. Xiaoyu163. Com Qq376315150 99 28 94 29 8

Transcript

http://www.xiaoyu163.com CFD-S22L/S32L QQ 376315150 892498299 SERVICE MANUAL AEP Model UK Model Ver 1.0 2000. 03 TEL TEL Model Name Using Similar Mechanism CD CD Mechanism Type Section Optical Pick-up Name Model Name Using Similar Mechanism TC Section Tape Transport Mechanism Type Radio section Frequency range CFD-S22L/S32L FM MW LW 87.5 - 108 MHz 531 - 1,602 kHz 531 - 279 kHz Cassette-corder section Recording system 4-track 2 channel stereo Fast winding time Approx. 120 sec. with Sony cassette C-60 Frequency response TYPE I (normal): 70 - 10,000 Hz General Speaker Full range: 10 cm (4 in.) dia., 3.2 ohms, cone type (2) Outputs Headphones jack (stereo minijack) For 16 - 68 ohms impedance headphones Maximum power output 2.3 W + 2.3 W Power requirements For CD radio cassette-corder: 230 V AC, 50 Hz 9 V DC, 6 R20 (size D) batteries For remote control (CFD-S32L only): 3 V DC, 2 R6 (size AA) batteries Power consumption AC 20 W – Continued on next page – IF FM: 10.7 MHz MW/LW: 450 kHz Aerials FM: Telescopic aerial MW/LW: Built-in ferrite bar aerial www xiaoy u163. com CD RADIO CASSETTE-CORDER . –1– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 CD player section System Compact disc digital audio system Laser diode properties Material: GaAlAs Wave length: 780 nm Emission duration: Continuous Laser output: Less than 44.6 µW (This output is the value measured at a distance of about 200 mm from the objective lens surface on the optical pick-up block with 7 mm aperture.) Spindle speed 200 r/min (rpm) to 500 r/min (rpm) (CLV) Number of channels 2 Frequency response 20 - 20,000 Hz +1/–2 dB Wow and flutter Below measurable limit QQ 376315150 892498299 SPECIFICATIONS QQ QQ TEL 13942296513 CFD-S38L KSM-213CDM KSS-213C CFD-S38L MF-S22-117 13942296513 13942296513 Photo: CFD-S32L http://www.xiaoyu163.com QQ 376315150 892498299 This Compact Disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the bottom exterior. Battery life For CD radio cassette-corder: FM recording Sony R20P: approx. 13.5 h Sony alkaline LR20: approx. 20 h Tape playback Sony R20P: approx. 7.5 h Sony alkaline LR20: approx. 15 h CD playback Sony R20P: approx. 2.5 h Sony alkaline LR20: approx. 7 h CAUTION Design and specifications are subject to change without notice. Notes on Chip Component Replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. www . xiaoy u163. com –2– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 QQ QQ TEL 13942296513 NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. 13942296513 13942296513 Flexible Circuit Board Repairing • Keep the temperature of the soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. TEL TEL Dimensions Approx. 420 × 165 × 256 mm (w/h/d) (16 5/8 × 6 1/2 × 10 1/8 inches) (incl. projecting parts) Mass Approx. 4.1 kg (9 lb. 1 oz.) (incl. batteries) Supplied accessories Mains lead (1) Remote control RMT-CS32AD (1) (CFD-S32L only) Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. http://www.xiaoyu163.com QQ 376315150 892498299 TABLE OF CONTENTS 1. SERVICING NOTES ......................................................... 4 2. GENERAL Location of controls ................................................................. 5 Adjusting the sound emphasis (MEGA BASS/TONE) ........... 5 Playing a CD ........................................................................... 6 Listening to the radio ............................................................... 6 Playing a tape .......................................................................... 7 Recording ................................................................................ 7 3. DISASSEMBLY 5. ELECTRICAL ADJUSTMENTS 6. DIAGRAMS QQ 376315150 892498299 6-1. IC Pin Description ............................................................. 17 6-2. Circuit Boards Location .................................................... 