Preview only show first 10 pages with watermark. For full document please download

Wm-fs593/fs595

   EMBED

Share

Transcript

WM-FS593/FS595 SERVICE MANUAL US Model Canadian Model Ver 1.3 1999. 06 With SUPPLEMENT-1 WM-FS593/FS595 AEP Model E Model (9-924-906-81) WM-FS593 Photo : WM-FS593 Model Name Using Similar Mechanism NEW Tape Transport Mechanism Type MF-WMFS593-147 SPECIFICATIONS Radio section Frequency range FM: 87.5 - 108 MHz AM: 530 - 1,710 kHz (US, Canadian, Central and South America) 531 - 1,602 kHz (Except US, Canadian, Central and South America) Tape section Frequency response (Dolby NR off) Playback: 30 - 14,000 Hz Output 2 (Headphones/earphones) jack Load impedance 8 - 300 ohms General Power requirements Dimensions (w/h/d) Mass Supplied accessories 3V Two R6 (size AA) batteries Approx. 96.5 × 130.6 × 47.8 mm (3 7/8 × 5 1/4 × 1 15/16 inches) incl. projecting parts and controls Approx. 295 g (10.5 oz) / Approx. 370 g (13.1 oz) incl. batteries and a cassette Stereo headphones or Stereo earphones (1) Belt clip (1) Flasher (1) (FS595 only) Sony CR2025 lithium battery (1) (FS595 only) Design and specifications are subject to change without notice. Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. “DOLBY” and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation. (WM-FS595 only) Notes on Chip Component Replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. RADIO CASSETTE PLAYER MICROFILM –1– TABLE OF CONTENTS 1. SERVICE NOTE 1-1. Moisture Resistant Treatment ............................................. 3 2. GENERAL Getting Started ........................................................................ 6 Operating the Walkman .......................................................... 6 Additional Information ........................................................... 7 3. DISASSEMBLY 3-1. 3-2. 3-3. 3-4. 3-5. 3-6. Display Board ..................................................................... 8 Mechanism Block ............................................................... 8 Main Board ......................................................................... 9 Mechanism Deck ................................................................. 9 Headphone Board .............................................................. 10 Control Board .................................................................... 10 4. MECHANICAL ADJUSTMENTS ............................ 11 5. ELECTRICAL ADJUSTMENTS ............................. 11 6. DIAGRAMS 6-1. 6-2. 6-3. 6-4. 6-5. 6-6. Block Diagram .................................................................. 13 Printed Wiring Boards –Main Section– ............................ 15 Schematic Diagram –Main Section– ................................. 17 Printed Wiring Board –Display Section– .......................... 20 Schematic Diagram –Display Section– ............................. 21 IC Pin Description ............................................................. 24 7. EXPLODED VIEWS 7-1. Cassette Holder Section .................................................... 26 7-2. Rear Cabinet Section ......................................................... 27 7-3. Mechanism Deck Section .................................................. 28 8. ELECTRICAL PARTS LIST ..................................... 29 –2– SECTION 1 SERVICE NOTE 1-1. MOISTURE RESISTANT TREATMENT Be sure to perform the following work when the HOLD knob and VOL knob have been replaced in servicing: Apply SONY grease SGL-505 (7-662-010-04) to the HOLD knob and VOL knob at the points specified in the figure with an applicator or other means. grease applying point (HOLD knob) grease applying point (rear cabinet) –3– SECTION 2 GENERAL –4– This section is extracted from instruction manual. –5– –6– –7– SECTION 3 DISASSEMBLY • The equipment can be removed using the following procedure. Set / Display board / Mechanism block Main board / Mechanism deck Headphone board Control board Note : Follow the disassembly procedure in the numerical order given. 3-1. DISPLAY BOARD 5 B 1.7x4 1 claws 6 DISPLAY board 3 CN701 2 cover 4 CN702 3-2. MECHANISM BLOCK 3 7 Removal the three solders. 1 B 1.7x8 claw 5 2 B 1.7x8 claw 4 mechanism block 6 connector –8– 3-3. MAIN BOARD 5 MAIN board 3 screw 2 Removal the four solders. 4 claws 1 CN305 3-4. MECHANISM DECK mechanism deck (MF-WMFS593-147) 1 claw 2 claws chassis –9– 3-5. HEADPHONE BOARD 1 TP 2x14 2 B 1.7x4 3 bracket (H/P JACK) 4 HEADPHONE board 3-6. CONTROL BOARD 4 B 1.4x6 2 adhesive sheet (control) 1 panel (control) 6 CONTROL board 5 cabinet (control) 3 B 1.4x6 – 10 – SECTION 5 ELECTRICAL ADJUSTMENTS SECTION 4 MECHANICAL ADJUSTMENTS PRECAUTION PRECAUTION 1. Clean the following parts with a denatured-alcohol-moistened swab : playback head pinch roller capstan rubber belt 2. Demagnetize the playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage (2.5 V) unless otherwise noted. • Supplied voltage : 2.5 V • Switches and control position TAPE SELECT switch : NORMAL SOUND switch : NORMAL VOL control : maximum AVLS switch : NORMAL DOLBY NR switch : OFF (FS595) HOLD switch : OFF Test Tape Torque Measurement Mode Torque Meter FWD FWD