 195231 196492X428 196314 194209 410710 19191912 194208 195181
87
*Key 91 may be substituted for Key 101
DESCRIPTION Shaft Asm.,Cross Lift Lever Asm., Lift RH Grip, Lever Spring Torsion Pin Cotter 7/16 Bow Tie Lock Spring Lift Assist Washer Clear Zinc Pin Cotter 5/16 Bow Tie Lock Link Lift Susp Mower Rear
18
KEY NO.
PART NO.
DESCRIPTION
97 98 100 101 113
17000612 195264 73930600 407003 19171912
Screw 3/8-16 x .75 Smgml Tap/R.Z Link Lift Susp. Front Mower Nut Centerlock 3/8 -16 unc Link Asm Lift Fixed Washer 17/32 x 1-3/16 x 12 Ga.
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
