Transcript
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 SCHEMATIC SCH03
BATTERY
S O LE NO ID RED
A
RED
STARTER
RED
M
FUSE
AMMETER (OPTIONAL)
B S M A1 L A2
WHITE
BLUE
G
CLUTCH / BRAKE (PEDAL UP)
ATTACHMENT CLUTCH (CLUTCH OFF) BLACK
BLACK
SEAT SWITCH (NOT OCCUPIED)
BLACK
BLACK
GRAY GRAY
REVERSE SWITCH NOT IN REVERSE
SHORTING CONNECTOR
BLACK BLACK
HOUR METER
BLUE
FUEL LINE
BLACK
(OPTIONAL)
CHARGING SYSTEM OUTPUT 3 AMP DC @ 3600 RPM
BLUE
RED
SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES)
IGNITION UNIT
BLACK/WHITE
28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
FUEL SHUT-OFF SOLENOID LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 RPM
LIGHT SWITCH
DIODE
STATOR
ORANGE
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF) BROWN
IGNITION SWITCH POSITION
CIRCUIT
OFF RUN/OVERRIDE
M+G+A1 B+A1
RUN START
B+A1 B + S + A1
“MAKE”
L+A2
BLACK
NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST.
3
HEADLIGHTS
NON-REMOVABLE CONNECTIONS
REMOVABLE CONNECTIONS
WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING.
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 ELECTRICAL
L02 22
79
21
33 90
34
30
27 26
24
43
41
42
2 40
25
28 16 16
94
29 92 93
4
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 ELECTRICAL
KEY NO.
PART NO.
DESCRIPTION
1 2 8 16 21 22 24 25 26 27 28 29 30 33 34 40 41 42 43 79 90 92 93 94
532 16 34-65 874 76 04-12 532 17 66-89 532 17 61-38 532 17 56-88 532 00 41-52 532 42 12-97 532 42 12-99 532 17 51-58 873 51 04-00 532 42 12-98 532 19 27-49 532 19 33-50 532 41 19-33 532 11 07-12 532 19 74-28 871 11 04-08 532 13 15-63 532 19 25-07 532 17 52-42 532 43 53-95 532 19 66-15 532 19 25-40 532 19 18-34
Battery Bolt Hex Hd 1/4-20 unc x 3/4 Box Battery Switch Interlock Harness Asm Light w/4152j Bulb Light #1156 Cable Battery Cable Battery 6 Ga. 11" Red Fuse 20 AMP Nut Keps Hex 1/4-20 unc Cable Ground 6 Ga. 12" Black Switch Seat Switch Ign Key/Chain Switch Light/Reset Harness Ign Bolt Blk Fin Hex 1/4-20 Cover Terminal Red Solenoid Socket Asm. Bulb Twistlock Cover Terminal Battery Harness Pigtail Screw Plastite 10-14 x 2.0 Module Reverse ROS
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
5
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 CHASSIS
29 159 30
212
17 24
18 39 28
24
25 26
5
25 26
5
31
209
209
278
9 11
208
209 208
13
207
64
26
209 35 1 209
33 208
10 142
115 37
145 37
209 35
114 2
209
142
141
205
35 34
38
26 209 38
205
6
Chassis-stlt_Alpha_18
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 CHASSIS
KEY NO.
PART NO.