back tension CQ-102C REV REV back tension FF, REW CQ-102RC CQ-201B Meter Reading 20 – 42 g • cm (0.28 – 0.58 oz • inch) Type Signal Used for WS-48A 3 kHz, 0 dB Tape Speed Adjustment Tape Speed Adjustment Procedure : less than 2 g • cm (less than 0.03 oz • inch) test tape WS-48A (3 kHz, 0 dB) 20 – 42 g • cm (0.28 – 0.58 oz • inch) frequency counter 16 Ω less than 2 g • cm (less than 0.03 oz • inch) set more than 50 g • cm (more than 0.69 oz • inch) 2 jack 1. Playback WS-48A (tape center part) in the REV state and adjust RV601 so that the frequency counter reading becomes 2,970 – 3,000 Hz. 2. Playback WS-48A (tape center part) in the FWD state. Check that frequency counter reading is within ± 1.5% of the reading of step 1. Adjustment Location : RV601 – 11 – TUNER SECTION 0 dB = 1 µV FM FREQUENCY COVERAGE ADJUSTMENT • FM Section Setting: BAND switch: FM FM RF signal generator Frequency Display 108 MHz Reading on Digital voltmeter 8 ± 0.03 V Adjustment Part 0.01 µF L2 FM TRACKING ADJUSTMENT to IC1 pin 2 Adjust for a maximum reading on level meter. 75 kHz frequency deviation by 1 kHz signal Output level : as low as possible L1 CT1 87.5 MHz 108 MHz AM FREQUENCY COVERAGE ADJUSTMENT • AM Section Setting: BAND switch: AM Frequency Display 530 kHz (531 kHz) 1.5 ± 0.03 V Reading on Digital voltmeter AM RF signal generator Adjustment Part Put the lead-wire antenna close to the set. L3 AM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. 30% amplitude modulation by 400 Hz signal Output level : as low as possible L4 CT2 620 kHz (621 kHz) 1,400 kHz (1,395 kHz) AM IF ADJUSTMENT • Connecting Level Meter (FM and AM) Adjust for a maximum reading on level meter. T1 level meter (range: 0.5-5 V ac) 1,000 kHz (999 kHz) 16 Ω ( ) : Except US, Canadian, E model set Adjustment Location: main board 2 jack –main board (side B)– L3 AM FREQUENCY COVERAGE ADJ • Connecting Digital Voltmeter (FM and AM) digital voltmeter AM TRACKING L4 ADJ L2 FM FREQUENCY COVERAGE ADJ CT2 MAIN board TP (VT) R6 CT1 • Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. – 12 – L1 TP(VT) T1 AM IF ADJ FM TRACKING ADJ WM-FS593/FS595 SECTION 6 DIAGRAMS 6-1. BLOCK DIAGRAM PRE OUT(L) MIX IN(L) FS593 24 FS595 13 PRE2 R-CH J301 4 TAPE END DETECTOR PH701 R-CH R-CH R-CH DET FWD/REV 11 TAPE SELECT SWITCH Q101 MUTE SWITCH Q306 10 PRE MUTE Q304,305 REF COM 12 15 3 DET Q311 L.B GAIN CONTROL Q301 AVLS Q301 TUNER B+ 5V REF REF DET SYS. CONT POWER MUTE 9 PRE MUTE SW OUT(L) NF(L) 1 5 IC331 DOLBY NR AMP 25 34 ON/OFF 4 26 PWR OUT(L) PWR IN(L) RV301-1 VOL MIX OUT(L) AVLS 28 REV(L) REV PRE /POWER AMP IC301 20 L.B. GAIN FWD(L) 31 FWD DET1 HP901 PLAYBACK HEAD L-CH LOW BOOST M.B. ON/OFF 14 6 3V PHOTO REFLECTION SW Q505 PULSE AMP Q504 D801-804 (BACK LIGHT) X701 LED DRIVE Q801,803 HOLD SENS SWITCH Q706 VT LPF Q701,702 ON OFF LIGHT ON DOLBY X OUT RV601 OUT 17 VSP 16 15 MOTOR START SW Q609,610 TAPE SPEED 14 IN+ VREF 13 MOTOR BRK 51 25 LIQUID CRYSTAL DISPLAY PANEL ND701 AMP B+ SW Q501,503 AMP B+ 3V CTL 46 TAPE SPEED CONTOROL Q605,606 Q703 RADIO 60 ON REW SW REV SW 50 PHOTO IN BEEP 64 X IN MEGA BASS 61 27 PHOTO CTL AVLS 59 S301 (OPEN DET) S701 HOLD S751 1 - 22 26 FF SW 71 54 58 57 56 55 52 FWD SW 70 53 MOTOR CTL 39 75 BRKSPEED 41 MOTOR DIR 40 74 IF IN 43 49 IF REQ 44 47 BAND VCO AM 31 30 SEG1-18 VCO FM 65 COM1-4 OPEN DET GROOVE HOLD SW MUTE SENS HOLD FWD/ REV AD IN2 SYSTEM CONTROL IC701 AD IN3 48 FM MODE 62 EO 28 TAPE SELECT AMP B+ 32 TUNER B+ SW Q91,92 TUNER B+ (2.4V) FWD REW FF REV S601 (MD CONTROL) START SYSTEM CONTROL B+ SW Q506,507 SYSTEM CONTROL 3V 3 O MOTOR BRAKE SW Q601-604 AD REF 1.5V DRY BATTERY SIZE "AA" (IEC DESIGNATION R6) 2PCS,3V I 2 IC702 REG MOTOR SERVO IC601 OUTPUT BIAS CIRCUIT S702-705 S706-711 ERROR AMP VCO Q3 MOTOR DIR SWITCH Q607,608 3 FWD/REV SELECT SWITCH DR CURRENT CONTROL START-UP OSC CIRCUIT VELOCITY CONTROL U START-UP LOGIC V 5 PRE DRIVER W E, 9E, E7, FR, IT 6 START-UP CONTROL CIRCUIT FL1 BPF US, CND, 5E FM MODE SWITCH Q1,2 2 24 L1 FM RF D1 D401 T401 DDC DC/DC CONVERTER Q401 FM/MONO SW FM MIX FM RF 4 BUFF IF MIX OUT 7 FM/AM SW IF OUT FM DET 16 IF BUFF CF1 AM IN CT2,L4 AM TRACKING 12 AF BUFF DET OUT 1/8 SW T1 AM IF M901 MOTOR L-CH OUT IF REQ AM DET 6 15 MPX IN DECODE R-CH OUT 11 • R-ch : same as L-ch. R-CH FM OSC • Signal path : FM : AM : PB AM MIX BUFF D3 CF2 FM IF 17 FM/AM L2 FM OSC 22 CT2 13 VCO OUT AM IF L2 FM FREQ. COVERAGE L4 AM FERRITE-ROD ANTENNA 19 FM/MONO FM OSC 21 D2 14 FM IN CT1 CT1,L1 FM TRACKING D402 FM/AM FRONT-END,IF DET, DEMODULATOR IC1 AM OSC 20 AM OSC L3 AM OSC 04 4 PHASE SELECT CIRCUIT 10 X1 AM FREQ. COVERAGE TUNER B+ – 13 – – 14 – • Abbreviation 9E : Country of origin is not shown CND : Canadian model 5E : Central & South America model E7 : AEP model IT : Italian model FR : France model • IC Block Diagrams AM MIX MIX OUT 4 FM MIX FM OSC HP IN (L) AM LOW CUT 3 24 FM RF 23 RF VCC MIX IN (L) REG NF (R) FM RF SW OUT (L) PRE OUT (L) PRE OUT (R) SW OUT (R) FM RF GND 1 FM RF IN 2 IC301 LA4585M-TLM PRE GND NF (L) IC1 TA2104FN 22 AM RF IN 27 26 25 24 23 22 21 20 19 21 FM OSC PRE2 PRE1 REV (L) 28 VCC 5 AM OSC 18 MIX IN (R) 20 AM OSC REV (R) 29 BUFF 19 OSC OUT LEVEL DET ST 18 ST LED 16 LP1 REF IF BUFF AGC 1/8 RIPPLE 