18 6-3. Block Diagram – CD Section – ......................................... 19 6-4. Block Diagram – Main Section – ...................................... 21 6-5. Printed Wiring Board – Tuner Section – ........................... 23 6-6. Schematic Diagram – Tuner Section – .............................. 25 6-7. Printed Wiring Board – CD Section – ............................... 27 6-8. Schematic Diagram – CD Section – .................................. 29 6-9. Schematic Diagram – PRE Section – ................................ 31 6-10. Printed Wiring Boards – Main Section – .......................... 33 6-11. Schematic Diagram – Main Section (1/2) – ...................... 35 6-12. Schematic Diagram – Main Section (2/2) – ...................... 37 6-13. Printed Wiring Board – Control Section – ........................ 39 6-14. Schematic Diagram – Control Section – ........................... 41 6-15. Printed Wiring Boards – Power Supply Section – ............ 43 6-16. Schematic Diagram – Power Supply Section – ................. 45 7. EXPLODED VIEWS 7-1. 7-2. 7-3. 7-4. 7-5. 7-6. Cabinet (Front) Section ..................................................... 50 Cabinet (Rear) Section ...................................................... 51 Cabinet (Upper) Section .................................................... 52 Tape Mechanism Section-1 ............................................... 53 Tape Mechanism Section-2 ............................................... 54 Optical Pick-up Section .................................................... 55 8. ELECTRICAL PARTS LIST ......................................... 56 www . xiaoy u163. com –3– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 QQ QQ Tape Section .......................................................................... 14 Tuner Section ......................................................................... 15 CD Section ............................................................................ 16 13942296513 13942296513 4. MECHANICAL ADJUSTMENTS ............................... 14 TEL TEL 3-1. Cabinet (Front) Sub Assy .................................................... 8 3-2. Wires ................................................................................... 9 3-3. Secondary Board, Power Board .......................................... 9 3-4. Tuner Board ....................................................................... 10 3-5. Cabinet (Upper) Block Assy ............................................. 10 3-6. Main Board ....................................................................... 11 3-7. CD Mechanism Block ....................................................... 11 3-8. Tape Mechanism Block ..................................................... 12 3-9. Holder Assy, Cassette ........................................................ 12 3-10. PRE Board ......................................................................... 13 http://www.xiaoyu163.com SECTION 1 SERVICING NOTES QQ 376315150 892498299 CHUCK PLATE JIG ON REPAIRING On repairing CD section, playing a disc without the lid (CD), use Chuck Plate Jig. • Code number of Chuck Plate Jig: X-4918-255-1 LASER DIODE AND FOCUS SEARCH OPERATION CHECK 1. Turn ON the OPERATE button and press FUNCTION button to CD position. 2. Open the lid (CD). 3. Turn on S501 with screwdriver, etc. as following figure. 4. Press the CD N X button. 