DESCRIPTION
1 2 5 9 10 11 13 17 18 24 25 26 28 29 30 31 33 34 35 37 38 39 64 114 115 141 142 145 159 205 207 208 209 212 278 ---
532 17 46-19 532 17 65-54 532 15 52-72 532 43 33-53 872 14 06-08 532 17 49-96 532 18 17-19 532 40 61-79 532 18 49-21 874 78 06-16 819 13 13-12 873 80 06-00 532 42 67-41 532 19 54-02 532 19 45-89 532 13 66-19 532 18 25-07 532 18 25-08 872 11 06-06 817 49 05-08 532 17 57-10 532 18 75-68 532 15 47-98 532 15 81-12 817 06 06-20 873 90 06-00 532 17 57-02 532 40 91-67 532 18 56-35 817 49 06-08 817 67 05-08 817 67 06-08 817 00 06-12 532 18 75-69 532 41 63-58 532 00 54-79 532 18 78-01
Chassis Drawbar, Stretch Bumper, Hood/Dash Dash Bolt, Carriage 3/8-16 x 1 Panel Dash LH Panel Slkscr Dash RH Hood Bumper Hood Bolt Fin Hex 3/8-16 unc x 1 Gr. 5 Washer 13/32 x 13/16 x 12 Ga. Nut Lock Hex w/Ins 3/8-16 unc Grille Lens Grille Bar Fender Bracket Fender Repl 109873X Footrest Pnt LH Footrest Pnt RH Bolt Rdhd Sht Sqnk 3/8-16 x 3/4 Screw Thdrol 5/16-18 x 1/2 TYT Bracket Asm. Pivot Mower Bracket Pivot Dash Lower Keeper Belt Rear LH Screw 3/8-16 x 1-1/4 Nut Lock Flg. 3/8-16 unc Plate Reinforcement Rod Pivot Chassis/Hood Cupholder Screw Thdrol 3/8-16 x 1/2 Screw 5/16-18 x 1/2 Screw Thdrol 3/8-16 x 1/2 Screw Hex Wsh Thdrol 3/8-16 Insert Lens Reflect Screw #10 x 0.750 BOS Thread Plug Button Blk 359 Dia Choke Plug Dome Plastic
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
7
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 DRIVE
57 120 89
63 69
197
120
81
70
116
66
84
159 158
198 161
65
162 21
85
112
169
13 14
10
80
14
168
82
3
85
55
202
50
18 113
4
8
64
41
83
163
112
56
165
51
166 156
150
38
48
5
11
18 79
16 52
49 32
30 32 170
30
47
6 52
62
6
77
151 51
27
39
6
35 36
120
37 34
25 19
28
24
36
26 2
15
77 96
35 53
26
74 78
29
76
10
27
22
1 26
75
drive-stlt_Peerless_fender_13_r1
8
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 DRIVE
KEY NO.
PART NO.
1
– – – – – – Transaxle Peerless 206-545C (165670) (Order parts from transaxle manufacturer) 532 14 66-82 Spring Return Brake T/a Zinc 532 12 36-66 Pulley Transaxle 18" Tires 812 00 00-28 Ring Retainer # 5100-62 532 12 15-20 Strap Torque 30 Degrees 817 06 05-12 Screw 5/16-18 x 3/4 532 19 27-06 Rod Shift Fender Adjust Lt 876 02 04-16 Pin Cotter 1/8 x 1 Cad 532 10 57-01 Washer Plate Shf 388 Sq Hole 874 55 04-12 Bolt 1/4-28 unf Gr. 8 w/Patch 810 04 04-00 Washer Lock Hvy Helical 874 49 05-40 Bolt Hex FLGHD 5/16-18 Gr. 5 873 80 05-00 Nut Lock Hex w/ins 5/16-18 874 78 06-16 Bolt, Fin Hex 3/8-16 unc x 1 Gr. 5 873 80 06-00 Nut Lock 3/8-16 unc 532 10 69-33 Knob 532 13 08-04 Rod Brake Blk Zinc 26 840 873 35 06-00 Nut Hex Jam 3/8-16 unc 532 10 68-88 Spring Rod Brake 2 00 Zinc 819 13 13-16 Washer 13/32 x 13/16 x 16 Ga. 876 02 04-12 Pin Cotter 1/8 x 3/4 Cad 532 17 57-65 Rod Brake Parking LT/YT 532 07 16-73 Cap Brake Parking 532 16 95-92 Bracket Mtg Transaxle 874 76 05-12 Bolt Hex Hd 5/16-18 unc x 3/4 532 17 55-78 Shaft Asm Pedal Foot 532 12 01-83 Bearing Nylon Blk 629 Id 819 21 16-16 Washer 21/32 x 1 x 16 Ga. 532 12 49-63 Pin Roll 3/16 x 1" 532 17 91-14 Pulley Composite Flat 872 11 06-22 Bolt RDHD 3/8-16 unc x 2-3/4 Gr. 5 532 17 55-56 Keeper Belt Flat Idler 532 12 77-83 Pulley Idler V Groove Plastic 532 15 44-07 Bellcrank Asm 532 12 32-05 Retainer Belt Style Spring 872 11 06-12 Bolt Carr. Sh. 3/8-16 x 1-1/2 Gr. 5 873 68 06-00 Nut Crownlock 3/8-16 unc 873 68 05-00 Nut Crownlock 5/16-18 unc 532 19 96-52 Link Clutch 532 10 57-09 Spring Return Clutch 6 75 817 06 06-20 Screw 3/8-16 x 1-1/4 532 13 82-55 V-Belt Ground Drive 532 12 48-72 Cover Pedal Blk Round
2 3 4 5 6 8 10 11 13 14 15 16 18 19 21 22 24 25 26 27 28 29 30 32 34 35 36 37 38 39 41 47 48 49 50 51 52 53 55 56 57 62
DESCRIPTION
KEY NO.