33 MIX OUT (L) 34 MIX OUT (R) 35 SW 17 IF OUT IF REQ LOW BOOST R.F MIX.1 MIX.2 AM BUFF 16 DET OUT AM DET 2 PWR.2 PWR.C 3 4 5 6 7 8 9 ON/OFF VEXT INR OUTR DCR DETR GND-2 FC RI OUT VSP IN+ VREF START COM OSC IC601 MM1370XVBE VCC IC331 NJM2185AV-TE2 (WM-FS595 only) DET2 PWR IN (L) 1 PWR.1 DET VCC REF COM 13 FM AM PWR GND L-CH OUT 12 SYS. CONT REF PWR OUT (L) FM/AM SW MPX OUT 14 13 12 11 10 9 8 20 19 18 17 16 15 14 13 12 11 ERROR AMP SUM G2 G1 OUTPUT BIAS CIRCUIT V/I WEIGHT START-UP • OSCILLATION CIRCUIT VELOCITY CONTROL CURRENT CONTROL Gm BIAS CIRCUIT START-UP CONTROL CIRCUIT START-UP LOGIC Ach BLOCK Bch BLOCK (same Ach) – 23 – 1 2 3 4 5 6 7 8 9 10 PV PW GND-1 FORWARD/REVERSE SELECT SWITCH P-GND IREF VREF INL OUTL DCL DETL PRE DRIVER W 7 V 6 U 5 DR 4 PU VCC 2 3 GND PHASE SELECT CIRCUIT 1 12 DET1 11 FWD/REV 14 ST MONO AVLS ST/MONO SW R-CH OUT 11 DET PWR IN (R) 36 15 MPX IN DECODE 14 M.B.ON/OFF 13 LP2 REF FM DET FM DET 10 15 L.B.GAIN REF REF POWER MUTE FM IF IN 7 GND 8 AGC 9 17 HP IN (R) FWD (R) 30 FWD (L) 31 REF 32 PWR OUT (R) AM IF IN 6 10 PRE MUTE 6-6. IC PIN DESCRIPTION • IC701 TC9327F-102 Pin No. Pin Name I/O Pin Description 1–4 5–22 COM1–COM4 S1–S18 — — Common terminal Segment terminal 23, 24 25 NC BRKSPEED — — Open Tape speed control terminal 26 27 LIGHT ON DOLBY — O LED control terminal (L: ON, H: OFF) Dolby control terminal (L: ON, Hi-imp: OFF) 28 29 FWD/REV NC O — Head input selection terminal ( L: REV, Hi-imp: FWD) Open 30 31 AVLS FM MODE O O AVLS control terminal (L: When AVLS is ON, H: OFF) MODE control terminal 32 33 TAPE SELECT NC O — TAPE SEL control terminal (H: CrO2/METAL) GND 34, 35 36 K0, K1 K2 I I 37 38 K3 BATT IN — I GND BATT detection terminal (L: BATT detected, H: Not detected) 39 40 OPEN DET HOLD SENS I I Open detection terminal (L: Open) Input when the HOLD key is pressed (L: When key is pressed) 41 42 HOLD SW BATT DET I I HOLD SW detection terminal (L: When SW is ON) Power supply voltage detection terminal (A/D input) 43, 44 45 AD IN2, AD IN3 AD-REF I I Key input terminal (A/D input) Reference voltage for AD IN1 and 2 46 47 48 AMP CTL MEGABASS GROOVE O O O AMP control terminal (H: When AMP is ON) MEGA BASS control terminal (L: When MEGA BASS/GROOVE is ON) Groove control unit (H: When GROOVE is ON) 49 50 BEEP MOTOR DIR O O BEEP sound input terminal Motor rotating direction control terminal (H: Reverse rotation) 51 52 MOTOR CTL MOTOR BRK O O Motor control terminal (H: When motor is ON) Motor brake control terminal (H: When brake is ON) 53 54 PHOTO CTL PHOTO IN O I Rotating detection circuit control terminal, PHOTO ON = L, STOP OFF, Input port Rotation detection signal input terminal 55 56 REV SW REW SW I I 57 58 FF SW FWD SW I I 59 60 BAND RADIO ON O O Band selection terminal (L: AM, Input port: FM) Radio ON/OFF control terminal (H: When radio is ON) 61 62 IF REQ MUTE O O IF request terminal (L: During auto scan) Otherwise = Input port Mute signal output terminal (H: During MUTE ON) 63 64 NC IF IN — I Open IF input terminal 65 66 EO NC O O Error out signal output terminal 67 68 HOLD NC — — +VDD Open 69 70 GND VCO (FM) — I Power supply GND terminal FM local oscillator input terminal 71 72 VCO (AM) VDD I — AM local oscillator input terminal Power supply voltage terminal 73 RESET — WALKMAN reset terminal (H: During operation) Destination selection DOLBY used/ not used Mechanism deck mode detection SW input terminal, ON = H – 24 – Pin No. Pin Name I/O Pin Description 74 75 XOUT XIN — — 76 VXT — 77 78, 79 VLCD C1, C2 — — LCD drive power supply step-up terminal 80 VEE — 1.5 V constant voltage power supply terminal for LCD drive. Crystal oscillator connection terminal Terminal to which external capacitor for stabilization of crystal oscillator power supply is connected. * Note: Output value of P9-2 (FM MODE terminal) changes depending upon destination. US, Canadian : High output during LOCAL mode, Low output during DX mode. E, AEP, East European : Low output during MONO mode, Set to the input during STEREO mode. * Note: Output port setting during STOP mode Hi-imp : S23, S24, D01/OT2, DO2 Low : P3-0, P3-1, P3-2, MUTE Set to the input port : P9-1, P9-2, P9-3, P4-0, P4-1, P4-3, P6-1, P6-2, P6-3 – 25 – Ver 1.3 1999. 06 SECTION 7 EXPLODED VIEWS NOTE: • The mechanical parts with no reference number in the exploded views are not supplied. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) N N • Accessories and packing materials and hardware (# mark) list are given in the last of this parts list. • Abbreviation CND : Canadian model E7 : AEP model IT : Italian model FR : France model 5E : Central & South America model 9E : Country of origin is not shown Parts Color Cabinet’s Color 7-1. CASSETTE HOLDER SECTION 11 19 12 20 not supplied 13 14 9 8 7 15 11 6 3 16 3 5 ND701 18 17 4 3 2 #1 10 1 Ref. No. Part No. Description Remark 1 2 3 4 4 3-023-120-01 3-023-099-01 3-318-203-61 A-3061-756-A A-3061-761-A BELT COVER SCREW (B1.7X4), TAPPING DISPLAY BOARD, COMPLETE (E,9E) DISPLAY BOARD, COMPLETE (FS593:US,CND,5E) 4 4 4 5 6 A-3061-766-A A-3061-771-A A-3061-776-A 3-023-109-01 3-922-849-11 DISPLAY BOARD, COMPLETE (E7,IT) DISPLAY BOARD, COMPLETE (FR) DISPLAY BOARD, COMPLETE (FS595) COVER (RESET) PACKING, CABINET (BLUE)…(YELLOW) 6 7 8 9 10 3-922-849-21 3-318-201-61 3-023-104-01 3-326-560-02 7-626-000-04 PACKING, CABINET (RED) SCREW (B1.4X6), TAPPING JOINT (HOLD) RING (DIA. 2.5XDIA. 4.5), O SPRING-PIN 1.6X16 11 12 12 3-326-536-11 SCREW, TAPPING 3-023-089-01 PLATE, ORNAMENTAL (BLACK) (FS593) 3-023-089-11 PLATE, ORNAMENTAL (GRAY) (FS595) Ref. No. Part No. Description 13 14 15 16 17 3-023-118-01 3-023-119-01 X-3375-542-1 3-023-103-01 3-023-122-01 COVER (LIGHT) SHEET (LIGHT), ADHESIVE ARM ASSY CASE (LCD) PLATE (LCD), CONDUCTIVE 18 19 3-023-097-01 PLATE (LCD), LIGHT GUIDE X-3375-254-1 HOLDER (CASSETTE) SUB ASSY (YELLOW) (FS593:US,CND,5E) X-3375-650-1 HOLDER (CASSETTE) SUB ASSY (YELLOW) (FS593:EXCEPT US,CND,5E) X-3375-651-1 HOLDER (CASSETTE) SUB ASSY (YELLOW) (FS595) X-3375-653-1 HOLDER (CASSETTE) SUB ASSY (RED) (FS593:CND) 19 19 19 20 20 ND701 – 26 – 3-023-101-01 KNOB (HOLD) (YELLOW) 3-023-101-11 KNOB (HOLD) (RED) 1-803-084-21 DISPLAY PANEL, LIQUID CRYSTAL Remark Ver 1.2 1999. 01 7-2. REAR CABINET SECTION 64 65 62 63 62 61 66 89 87 MF-WMFS593-147 BT1 60 A 57 68 58 BT2 67 57 #2 55 59 not supplied 56 84 54 76 53 69 88 #3 70 71 A 72 85 73 74 75 83 52 77 86 51 79 83 82 76 81 78 80 86 Ref. No. Part No. Description Part No. Description 51 51 52 52 53 3-023-087-01 3-023-087-11 3-023-093-01 3-023-093-11 3-009-870-01 BUCKLE (GRAY/YELLOW)…(YELLOW) BUCKLE (GRAY/RED)…(RED) PLATE, LOCK (YELLOW) PLATE, LOCK (RED) ROLLER (BUCKLE) Remark Ref. No. 73 73 73 73 73 3-023-090-01 3-023-090-11 3-023-090-21 3-023-090-31 3-023-090-41 CABINET (REAR) (YELLOW) (FS593:US,CND,E,5E) CABINET (REAR) (YELLOW) (FS593:E7,FR,IT) CABINET (REAR) (YELLOW) (FS593:9E) CABINET (REAR) (YELLOW) (FS595) CABINET (REAR) (RED) (FS593:CND) 54 55 56 57 58 3-318-203-61 3-025-316-01 3-023-107-01 3-349-825-31 3-023-106-01 SCREW (B1.7X4), TAPPING SHAFT (ROLLER) CAM (RESET) SCREW BRACKET (RESET) 74 75 75 76 77 3-326-573-01 3-024-906-01 3-024-906-11 3-023-112-01 3-023-091-01 RING (DIA. 4.9XDIA. 7.1), O KNOB (VOL) (GRAY) KNOB (VOL) (RED) SHAFT (BUCKLE) PLATE (REAR), ORNAMENTAL (BLACK)…(YELLOW) 59 60 61 62 63 3-023-110-01 3-024-616-01 X-3376-084-1 3-318-203-31 3-934-020-01 SPRING (RESET) BRACKET (SPRING) CHASSIS ASSY SCREW (B1.7X8), TAPPING LID, BATTERY CASE 77 78 79 80 80 3-023-091-11 3-023-095-01 3-023-113-01 3-023-094-01 3-023-094-11 PLATE (REAR), ORNAMENTAL (BLACK)…(RED) PANEL (CONTROL) SHEET (CONTROL), ADHESIVE CABINET (CONTROL) (YELLOW) CABINET (CONTROL) (GRAY) 64 65 66 66 66 3-936-792-01 3-351-153-01 A-3021-106-A A-3021-109-A A-3021-112-A SPRING, TORSION SPRING MAIN BOARD, COMPLETE (E,9E) MAIN BOARD, COMPLETE (FS593:US,CND,5E) MAIN BOARD, COMPLETE (E7,IT) * 81 82 82 83 84 1-669-172-11 3-023-088-01 3-023-088-11 3-012-927-01 3-386-371-01 CONTROL BOARD RING (O) (DIA. 34.3) (YELLOW) RING (O) (DIA. 34.3) (GRAY) RING, O PACKING, HP JACK 66 66 67 68 69 A-3021-115-A A-3021-119-A 3-028-083-01 3-922-447-01 3-934-023-01 MAIN BOARD, COMPLETE (FR) MAIN BOARD, COMPLETE (FS595) SCREW (TP2X14) PACKING, DC JACK JOINT (VOL) * 85 86 87 88 89 1-669-173-11 3-318-201-61 1-669-174-11 3-375-114-01 3-934-185-11 HEADPHONE BOARD SCREW (B1.4X6), TAPPING FLEXIBLE BOARD SCREW (TP1.7X4) SHEET, BATTERY 70 71 72 3-704-197-11 LOCK, SERRAT IB 3-318-201-51 SCREW (B1.4X4), TAPPING 3-934-024-01 JOINT (VOL.B) BT1 BT2 – 27 – 3-024-617-01 TERMINAL (+), BATTERY 3-023-117-01 TERMINAL (-), BATTERY Remark 7-3. MECHANISM DECK SECTION (MF-WMFS593-147) 104 103 122 106 105 108 109 121 110 107 102 120 102 111 112 117 116 118 118 117 119 119 101 116 HP901 M901 114 113 115 Ref. No. Part No. Description Part No. Description 101 102 103 104 105 X-3375-020-1 X-3369-747-1 3-354-868-01 3-021-950-01 3-021-982-01 PINCH LEVER (N-F) ASSY WHEEL ASSY (SP), CAPSTAN BELT GEAR (DF) SPRING (MODE), COMPRESSION Remark Ref. No. 113 114 115 116 117 3-703-816-31 X-3375-021-1 3-703-816-73 3-921-797-01 3-921-003-01 SCREW (M1.4), SPECIAL HEAD PINCH LEVER (R-F) ASSY SCREW (M1.4), SPECIAL HEAD WASHER BEARING 106 107 108 109 110 X-3375-024-1 3-021-951-01 3-348-953-21 3-021-979-01 3-021-949-01 CLUTCH ASSY (F) GEAR (CAM) WASHER SPRING (UDF), COMPRESSION GEAR (BF) 118 119 120 121 122 3-022-100-01 3-024-223-01 X-3375-268-1 3-338-647-31 3-026-340-01 SPRING (B.T.), COMPRESSION GEAR (REEL-2) GEAR (AF-SV) ASSY WASHER (1.0-2.5) WASHER 111 112 X-3375-022-1 CHASSIS ASSY (F) 3-021-974-01 SPRING (HEAD BASE) HP901 M901 1-500-555-11 HEAD, MAGNETIC (PLAYBACK) 1-763-073-11 MOTOR – 28 – Remark SECTION 8 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. • CAPACITORS uF : µF • COILS uH : µH Ref. No. Part No. * 1-669-172-11 CONTROL BOARD *************** Description Remark < RESISTOR > R751 R752 R753 R754 1-218-845-11 1-218-847-11 1-218-849-11 1-218-851-11 RES,CHIP RES,CHIP RES,CHIP RES,CHIP 820 1K 1.2K 1.5K 0.50% 0.50% 0.50% 0.50% 1/16W 1/16W 1/16W 1/16W < SWITCH > S751 1-771-128-11 SWITCH, TACTILE (BAND,REW,FF,π ,ª·) ************************************************************* A-3061-756-A DISPLAY BOARD, COMPLETE (E,9E) A-3061-761-A DISPLAY BOARD, COMPLETE (FS593:US,CND,5E) A-3061-766-A DISPLAY BOARD, COMPLETE (E7,IT) A-3061-771-A DISPLAY BOARD, COMPLETE (FR) A-3061-776-A DISPLAY BOARD, COMPLETE (FS595) ************************ Ref. No. DISPLAY When indicating parts by reference number, please include the board. • Abbreviation CND : Canadian model E7 : AEP model IT : Italian model FR : France model 5E : Central & South America model 9E : Country of origin is not shown Part No. Description C722 C723 C724 C725 C726 1-163-141-00 1-163-141-00 1-163-141-00 1-163-141-00 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 5% 5% 5% 5% 10% 50V 50V 50V 50V 50V C727 C728 C801 C802 C803 1-104-847-11 1-163-038-00 1-163-021-00 1-104-847-11 1-164-004-11 TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP 22uF 0.1uF 0.01uF 22uF 0.1uF 20% 4V 25V 50V 4V 25V C804 C805 1-164-004-11 CERAMIC CHIP 1-163-031-11 CERAMIC CHIP 0.1uF 0.01uF Remark 10% 20% 10% 10% 25V 50V < CONNECTOR > CN701 CN702 1-573-927-11 CONNECTOR, FFC/FPC (ZIF) 18P 1-573-927-11 CONNECTOR, FFC/FPC (ZIF) 18P < DIODE > D801 D802 D803 D804 3-023-097-01 PLATE (LCD), LIGHT GUIDE 3-023-103-01 CASE (LCD) 3-023-122-01 PLATE (LCD), CONDUCTIVE CONTROL 8-719-070-00 8-719-070-00 8-719-070-00 8-719-070-00 LED LED LED LED LNJ410C64OSO LNJ410C64OSO LNJ410C64OSO LNJ410C64OSO < FERRITE BEAD > < CAPACITOR > C701 C702 C703 C704 C705 1-163-009-11 1-104-847-11 1-163-231-11 1-163-231-11 1-107-823-11 CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 22uF 15PF 15PF 0.47uF 10% 20% 5% 5% 10% 50V 4V 50V 50V 16V C706 C707 C708 C709 C710 1-164-004-11 1-164-004-11 1-163-031-11 1-107-823-11 1-163-251-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.01uF 0.47uF 100PF 10% 10% 25V 25V 50V 16V 50V C711 C712 C713 C714 C715 1-163-141-00 1-163-251-11 1-163-251-11 1-163-031-11 1-135-233-21 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP 0.001uF 100PF 100PF 0.01uF 0.33uF 5% 5% 5% C716 C717 C718 C719 C721 1-163-139-00 1-163-031-11 1-163-251-11 1-163-031-11 1-163-141-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 820PF 0.01uF 100PF 0.01uF 0.001uF 5% 10% 5% 20% 5% 5% 50V 50V 50V 50V 20V 50V 50V 50V 50V 50V FB701 1-414-813-11 FERRITE, EMI (SMD) < IC > IC701 IC702 8-759-526-57 IC TC9327F-102 8-759-469-63 IC S-81215SGUP-DQK-T1 < JUMPER RESISTOR > JC701 JC702 JC704 JC705 JC706 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W JC708 JC711 JC712 JC715 JC716 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 0 0 0 0 0 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W < COIL > L701 – 29 – 1-412-995-21 INDUCTOR 22uH DISPLAY Ref. No. HEADPHONE Part No. MAIN Description Remark Ref. No. < LIQUID CRYSTAL DISPLAY > ND701 1-803-084-21 DISPLAY PANEL, LIQUID CRYSTAL < TRANSISTOR > Q701 Q702 Q703 Q706 Q801 8-729-220-93 8-729-602-21 8-729-117-73 8-729-602-21 8-729-028-76 FET 2SK209-G TRANSISTOR 2SC4154-F TRANSISTOR 2SC4178-F14 TRANSISTOR 2SC4154-F TRANSISTOR DTA114YUA-T106 Q803 8-729-028-76 TRANSISTOR DTA114YUA-T106 < RESISTOR > R705 R706 R707 R708 R709 1-216-833-11 1-216-805-11 1-216-829-11 1-216-813-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 47 4.7K 220 47K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R710 R711 R712 R713 R714 1-216-831-11 1-216-825-11 1-216-833-11 1-216-845-11 1-216-851-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 6.8K 2.2K 10K 100K 330K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R715 R716 R717 R718 R719 1-216-845-11 1-218-912-11 1-218-907-11 1-218-870-11 1-218-870-11 METAL CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100K 510K 330K 9.1K 9.1K 5% 0.50% 0.50% 0.50% 0.50% 1/16W 1/16W 1/16W 1/16W 1/16W R720 R721 R722 R723 R725 1-218-836-11 1-216-821-11 1-216-851-11 1-216-833-11 1-218-868-11 RES,CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP 360 1K 330K 10K 7.5K 0.50% 5% 5% 5% 0.50% 1/16W 1/16W 1/16W 1/16W 1/16W R726 R727 R728 R729 R730 1-218-864-11 1-218-868-11 1-218-871-11 1-218-836-11 1-218-845-11 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 5.1K 7.5K 10K 360 820 0.50% 0.50% 0.50% 0.50% 0.50% 1/16W 1/16W 1/16W 1/16W 1/16W R731 R732 R733 R734 R736 1-218-847-11 1-218-849-11 1-218-851-11 1-218-868-11 1-216-845-11 RES,CHIP RES,CHIP RES,CHIP RES,CHIP METAL CHIP 1K 1.2K 1.5K 7.5K 100K 0.50% 0.50% 0.50% 0.50% 5% 1/16W 1/16W 1/16W 1/16W 1/16W (FS595) R737 1-216-845-11 METAL CHIP 100K 5% R738 1-216-845-11 METAL CHIP 100K R739 R740 1-216-845-11 METAL CHIP 1-216-845-11 METAL CHIP 100K 100K R741 1-216-845-11 METAL CHIP 100K 1/16W (E7,FR,IT) 5% 1/16W (E,9E) 5% 1/16W 5% 1/16W (FS593) 5% 1/16W (US,CND,E,5E,9E) Part No. Description Remark R742 1-216-845-11 METAL CHIP 100K R743 R744 R745 R746 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100K 100K 100K 100K 5% 1/16W (EXCEPT E,9E) 5% 1/16W 5% 1/16W 5% 1/16W 5% 1/16W R747 R750 R755 R801 R802 1-216-845-11 1-216-821-11 1-216-821-11 1-216-810-11 1-216-810-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100K 1K 1K 120 120 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R803 R804 1-216-810-11 METAL CHIP 1-216-810-11 METAL CHIP 120 120 5% 5% 1/16W 1/16W < SWITCH > S701 S702 S703 S704 S705 1-572-922-11 1-771-105-11 1-771-105-11 1-771-105-11 1-771-105-11 SWITCH, SLIDE (HOLD) SWITCH, TACTILE (MENU) SWITCH, TACTILE (SET) SWITCH, TACTILE (TUNING +) SWITCH, TACTILE (TUNING -) S706 S707 S708 S709 S710 1-771-105-11 1-771-105-11 