5. Confirm the laser diode emission while observing the objecting lens. When there is no emission, Auto Power Control circuit or Optical Pick-up is broken. Objective lens moves up and down three times for focus search. TEL TEL . xiaoy u163. com –4– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 13942296513 13942296513 S501 http://www.xiaoyu163.com SECTION 2 GENERAL QQ 376315150 892498299 This section is extracted from instruction manual. TEL TEL 13942296513 13942296513 . xiaoy u163. com –5– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com QQ 376315150 892498299 TEL TEL 13942296513 13942296513 . xiaoy u163. com –6– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com QQ 376315150 892498299 TEL TEL 13942296513 13942296513 . xiaoy u163. com –7– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com SECTION 3 DISASSEMBLY QQ 376315150 892498299 • The equipment can be removed using the following procedure. Set Cabinet (Front) Sub Assy Wires Cabinet (Upper) Block Assy Main Board Secondary Board, Power Board Tuner Board Tape Mechanism Block Holder Assy, Cassette CD Mechanism Block PRE Board Note : Follow the disassembly procedure in the numerical order given. 3-1. CABINET (FRONT) SUB ASSY TEL TEL 9 cabinet (front) sub assy 7 CNP323 lid (CD) 2 BVTP 3x10 5 BVTP 3x10 1 lid, battery case 4 BVTP 3x12 3 BVTP 3x10 www . xiaoy u163. com –8– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 8 CNP501 QQ QQ QQ 376315150 892498299 TEL 13942296513 13942296513 13942296513 6 BVTP 3x12 http://www.xiaoyu163.com QQ 376315150 892498299 3-2. WIRES Put flat cable and wires between the cabinets and push them in the grooves located at A to G in the figure to prevent disconnection before assembling the set. CABINET (FRONT) B C D G CABINET (REAR) F 3-3. SECONDARY BOARD, POWER BOARD 5 CNP901 3 BVTP 3x10 SECONDARY board www xiaoy u163. com 6 POWER board . 2 BVTP 3x10 1 BVTP 3x10 4 CNP902 –9– http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 from speaker QQ QQ QQ 376315150 892498299 TEL 13942296513 13942296513 13942296513 E TEL TEL A http://www.xiaoyu163.com QQ 376315150 892498299 3-4. TUNER BOARD TEL TEL 4 13942296513 13942296513 5 TUNER board 1 CNP1 3 holder (PWB)(TU) 2 BVTP 3x10 6 BVTP 3x12 3 holder assy, cassette 7 BVTP 3x12 4 lid (CD) 5 BVTP 3x10 8 BVTP 3x12 9 handle 0 cabinet (upper) block assy www 2 CNP902 xiaoy u163. com cabinet (rear) . 1 CNP1 – 10 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 3-5. CABINET (UPPER) BLOCK ASSY QQ QQ QQ 376315150 892498299 TEL 13942296513 http://www.xiaoyu163.com QQ 376315150 892498299 3-6. MAIN BOARD 2 BVTP 3x10 1 BVTP 3x10 8 MAIN board 5 CNP322 3 connector (S501) TEL TEL 4 CNP651 6 CNP505 3-7. CD MECHANISM BLOCK 1 PWH 2.6x10 2 PWH 2.6x10 3 CD mechanism block www . xiaoy u163. com – 11 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 QQ QQ TEL 13942296513 13942296513 13942296513 7 CNP502 http://www.xiaoyu163.com QQ 376315150 892498299 3-8. TAPE MECHANISM BLOCK 1 BVTP 3x10 2 BVTP 3x10 3 tape mechanism block TEL TEL 13942296513 13942296513 3-9. HOLDER ASSY, CASSETTE 3 1 BVTP 3x10 2 DAMPER 4 holder assy, cassette www . xiaoy u163. com – 12 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com QQ 376315150 892498299 3-10. PRE BOARD 1 BVTP 2x4 2 PRE board 3 Removal the solders. TEL TEL 13942296513 13942296513 . xiaoy u163. com – 13 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513 http://www.xiaoyu163.com SECTION 4 MECHANICAL ADJUSTMENTS SECTION 5 ELECTRICAL ADJUSTMENTS QQ 376315150 892498299 PRECAUTION TAPE SECTION 1. Clean the following parts with a denatured-alcohol-moistened swab : record/playback head pinch roller erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. (Do not bring the head magnetizer close to the erase head.) 3. Do not use a magnetized screwdriver for the adjustments. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 0 dB = 0.775 V • Standard Output Level Output terminal HP OUT load impedance output signal level 32 Ω 0.25 V (–10 dB) • Test Tape Type Signal WS-48A 3 kHz, 0 dB Used for tape speed adjustment Torque Measurement Mode FWD CQ-102C 30 – 70 g • cm (0.42 – 0.97 oz • inch) FWD Back Tension CQ-102C 1.5 – 5.5 g • cm (0.021 – 0.076 oz • inch) FF CQ-201B more than 60 g • cm (more than 0.83 oz • inch) CQ-201B more than 60 g • cm (more than 0.83 oz • inch) REW Tape Speed Adjustment Procedure: Mode: playback digital frequency counter test tape WS-48A (3 kHz, 0 dB) 32 Ω set i jack (J321) Tape