PART NO.
DESCRIPTION
63 64 65 66 69 70 74 75 76 77 78 79 80 81 82 83 84 85 89 96 112 113 116 120 150 151 156 158 159 161 162 163 165 166 168 169 170 197 198 202
532 17 54-10 532 17 39-37 810 04 07-00 532 15 47-78 532 14 24-32 532 13 46-83 532 13 70-57 532 12 17-49 812 00 00-01 532 12 35-83 532 12 17-48 532 12-50-96 532 14 50-90 532 16 55-92 532 16 57-11 819 17 12-16 532 16 62-31 532 15 03-60 532 19 49-71 532 12 47-88 819 09 12-10 532 12 72-85 872 14 06-08 873 90 06-00 532 17 54-56 819 13 32-10 532 16 60-02 532 43 74-58 532 18 39-00 872 14 04-06 873 68 04-00 874 78 04-16 532 43 82-50 817 49 05-10 532 16 54-92 532 16 55-80 532 18 74-14 532 16 96-13 532 16 95-93 872 11 06-14
Engine Pulley Bolt Hex Washer Lock Hvy Hlcl Spr 7/16 Keeper Belt Engine Foolproof Screw Hex wsh HiLo 1/4 x 1/2 unc Guide Belt Mower Drive RH Spacer Axle Washer 25/32 x 1 1/4 x 16 Ga. E-ring #5133-75 Key Square 2 0 x 1845/ 1865 Washer 25/32 x 1-5/8 x 16 Ga. Key Woodruff #9 3/16 x 3/4 Arm Shift Shaft Asm Cross Tapered PMST/20 Spring Torsion T/a Washer 17/32 x 3/4 x 16 Ga. Link Transaxle Nut Lock Center 1/4 - 28 FNTHD Console Shift STLT Retainer Spring 1" Washer 9/32 x 3/4 x 10 Ga. Strap Torque LT Bolt Rdhd Sq Neck 3/8-16 x 1 Nut Lock Flg. 3/8-16 unc Spacer Retainer Washer 13/32 x 2 x 10 Washer Srrted 5/16ID x 1.125 Bracket Shift Mount Hub Tapered Flange Shift Lt Bolt Rdhd Sqnk 1/4-20 x 3/4 Nut Crownlock 1/4-20 unc Bolt Hex Fin 1/4-20 unc x 1 Gr. 5 Bracket Pivot Lever Screw 5/16-18 x 5/8 Bolt Shoulder 5/16-18 x .561 Plate Fastening Keeper Belt Transaxle Gear Nyliner Snap-In Washer Nyliner Bolt RdHd 3/8-16 unc x 1-3/4 Gr. 5
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
9
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 ENGINE
3
2
72 1
13
81
78
122
78
32 44 31 46
33 37
45 111
33
23
40
29
OPTIONAL EQUIPMENT Spark Arrester engine-stlt_bs_24
10
4
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 ENGINE
KEY NO.
PART NO.