1-771-105-11 1-771-105-11 1-771-105-11 SWITCH, TACTILE (1) SWITCH, TACTILE (2) SWITCH, TACTILE (3) SWITCH, TACTILE (4) SWITCH, TACTILE (5) S711 1-771-105-11 SWITCH, TACTILE (BACK LIGHT) < VIBRATOR > X701 1-577-262-11 VIBRATOR, CRYSTAL (75kHz) ************************************************************* 1-669-173-11 HEADPHONE BOARD ***************** * < JACK > J301 1-565-376-11 JACK (2) ************************************************************* A-3021-106-A A-3021-109-A A-3021-112-A A-3021-115-A A-3021-119-A MAIN BOARD, COMPLETE (E,9E) MAIN BOARD, COMPLETE (FS593:US,CND,5E) MAIN BOARD, COMPLETE (E7,IT) MAIN BOARD, COMPLETE (FR) MAIN BOARD, COMPLETE (FS595) ********************* 3-934-023-01 JOINT (VOL) 7-627-850-57 SCREW, PRECISION +P 1.4X3.5 < BATTERY TERMINAL > BT1 BT2 3-024-617-01 TERMINAL (+), BATTERY 3-023-117-01 TERMINAL (-), BATTERY < CAPACITOR > C1 – 30 – 1-163-133-00 CERAMIC CHIP 470PF 5% 50V MAIN Ref. No. Part No. Description C2 C3 C4 C5 C6 1-163-133-00 1-163-141-00 1-163-227-11 1-163-251-11 1-163-037-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 470PF 0.001uF 10PF 100PF 0.022uF 5% 5% 0.5PF 5% 10% 50V 50V 50V 50V 25V C7 C8 C9 C10 C11 1-163-222-11 1-163-037-11 1-163-235-11 1-163-131-00 1-163-141-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 5PF 0.022uF 22PF 390PF 0.001uF 0.25PF 10% 5% 5% 5% 50V 25V 50V 50V 50V C12 C13 C14 C15 C16 1-163-251-11 1-163-231-11 1-163-038-00 1-163-033-00 1-163-021-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 15PF 0.1uF 0.022uF 0.01uF 5% 5% 50V 50V 25V 50V 50V C18 C19 C20 C21 C22 1-163-021-00 1-163-141-00 1-164-004-11 1-109-982-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.001uF 0.1uF 1uF 0.1uF 10% 5% 10% 10% C23 1-163-022-00 CERAMIC CHIP 0.012uF C23 1-163-024-00 CERAMIC CHIP 0.018uF C24 C25 1-163-809-11 CERAMIC CHIP 1-163-022-00 CERAMIC CHIP 0.047uF 0.012uF C25 1-163-024-00 CERAMIC CHIP 0.018uF 10% 50V (E,9E,E7,FR,IT) 10% 50V (US,CND,5E) 10% 25V 10% 50V (E,9E,E7,FR,IT) 10% 50V (US,CND,5E) C26 C27 C28 C29 C30 1-163-809-11 1-135-151-21 1-163-031-11 1-163-141-00 1-163-141-00 CERAMIC CHIP TANTALUM CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.047uF 4.7uF 0.01uF 0.001uF 0.001uF C31 C32 C33 C34 C35 1-163-031-11 1-109-982-11 1-163-059-00 1-126-209-11 1-164-346-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 0.01uF 1uF 0.01uF 100uF 1uF C36 1-164-346-11 CERAMIC CHIP 1uF C37 1-164-346-11 CERAMIC CHIP 1uF C39 C41 1-163-141-00 CERAMIC CHIP 1-164-346-11 CERAMIC CHIP 0.001uF 1uF C42 1-164-346-11 CERAMIC CHIP 1uF C43 C91 C92 C93 C101 1-163-031-11 1-104-847-11 1-163-141-00 1-135-201-11 1-163-005-11 0.01uF 22uF 0.001uF 10uF 470PF CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP TANTALUM CHIP CERAMIC CHIP Remark 10% 50V 50V 25V 10V 25V 10% 20% 25V 4V 50V 5% 50V 5% 50V (US,CND,5E) 10% 10% 20% 50V 10V 50V 4V 16V 5% 16V (FS593) 16V (FS593) 50V 16V (FS595) 16V (FS595) 20% 5% 20% 10% 50V 4V 50V 4V 50V Ref. No. Part No. Description C102 C103 C104 C105 1-163-005-11 1-163-017-00 1-104-847-11 1-164-346-11 CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP C106 1-163-009-11 CERAMIC CHIP 0.001uF 10% C107 C108 C109 1-164-346-11 CERAMIC CHIP 1-163-009-11 CERAMIC CHIP 1-164-346-11 CERAMIC CHIP 1uF 0.001uF 1uF 10% C131 1-164-346-11 CERAMIC CHIP 1uF C132 1-164-489-11 CERAMIC CHIP 0.22uF C133 1-164-505-11 CERAMIC CHIP 2.2uF C201 C202 C203 C204 1-163-005-11 1-163-005-11 1-163-017-00 1-104-847-11 470PF 470PF 0.0047uF 22uF C205 1-164-346-11 CERAMIC CHIP 1uF C206 C207 C208 C209 1-163-009-11 1-164-346-11 1-163-009-11 1-164-346-11 0.001uF 1uF 0.001uF 1uF C231 1-164-346-11 CERAMIC CHIP 1uF C232 1-164-489-11 CERAMIC CHIP 0.22uF C233 1-164-505-11 CERAMIC CHIP 2.2uF C301 C302 1-164-346-11 CERAMIC CHIP 1-104-847-11 TANTAL. CHIP 1uF 22uF C303 C304 C305 C306 C307 1-104-847-11 1-164-005-11 1-164-346-11 1-126-209-11 1-107-823-11 TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP 22uF 0.47uF 1uF 100uF 0.47uF C308 C309 C310 C311 C312 1-164-222-11 1-163-038-00 1-135-180-21 1-163-809-11 1-164-505-11 CERAMIC CHIP CERAMIC CHIP TANTALUM CHIP CERAMIC CHIP CERAMIC CHIP 0.22uF 0.1uF 3.3uF 0.047uF 2.2uF C313 C314 C315 C316 C319 1-107-823-11 1-163-037-11 1-164-004-11 1-135-151-21 1-164-005-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTALUM CHIP CERAMIC CHIP 0.47uF 0.022uF 0.1uF 4.7uF 0.47uF C331 1-135-201-11 TANTALUM CHIP 10uF C332 1-164-005-11 CERAMIC CHIP – 31 – CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP Remark 470PF 10% 0.0047uF 5% 22uF 20% 1uF 0.47uF 10% 10% 10% 5% 20% 10% 10% 10% 20% 20% 20% 10% 20% 10% 50V 50V 4V 16V (FS593) 50V 16V 50V 16V (FS595) 16V (FS595) 16V (FS595) 16V (FS595) 50V 50V 50V 4V 16V (FS593) 50V 16V 50V 16V (FS595) 16V (FS595) 16V (FS595) 16V (FS595) 16V 4V 4V 25V 16V 4V 16V 25V 25V 6.3V 25V 16V 10% 10% 10% 20% 16V 25V 25V 4V 25V 20% 4V (FS595) 25V (FS595) MAIN Ref. No. Part No. Description Remark C334 1-135-201-11 TANTALUM CHIP 10uF 20% C335 1-163-009-11 CERAMIC CHIP 0.001uF 10% C401 C402 C403 1-163-227-11 CERAMIC CHIP 1-163-141-00 CERAMIC CHIP 1-164-505-11 CERAMIC CHIP 10PF 0.001uF 2.2uF 0.5PF 5% C404 C405 C406 C407 C502 1-163-227-11 1-104-847-11 1-163-031-11 1-163-033-00 1-163-009-11 CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 10PF 22uF 0.01uF 0.022uF 0.001uF 0.5PF 20% C506 C507 C601 C602 C603 1-164-004-11 1-125-639-11 1-164-004-11 1-164-004-11 1-164-489-11 CERAMIC CHIP DOUBLE LAYERS CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 56000uF 0.1uF 0.1uF 0.22uF 10% 10% 10% 10% 25V 3.5V 25V 25V 16V C604 C605 C606 C607 C608 1-164-004-11 1-164-004-11 1-126-246-11 1-164-004-11 1-107-823-11 CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 220uF 0.1uF 0.47uF 10% 10% 20% 10% 10% 25V 25V 4V 25V 16V C609 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V 10% Ref. No. 4V (FS595) 50V (FS595) 50V 50V 16V FB401 50V 4V 50V 50V 50V IC1 IC301 IC331 IC601 Part No. Description Remark 1-414-385-11 FERRITE, EMI (SMD) < BPF > FL1 1-236-711-21 FILTER, BAND PASS < IC > 8-759-525-93 8-759-332-69 8-759-488-80 8-759-526-37 IC IC IC IC TA2104FN(EL) LA4585M-TLM NJM2185AV-TE2 (FS595) MM1370XVBE < JUMPER RESISTOR > JC1 JC2 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP 0 0 JC3 JC601 1-216-295-00 SHORT 1-216-296-00 SHORT 0 0 5% 5% 1/16W 1/16W (US,CND,5E) < COIL > L1 L2 L3 L4 L401 1-416-651-11 1-416-652-11 1-415-962-11 1-501-996-11 1-412-991-11 COIL (FM-RF) COIL (FM-OSC) COIL (OSC) ANTENNA, FERRITE-ROD INDUCTOR 10uH < FILTER > < PHOTO REFLECTOR > CF1 CF2 1-767-480-11 FILTER, CERAMIC (AM) 1-767-362-11 FILTER, CERAMIC PH701 8-719-988-14 PHOTO REFLECTOR PR-11-B < CONNECTOR > CN301 CN302 CN303 CN304 1-750-341-11 1-750-341-11 1-750-346-21 1-691-742-11 < TRANSISTOR > CONNECTOR, FFC/EPC (ZIF) 18P CONNECTOR, FFC/EPC (ZIF) 18P CONNECTOR, FFC/EPC (ZIF) 6P PIN, CONNECTOR (PC BOARD) 4P Q1 Q2 Q3 Q91 Q92 8-729-602-21 8-729-028-76 8-729-117-73 8-729-230-60 8-729-402-13 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC4154-F (US,CND,5E) DTA114YUA-T106 (US,CND,5E) 2SC4178-F14 2SA1586-YG XN1501 < DIODE > Q101 Q201 Q301 Q304 Q305 8-729-421-26 8-729-421-26 8-729-014-12 8-729-014-12 8-729-028-76 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR UN5216 UN5216 RN1311-TE85L RN1311-TE85L DTA114YUA-T106 DIODE DIODE DIODE DIODE DIODE < TRIMMER > CT1 CT2 1-141-463-11 CAP, ADJ 1-141-463-11 CAP, ADJ 10PF 10PF D1 D2 D3 D91 D401 8-719-062-15 8-719-062-15 8-719-951-05 8-719-941-86 8-719-404-49 KV1430-3/4-TL00 KV1430-3/4-TL00 KV1560 DAN202U MA111 Q306 Q310 Q311 Q401 Q501 8-729-014-12 8-729-014-12 8-729-230-60 8-729-602-21 8-729-014-12 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR RN1311-TE85L RN1311-TE85L 2SA1586-YG 2SC4154-F RN1311-TE85L D402 D501 8-719-056-89 DIODE UDZ-TE-17-12B 8-719-049-09 DIODE 1SS367-T3SONY Q503 Q504 Q505 Q506 Q507 8-729-807-86 8-729-014-12 8-729-230-60 8-729-230-60 8-729-014-12 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SB1295-UL5 RN1311-TE85L 2SA1586-YG 2SA1586-YG RN1311-TE85L Q601 Q602 Q603 Q604 8-729-014-12 8-729-141-48 8-729-141-48 8-729-141-48 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR RN1311-TE85L 2SB624-BV345 2SB624-BV345 2SB624-BV345 < FERRITE BEAD > FB1 FB101 FB201 FB301 FB304 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-385-11 FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) – 32 – MAIN Ref. No. Part No. Description Q605 Q606 Q607 Q608 Q609 8-729-028-76 8-729-421-26 8-729-014-12 8-729-028-76 8-729-014-12 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Remark Q610 8-729-028-76 TRANSISTOR DTA114YUA-T106 DTA114YUA-T106 UN5216 RN1311-TE85L DTA114YUA-T106 RN1311-TE85L < RESISTOR > R1 1-216-821-11 METAL CHIP 1K 5% 1/16W (US,CND,5E) 1/16W 1/16W 1/16W 1/16W R2 R3 R4 R5 1-216-853-11 1-216-853-11 1-216-853-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP 470K 470K 470K 1K 5% 5% 5% 5% R6 R7 R8 R9 R10 1-216-853-11 1-216-853-11 1-216-853-11 1-216-833-11 1-216-821-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 470K 470K 470K 10K 1K 5% 5% 5% 5% 5% R11 R12 R13 1-216-827-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-841-11 METAL CHIP 3.3K 1K 47K R13 1-216-843-11 METAL CHIP 68K R13 1-216-849-11 METAL CHIP 220K R14 1-216-841-11 METAL CHIP 47K R14 1-216-843-11 METAL CHIP 68K R14 1-216-849-11 METAL CHIP 220K R15 R16 1-216-815-11 METAL CHIP 1-216-821-11 METAL CHIP 330 1K R18 R20 R21 R22 R23 1-216-805-11 1-216-817-11 1-216-813-11 1-216-805-11 1-216-841-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47 470 220 47 47K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R24 R91 R92 R93 R94 1-216-809-11 1-216-837-11 1-216-823-11 1-216-821-11 1-216-837-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 22K 1.5K 1K 22K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R95 R96 R101 R102 R103 1-216-809-11 1-216-829-11 1-216-841-11 1-216-841-11 1-216-855-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 4.7K 47K 47K 680K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R104 R105 R106 1-216-835-11 METAL CHIP 1-216-835-11 METAL CHIP 1-216-820-11 METAL CHIP 15K 15K 820 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 5% 1/16W 5% 1/16W 5% 1/16W (EXCEPT FR,FS595) 5% 1/16W (FR) 5% 1/16W (FS595) 5% 1/16W (EXCEPT FR,FS595) 5% 1/16W (FR) 5% 1/16W (FS595) 5% 1/16W 5% 1/16W (E,9E,E7,FR,IT) Ref. No. Part No. Description Remark R107 1-216-795-11 RES,CHIP 6.8 5% R107 1-216-807-11 METAL CHIP 