Tractor Walk Around

Transcript

5 Series Tractor Walk Around Tractor Walk Around – To do list Before a Customer gets to the dealership make sure you do the following; 1. 2. 3. 4. 5. Have a Deutz Fahr key Clean tractor Check fuel level Check all tractors functions work Adjust seat and steering to a comfortable positon 6. Set steering angle at full lock Tractor Walk Around – START Over the next slides this booklet will give you an overview on the key selling points. To start the Walk Around start at the rear of the tractor and move in an anti clock-wise direction to finish up with the customer inside the tractor. Be confident in selling the product and good luck! Tractor Walk Around – REAR Remotes – Mechanical 5130 1. 3 sets of remotes as std 2. Float, Detent, and Kick out 3. Flow control on 1 set 4. 60 l/min Hyd flow at rear remotes Remotes – Electro-Hyd 5130 FS/TTV 1. 3 sets of remotes as STD 2. Open centre Load Sensing 3. Flow control on 3 sets 4. Timer control on 1 5. 60 l/min at 1600rpm 6. Power beyond and load sensing Valve std Tractor Walk Around – REAR Three Point Linkage and Drawbar 1. Quick hitch ends 2. 4855kg lift capacity 3. Easy to use turnbuckle drop arms, one each side 4. Easy to use mechanical stabilisers with greasing points 5. Lower Link Draft sensing 6. Linkage Dampening when hitch is raised above 65% and travelling over 8km/h 7. Rear swinging heavy duty drawbar with multiple length settings to adjust for different PTO shafts Tractor Walk Around – REAR Rear Buttons on Guard 1. Green buttons are hitch Up and Down 2. Hold both Up & Down for 5 seconds to unlock hitch then linkage will raise and lower 3. Yellow button is PTO start and stop Tractor Walk Around – REAR Cab Suspension 1. Mechanically controlled maintenance free system 2. Operated by shocker and spring 3. Built in sway mechanism to give the operator a smooth ride Tractor Walk Around – REAR Easy to use maintenance 1. Easy view level Hydraulic/Transmission oil sight glass 2. Easy to fill Hydraulic oil located on top of lift cover 3. Located on rear left fender is the water reservoir for wipers Tractor Walk Around – SIDE Battery and Isolator switch 1. Easy to get to Battery, located under the step. 2. Isolator switch is a standard feature Tractor Walk Around – SIDE Cabin Air filter 1. Located at the top, 2 filters in total, one each side – Easy to remove Side Pillar Exhaust 1. Located on the side giving clear view from cabin and also mounted with special shock system to allow movement with cabin. Tractor Walk Around – SIDE Engine Lift the hood up, you will need the key to activate button at front of the bonnet. Once the bonnet is lifted remove side panel. Key Features • • • • German Built Deutz Tier 4, 3.6 lt engine Maintenance free system with No Ad blue and No Diesel particulate filter Common Rail fuel system Horsepower • 5130 -127hp Tractor Walk Around – SIDE Engine – Maintenance 1. • • • • • • All maintenance inspection for engine on one side; Dipstick Oil filler Engine oil filter Two fuel filters Fuel Primer Coolant Reservoir Tractor Walk Around – SIDE Engine – Key Features 1. Common Rail fuel injection – Explodes the fuel at higher pressure. The engine burns the fuel more efficiently giving the operator a fuel saving 2. Poly vee self tension Fanbelt, longer life and less maintenance 3. Separate belt around Air Cond compressor - this is a benefit as a lot of competitors have one belt going around all pulleys. If Air Cond compressor seizes you can still operate tractor 4. Viscous Fan on radiator, will use less power than a normal fan and makes engine more fuel efficient Tractor Walk Around – SIDE Engine – Easy to clean radiators 1. Slide out Radiator screens – Easy to clean. DEMONSTRATE Radiator Pack Consists of; 1. Radiator 2. Transmission Cooler 3. Intercooler 4. Diesel fuel Cooler 5. Air Cond Condenser Tractor Walk Around – Front Engine – Air Filter 1. 2. 3. Donaldson Dual Air filter element Powercore filtration system to expel the dust – Works like a Dyson Vacuum cleaner Easy to clean and check Tractor Walk Around – Front Front Axle 1. 2. 3. 4. 5. Heavy Duty Front axle with 3600kg load rating 55 degree turning – tight turning circle Twin power steering rams - operated by separate steering hydraulic pump 4 wheel wet disc brakes – gives proper stopping power, not operated by 4wd shaft. Front and Rear Diff lock – Gives true pulling, competition has a limited slip diff or none. Tractor Walk Around – Front Work lights and styling 1. 2. 3. 4. Sloping and side angled bonnet to give clear view Big Air intake Plenty of work lights Led drive lights like on car Tractor Walk Around – SIDE Front Axle Suspension - ONLY FS and TTV 1. 2. 3. 4. Two rams that use Hydraulics and Nitrogen accumulator Can turn “On and Off” Low maintenance of suspension unit Gives the operator a smoother ride in cabin Tractor Walk Around – SIDE Engine – What is that Galvanised thing? Diesel Oxidation Catalyst (DOC) This is like a cars catalytic convertor - it is for the Tier 4 emissions and is a maintenance free system – NO Ad blue or Diesel Particulate filter Tractor Walk Around – SIDE Fuel Tank 1. 