1 2 3
532 17 05-51 Control Th/ch Flag 817 72 04-08 Screw Hex Thd Cut 1/4-20 x 1/2 – – – – – – Engine, B&S 31A507-1405-B1 (431930) (Order parts from engine manufacturer) 532 13 73-52 Muffler Exhaust B&S 532 16 52-91 Gasket Eng 1 313 Id Tin Plated 532 16 98-37 Shield BRN/DBR Guard 532 13 71-80 Kit Spark Arrestor (Flat Scrn) 532 43 30-03 Tank Fuel Front 532 43 85-96 Cap Fuel 532 12 34-87 Clamp Hose 532 40 11-37 Line Fuel 532 12 40-28 Bushing Snap Nyl Blk Fuel Line 817 67 04-12 Screw Thdrol 1/4-20 x 3/4 817 00 06-12 Screw Hex Wsh Thdrol 3/8-16 819 09 14-16 Washer 9/32 x 7/8 x 16 Ga. 532 19 23-34 Screw Socket Head 5/16-18 x 3/4 817 06 06-20 Screw 3/8-16 x 1-1/4 873 51 04-00 Nut Keps Hex 1/4-20 unc 532 41 41-19 Purge Line 532 42 19-22 Extension Drain Oil
4 13 23 29 31 32 33 37 40 44 45 46 72 78 81 111 122
DESCRIPTION
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton 1-800-233-3723
Engine Power Rating Information The gross power rating for individual gas engine models is labeled in accordance with SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure), and rating performance has been obtained and corrected in accordance with SAE J1995 (Revision 2002-05). Torque values are derived at 3060 RPM; horsepower values are derived at 3600 RPM. Actual gross engine power will be lower and is affected by, among other things, ambient operating conditions and engine-to-engine variability. Given both the wide array of products on which engines are placed and the variety of environmental issues applicable to operating the equipment, the gas engine will not develop the rated gross power when used in a given piece of power equipment (actual “on-site” or net power). This difference is due to a variety of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs & Stratton may substitute an engine of higher rated power for this Series engine.
11
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 STEERING
38 97 34 39 1
41
42 37 37 36 44 88 91 43
71 67
68
46 8 29
67
6 13
9
2
17
65
46
7 82
9 5
8
9
6 7
9 40
68
32
5
29 26
3
43 11
15 29
43 28
10
4
95 8
Steering-lt_OPP_1
30
12
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 STEERING
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 13 15 17 26 28 29 30 32 34 36 37 38 39 40 41 42 43 44 46 65 67 68 71 82 88 91 95 97
532 42 45-43 532 41 81-68 532 16 98-40 532 16 98-39 532 12 49-31 532 12 17-48 819 27 20-16 812 00 00-29 532 12 49-37 532 17 51-21 810 04 06-00 532 13 65-18 873 90 06-00 532 41 13-86 532 12 68-47 819 13 14-16 817 00 06-12 876 02 04-12 532 19 27-57 810 04 05-00 532 15 50-99 532 15 29-27 532 42 46-91 819 11 38-12 873 54 06-00 532 18 67-37 532 16 96-33 532 12 17-49 532 19 07-52 532 12 12-32 532 41 47-36 872 11 06-18 532 16 98-27 532 17 51-46 532 19 99-78 532 17 51-18 532 17 55-53 532 18 89-67 532 42 89-82
Wheel Steering Axle Asm Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer 25/32 x 1-5/8 x 16 Ga. Washer 27/32 x 1-1/4 x 16 Ga. Ring Klip #t5304-75 Bearing Col Strg Blk Link Drag Washer Lock Hvy Hlcl Spr 3/8 Spacer Brace Axle Nut lock Flg. 3/8-16 unc Shaft Asm Strg Bushing Link Drag Blk LR Washer 13/32 x 7/8 x 16 Ga. Screw 3/8-16 x 3/4 Pin Cotter 11/32 ID x 2 3/8 OD x 12 Ga. Rod Tie Wire Form 19 75 Mech Washer Lock 5/16 Bushing Strg 5/8 Id Dash Screw Cap Wheel Steer Washer 11/32 x 2 3/8 OD x 12 Ga. Nut Crownlock 3/8-24 Adaptor Wheel Strg Boot Dash Mtl Steering Blk Washer 25/32 x 1 1/4 x 16 Ga. Extension Steering Cap Spindle Fr Top Blk Spacer Brace Axle Bolt RDHD SQNK 3/8-16 x 2-1/4 Brace Axle Steering Asm. Bracket Susp Chassis Front Bolt Shoulder 7/16-20 Clip Steering Washer Harden .793 x 1.637 x 060 Bolt Fin Hex 5/16-18 x 4 w/Patch