68 5% R108 R109 R201 1-216-841-11 METAL CHIP 1-216-829-11 METAL CHIP 1-216-841-11 METAL CHIP 47K 4.7K 47K 5% 5% 5% R202 R203 R204 R205 R206 1-216-841-11 1-216-855-11 1-216-835-11 1-216-835-11 1-216-820-11 47K 680K 15K 15K 820 5% 5% 5% 5% 5% R207 1-216-795-11 RES,CHIP 6.8 5% R207 1-216-807-11 METAL CHIP 68 5% R208 R209 R301 1-216-841-11 METAL CHIP 1-216-829-11 METAL CHIP 1-216-829-11 METAL CHIP 47K 4.7K 4.7K 5% 5% 5% R302 R303 R304 R305 R306 1-216-843-11 1-216-833-11 1-216-841-11 1-216-851-11 1-216-789-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 68K 10K 47K 330K 2.2 5% 5% 5% 5% 5% R307 R308 R331 1-216-845-11 METAL CHIP 1-216-829-11 METAL CHIP 1-216-837-11 METAL CHIP 100K 4.7K 22K 5% 5% 5% R332 1-216-797-11 METAL CHIP 10 R333 1-218-884-11 RES,CHIP 36K R401 R403 R404 R405 R503 1-216-845-11 1-216-821-11 1-216-845-11 1-216-813-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100K 1K 100K 220 10K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R504 R505 R506 R511 R512 1-216-821-11 1-216-837-11 1-216-833-11 1-216-817-11 1-216-851-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1K 22K 10K 470 330K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R513 R514 R601 R602 R603 1-216-853-11 1-216-829-11 1-216-809-11 1-216-845-11 1-216-830-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 470K 4.7K 100 100K 5.6K 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R604 R605 R606 R607 R608 1-216-830-11 1-216-832-11 1-216-817-11 1-216-817-11 1-216-817-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 5.6K 8.2K 470 470 470 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/16W 1/16W R609 R610 1-216-829-11 METAL CHIP 1-216-827-11 METAL CHIP 4.7K 3.3K 5% 5% 1/16W 1/16W – 33 – METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1/16W (EXCEPT FR) 1/16W (FR) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (EXCEPT FR) 1/16W (FR) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (FS595) 5% 1/16W (FS595) 0.50% 1/16W (FS595) WM-FS593/FS595 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. < VARIABLE RESISTOR > RV301 RV601 Remark ************** HARDWARE LIST ************** 1-230-593-11 RES, VAR, CARBON 10K/10K (VOL) 1-241-916-11 RES, ADJ, CARBON 4.7K #1 #2 #3 < SWITCH > S301 S601 Description 7-624-101-04 STOP RING 1.2 (E TYPE) 7-627-551-87 SCREW, PRECISION +P 1.4X1.8 7-627-850-57 SCREW, PRECISION +P 1.4X3.5 1-771-091-21 SWITCH, PUSH (1 KEY) (OPEN DET) 1-692-370-11 SWITCH, SLIDE (MD CONTROL) < TRANSFORMER > T1 T401 1-416-594-11 TRANSFORMER, IF 1-449-021-21 TRANSFORMER, DC/DC CONVERTER < THERMISTOR (POSITIVE) > TH601 1-803-124-11 THERMISTOR, POSITIVE < FILTER > X1 1-767-830-11 FILTER, CERAMIC (DISCRIMINATOR) ************************************************************* MISCELLANEOUS *************** 87 1-669-174-11 FLEXIBLE BOARD HP901 1-500-555-11 HEAD, MAGNETIC (PLAYBACK) M901 1-763-073-11 MOTOR ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 1-475-934-11 FLASHER (FLS-WM1) (FS595) 3-861-495-11 MANUAL, INSTRUCTION (ENGLISH) (US) 3-861-495-21 MANUAL, INSTRUCTION (ENGLISH,FRENCH, ITALIAN) (CND,E7,FR,IT) 3-861-495-31 MANUAL, INSTRUCTION (SPANISH, PORTUGUESE) (5E,E7) 3-861-495-41 MANUAL, INSTRUCTION (GERMAN,DUTCH, SWEDISH) (E7) 3-861-495-51 MANUAL, INSTRUCTION (ENGLISH,KOREAN, CHINESE) (E) 3-861-495-61 MANUAL, INSTRUCTION (ENGLISH,KOREAN, CHINESE) (9E) 3-937-075-01 STOPPER (BUCKLE) (US) 8-952-478-90 HEADPHONE MDR-E215/Y SET (YELLOW) (FS593:EXCEPT US,CND) 8-953-274-90 HEADPHONE MDR-W020LP/YO SET (YELLOW) (FS595) 8-953-284-90 HEADPHONE MDR-W014LP/RK SET (RED) (FS593:CND) 8-953-284-91 HEADPHONE MDR-W014LP/YK SET (YELLOW) (FS593:US,CND) X-3375-256-1 CLIP (BELT) ASSY (YELLOW) X-3375-652-1 CLIP (BELT) ASSY (RED) ************************************************************* Sony Corporation 9-924-906-11 Personal A&V Products Company – 34 – 98E0483-1 Printed in Japan C1998. 5 Published by Quality Engineering Dept. (Shibaura) WM-FS593/FS595 US Model Canadian Model SERVICE MANUAL WM-FS593/FS595 AEP Model E Model Ver 1.1 1999. 01 WM-FS593 SUPPLEMENT-1 File this supplement with the Service Manual previously issued. Subject : Saudi Arabia Model Addition WM-FS593 Saudi Arabia model is almost same as WM-FS593 AEP model. This Service Manual Supplement-1 contains only the points which differ from WM-FS593 AEP model. However accessories and packing materials are all listed. For the informations not contained in this manual, please refer to WM-FS593/FS595 service manual (9-924-906-∏) previously issued. 1. DIFFERENCE OF PARTS LIST Page WM-FS593 (AEP model) Ref. No. 27 Part No. 73 WM-FS593 (Saudi Arabia model) Description Remark 3-023-090-11 CABINET (REAR) (YELLOW) Part No. Description Remark 3-023-090-21 CABINET (REAR) (YELLOW) • Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) N N Parts Color Cabinet’s Color 2. ACCESSORIES & PACKING MATERIALS Ref. No. Part No. Description Remark 3-861-495-62 MANUAL, INSTRUCTION (ENGLISH, CHINESE, ARABIC) 8-952-478-90 HEADPHONE MDR-E215/Y SET (YELLOW) X-3375-256-1 CLIP (BELT) ASSY (YELLOW) Sony Corporation 9-924-906-81 Personal A&V Products Company 99A04088-1D Printed in Japan C1999. 1 Published by Quality Engineering Dept. (Shibaura)