2. Large 165 Lt Capacity Easy to fill with low nozzle level and big fill neck Tractor Walk Around – SIDE Adjustable Mirrors 1. These can be adjusted in and out and also have a safety hinge mechanism in case object hits mirror Tractor Walk Around – SIDE Cabin 1. 2. 3. Large non slip steps Wide door entry for easy access Double skin glass front quarter panels – Reduces noise in Cabin Tractor Walk Around – Cabin Cabin Get customer to enter the cabin and sit in drivers seat , adjust steering wheel and start tractor. When in cabin start from the Powershuttle lever and work clock wise. First thing to do is explain the coloured controls ORANGE – Driving YELLOW – PTO BLUE – Auxiliary Hydraulics GREEN – Three point linkage Tractor Walk Around – Cabin Power Shuttle • Forward /Reverse Power Shuttle • Modulation control with 5 settings – DEMONSTRATE • All power shuttle info is displayed on A pillar monitor Tractor Walk Around – Cabin DASH 1. Easy to read dash work display 2. Analogue readout; • Engine Speed • Fuel gauge • Operating temperature 3. Digital readout ; • Hours of tractor • Ground Speed • PTO Speed • Time Tractor Walk Around – Cabin STOP & GO SDD Steering (OPT) Front axle suspension (Profiline/TTV) Tractor Walk Around – Cabin A pillar display - 5130 1. 2. 3. Shows direction of travel Show the powershift speed selected Shows the PTO Speed selected A pillar WORK Display - TTV This coloured work display shows the operator 1. Direction of travel 2. Powershift speed selected 3. PTO Speed selected 4. Ground speed 5. PTO speed 6. Headland management 7. Engine cruise control settings 1&2 8. Auxiliary Remotes with flow control and activation 9. Performance monitor – to select this touch the ESC black button and rotate to black dial and touch to select (these buttons are located next to the engine throttle) Tractor Walk Around – Cabin RIGHT HAND CONSOLE 5120-5130 Unlock of linkage and headland raise and lower Auxiliary Remotes 4WD and Diff lock buttons Three point linkage control unit Gear stick 3 speed powershift and declutch button Engine Throttle with 2 engine speed programmes PTO engagement & Auto PTO Gear Range lever Tractor Walk Around – Cabin Headland Management WORK display buttons RIGHT HAND CONSOLE Profiline/TTV Auxiliary Remotes Auxiliary Remotes Unlock Unlock of linkage and headland raise and lower 4WD, Diff lock & ASM Buttons ECO-Power Dial (TTV) Three point linkage control unit PTO engagement & Auto PTO Engine Throttle with 2 engine speed programmes Tractor Walk Around – Cabin GEAR STICK – Powershift Models 1. 2. 3. 3 Speed Powershift De clutch button – On the go shifting Auto Powershift (Profiline Models Only) De Clutch Button Auto Powershift Button Powershift Buttons Tractor Walk Around – Cabin Rapid Speed increaser Speed Increase/Decrease Joystick TTV Joystick Speed Cruise Control The TTV Joystick is easy to use! When showing and changing modes look at work display as information will be changing to correspond to the work mode Mode Button • Manual • PTO • Auto Tractor Walk Around – Cabin Back Right Hand Corner of Cabin 1. 2. 3. 4. 5. Easy to get to sealed Fuse box Euro 3 pin plug ISO 7 pin plug – to give implements ground speed Easy access for cables and leads through to the cabin Rear Inching 3 point linkage button Tractor Walk Around – Cabin Opening Rear window and rear quarter panel window 1. 2. 3. Plenty of view from Drivers seat to Drawbar Rear window can partially open or open all the way Rear quarter window opens to allow fresh air in Tractor Walk Around – Cabin PTO Speed Selector - Powershift 4 Speeds Normal & Economy 540 & 1000 PTO Speed Selector – TTV 3 Speeds Ground Speed (optional) 540,750 & 1000 Tractor Walk Around – Cabin Storage Compartments Plenty of storage compartments with a cooler box and drink holders Tractor Walk Around – Cabin Seating • • Padded trainee seat with adjustable backrest and seatbelt Deluxe Comfortable Air suspended seat Tractor Walk Around – Driving Cabin Roof Lining • • • • • • • • • Hi Visibility Glass Roof Hi capacity Air-conditioning with 17 Vents Side and front glass demister vents Cab work light switches Interior worklight Front and Rear wipers/washers CD/Radio player with 4 speakers Two internal mirrors Front sunshade Tractor Walk Around – Cabin Key Points to show when Driving 1. 2. 3. 4. 5. 6. 7. Tight turning Circle Visibility inside cabin Quiet noise level Engine Speed Programming STOP & GO (Powershift models) Power shuttle modulation Smooth forward/reverse shuttle TTV TRANSMISSION 1. 3 modes – Auto, PTO , Manual 2. Power Zero Control (Auto & PTO mode) Stays stopped without your feet on pedals and in forward or reverse 3. Power dial when in Auto mode – Change parameters when driving to see engine revs change but speed stays the same 4. Setting the Speed Cruise control