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
13
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 SEAT
1
8 8
9 14
9
7
7
10
5 6 22 21
2 24 5
16 25 15 11 4 13 17
3
12
seat-stlt_knob_1
KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12
PART NO. 532 40 10-42 532 14 05-51 871 11 06-16 819 13 16-10 532 14 50-06 873 80 06-00 532 12 41-81 817 00 06-16 819 13 16-14 532 19 55-30 532 16 63-69 532 17 46-48
KEY NO. 13 14 15 16 17 21 22 24 25
DESCRIPTION Seat Bracket Seat Pivot Bolt Hex 3/8 - 16 x 1 Washer 13/32 x 1 x10 Ga. Clip Push-In Hinged Nut Lock Hex w/Ins 3/8 - 16 Spring Seat Cprsn 2 250 Blk Zi Screw 3/8-16 x 1.5 Washer 13/32 x 1 x 14 Ga. Pan Pnt Seat Knob Seat Bracket Pnt Mounting Switch
PART NO. 532 12 12-48 872 05 04-12 532 13 43-00 532 12 12-50 532 12 39-76 532 17 18-52 873 80 05-00 819 17 19-12 532 12 70-18
DESCRIPTION Bushing Snap Blk Nyl Bolt Rdhd Sht Nk 1/4 - 20 x 1 -1/2 Spacer Split .28 x .96 Spring Cprsn Nut Lock 1/4 Lge Flg Bolt Shoulder 5/16-18 unc-2A Nut Lock Hex w/Ins 5/16 - 18 Washer 17/32 x 1-3/16 x 12 Ga. Bolt Shoulder 5/16-18 x .62
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
14
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 DECALS
7
2
12
6
12
15
9
4
11
5
11
5
3
10
KEY NO.
PART NO.
DESCRIPTION
KEY NO.
PART NO.
DESCRIPTION
2 3 4 5 6 7 9 10
532 19 46-91 532 43 10-89 532 17 05-63 532 43 19-85 532 41 16-57 532 43 19-82 532 43 19-86 532 16 03-96
Decal, Replacement Decal, Engine HP Decal, Warning Decal, Fender Decal, Fender Warning (E&F) Decal, Ins Str Wh Decal, Fender Decal, V-Belt Sch.
11 12 15 ------
532 43 84-87 532 43 19-83 532 14 50-05 532 18 10-90 532 18 10-91 532 13 83-11 532 43 85-11 532 44 42-57
Decal, Lower Dash Decal, Hood RH/LH Decal, Caution, Battery Pad Footrest RH Pad Footrest LH Decal, Handle Lft Height Adj. Manual, Operator's, English/Spanish Manual, Parts, English/Spanish
KEY NO.
PART NO.
DESCRIPTION
1 2 3 4 5 6 7 8 9 10 11 --
532 05 91-92 532 06 51-39 532 10 62-22 532 05 99-04 532 43 87-27 532 12 49-57 532 12 49-59 532 43 87-26 532 42 05-31 532 12 49-26 532 19 32-68 532 14 43-34
Cap, Tire Valve Stem, Valve Tire, Front Tube, Front (Service item only) Rim Assembly, 6" Front Fitting, Grease (Front wheel only) Bearing, Flange (Front wheel only) Rim Assembly, 8" Rear Tire, Rear Tube, Rear (Service item only) Cap, Hub Axle Sealant, Tire (10 oz. Tube)
WHEELS & TIRES 1 2
5,8 4,10
7 3,9 6
11
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
wheel_1
15
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 MOWER DECK
67
40
158
36 40
185
143 144 159
42 _c lu tc h_ m
od _7
152
45 150
68
40
46
145
44
184 59
56 53 52 55 54
48 142 147
148
146 33 32 31 30
1
21 21 34
21 147
23
2
24 25
21
26 142
29
2 15 14 3 4 5
20
149
18 13
6 19
18 11
21 8
?DECK?STD?
16
28
27
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 MOWER DECK
KEY NO.
PART NO.
1 2 3 4 5 6 8
532 16 58-92 872 14 05-06 532 13 80-17 532 16 54-60 532 12 46-70 532 17 80-24 532 19 30-03
11
532 13 89-71
13 14 15 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 40 44 45 46 48
532 19 28-72 532 18 72-81 532 11 04-85 872 14 05-05 532 13 28-27 532 15 97-70 873 68 05-00 532 17 75-63 532 10 53-04 532 12 37-13 532 11 04-52 532 17 18-59 819 11 10-16 532 13 14-91 532 17 39-84 532 18 76-90 532 15 35-35 532 40 02-34 872 11 06-12 532 13 14-94 873 90 06-00 532 14 00-88 532 12 47-88 532 13 77-29 532 13 39-44
KEY NO.
DESCRIPTION
52 53 54 55 56 59 67 68 142 143 144 145 146 147 148 149 150 152 158 159 184 185 208 --
Mower Deck Assembly, 42" Bolt Bracket Asm Fr. Sway Bar 3/42 Bracket Asm Deck 42" Sway Bar Retainer Spring Bar Sway Deck Bolt/Washer Asm. 7/16-20 unf (The following Blades are available) Blade Mower 42” Hi-Lift (for bagging and discharging) Shaft Asm. Mandrel Housing Mandrel Bearing, Ball, Mandrel Bolt, Carriage 5/16-18 x 5/8 Bolt, Shoulder Baffle, Vortex Nut Bracket, Deflector Mower 42" Cap, Sleeve 80 x 112 Blk Mower Spring, Torsion, Deflector 2 52 Nut, Push Phos & Oil Shield, Deflector 42" Blk Washer 11/32 x 5/8 x 16 Ga. Rod, Hinge 42" 6 75 w/G Screw Thdrol Washer, Spacer Mower Vented Pulley, Mandrel Nut, Toplock Bolt Carr SH 3/8-16 x 1-1/2 Gr.5 Pulley, Idler, Flat Nut Lock 3/8-16 Guard, Mandrel, LH Retainer Screw, Thdrol 1/4-20 x 5/8 T Washer, Hardened
--
PART NO.
DESCRIPTION
532 13 98-88 532 18 49-07 532 17 85-15 532 15 50-46 532 16 57-23 532 14 10-43 532 10 69-32 532 14 49-59 532 19 57-84 532 15 71-09 532 15 86-34 532 16 58-88 532 17 19-77 532 13 13-35 532 16 90-22 532 16 58-98 819 09 12-10 532 16 96-76 817 72 04-08 872 14 06-14 819 13 14-10 532 18 82-34 817 67 06-08 532 19 28-70
Bolt, Shoulder 5/16-18 unc Arm Assembly, Pad, Brake Washer, Hardened Arm, Idler Spacer, Retainer Guard TUV Idler Knob Round V-Belt, 42" Mower Anchor Spring Brake Mower Bracket Arm Idler 42" Keeper Belt 42" Clutch Cable Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler Retainer Spring Yellow Washer 9/32 x 3/4 x 10 Ga. Clutch Cable 42" Screw Hex Thd Cut 1/4-20 x 1/2 Bolt Rdhd Sqn 3/8-16 unc x 1-3/4 Washer 13/32 x 7/8 x 10 Ga. Head Asm Cable Clutch Screw 3/8-16 x 1/2 Mandrel Assembly (Includes housing, shaft assembly, and bearing only - pulley/nut/washer and blade bolt/washers not included) 532 41 80-31 Replacement Mower, Complete
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
17
TRACTOR - MODEL NUMBER PO14542LT (96012011202), PRODUCT NO. 960 12 01-12 MOWER LIFT
7 8
5
1
3 13
2
4 6
6
11
5 4
12 13 19
20 20
31 32 13
15
DESCRIPTION
1 2 3 4 5 6 7 8 11 12 13
532 40 49-81 532 15 94-71 532 10 57-67 812 00 00-02 819 21 16-21 532 12 01-83 532 12 56-31 532 12 45-26 532 13 98-65 532 13 98-66 532 12 46-70
Plunger Asm Lift Lever Shaft Asm Lift RH Pin Groove 1 500 Zinc E Ring #5133-62 Washer 21/32 x 1 x 21 Ga. Bearing Nylon Blk 629 Id Grip Handle Button Plunger Black Link Lift LH Fixed Length Link Lift RH Fixed Length Retainer Spring
20
15
31 32 PART NO.
16 17
20
19
KEY NO.
18
lift-rh.1piece_3
18
KEY NO.
PART NO.
DESCRIPTION
15 16 17 18 19 20 31 32
532 17 32-88 873 35 08-00 532 17 56-89 873 80 08-00 532 13 98-68 532 19 42-09 532 16 98-65 873 54 06-00
Link Front Nut Jam Hex 1/2-13 unc Trunnion Nut Lock w/Wsh 1/2-13 unc Arm Suspension Rear Pin Cotter 7/16 Bow Tie Lock Bearing Pvt Lift Nut Crownlock 3/8-24
NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm.