Tension Measurement Mode Meter Reading CQ-403A more than 100 g (more than 3.53 oz) QQ 376315150 892498299 Specification Value: Digital frequency counter 2,910 to 3,090 Hz Adjust so that the frequency at the beginning and that at the end of tape winding are between 2,910 to 3,090 Hz. Adjustment Location: www xiaoy u163. com Tape speed adjustment control inside motor . – 14 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 Adjust so that the value on the digital frequency counter is 3,000 Hz. QQ QQ FWD Tension meter 13942296513 13942296513 Meter reading TEL TEL Torque meter http://www.xiaoyu163.com QQ 376315150 892498299 TUNER SECTION 0 dB = 1 µV FM FREQUENCY COVERAGE ADJUSTMENT • FM Section Setting: RADIO (BAND) button: FM Frequency Display Reading on Digital voltmeter Adjustment Part FM RF signal generator TP (JW2) 87.5 MHz 1.6 ± 0.4 V 108 MHz 4.0 ± 0.3 V L2 FM TRACKING ADJUSTMENT 0.01 µF Adjust for a maximum reading on level meter. set L1 87.5 MHz 75 kHz frequency deviation by 1 kHz signal output level : as low as possible CT1 108 MHz FM IF ADJUSTMENT • MW/LW Section Setting: RADIO (BAND) button: MW or LW 10.7 MHz MW FREQUENCY COVERAGE CHECK Put the lead-wire antenna close to the set. Frequency Display Reading on Digital voltmeter Adjustment Part 30% amplitude modulation by 400 Hz signal 531 kHz 1.0 ± 0.5 V 1,611 kHz 5.2 ± 0.6 V MW TRACKING ADJUSTMENT • Connecting Level Meter (FM, MW and LW) QQ 32 Ω L3-1 621 kHz CT3 1,404 kHz MW/LW IF ADJUSTMENT Adjust for a maximum reading on level meter. T1 450 kHz set i jack (J321) • Connecting Digital Voltmeter (FM, MW and LW) digital voltmeter LW FREQUENCY COVERAGE ADJUSTMENT Frequency Display Reading on Digital voltmeter Adjustment Part 153 kHz 0.6 ± 0.3 V 279 kHz 5.0 ± 0.1 V L4 100 kΩ LW TRACKING ADJUSTMENT TP (VT) Adjust for a maximum reading on level meter. L3-2 162 kHz • Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. www . Adjustment Location: See page 16. xiaoy u163. com – 15 – http://www.xiaoyu163.com CT5 261 kHz 376315150 892498299 376315150 892498299 level meter (range: 0.5–5 V ac) 376315150 892498299 QQ QQ TEL 13942296513 Adjust for a maximum reading on level meter. 13942296513 13942296513 AM RF signal generator TEL TEL Adjust for a maximum reading on level meter. T2 http://www.xiaoyu163.com QQ 376315150 892498299 Adjustment Location: ANT1 FM TELESCOPIC ANTENNA – tuner board (component side) – T1 MW/LW IF ADJUSTMENT – tuner board (conductor side) – JW2 T2 FM IF ADJUSTMENT FM TRACKING ADJUSTMENT L1 CT1 IC1 TEL MW TRACKING ADJUSTMENT TP(VT) L3-1 CT3 IC2 CT5 L3-2 CNP1 CD SECTION CD section adjustments are done automatically in this set. In case of operation check, confirm that focus bias. FOCUS BIAS CHECK Test Point: 1. Connect the oscilloscope between IC701 pin qg (or TP (RF)) and GND on CD board. 2. Insert the disc (YEDS-18). (Part No. : 3-702-101-01) 3. Press the CD N X button. 4. Confirm that the oscilloscope waveform is as shown in the figure below. (eye pattern) A good eye pattern means that the diamond shape ( ) in the center of the waveform can be clearly distinguished. – CD board (conductor side) – TP (RF) • RF signal reference waveform (eye pattern) TP (RF) VOLT/DIV : 50 mV (10 : 1 probe in use) TIME/DIV : 500 nS RF level : 1.2 ± 0.3 Vp-p www xiaoy u163. com When observing the eye pattern, set the oscilloscope for AC range and raise vertical sensitivity. . – 16 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 QQ QQ LW TRACKING ADJUSTMENT TP (VT) TP (VT) 13942296513 13942296513 L4 LW FREQUENCY COVERAGE ADJUSTMENT GS TEL L2 FM FREQUENCY COVERAGE ADJUSTMENT http://www.xiaoyu163.com SECTION 6 DIAGRAMS QQ 3 7 6 3 1 5 1 5 0 6-1. IC PIN DESCRIPTION • IC501 CXP83620-022Q (SYSTEM CONTROL) 8 9 2 4 9 8 2 9 9 Pin Name I/O Pin Description 75 76 NC A-MUTE — O Not used. (Open) Audio mute output C-SCOR RMC I I CD SCOR input Sircs receiver input 77 78 SCL EC O I EEPROM clock output Event counter input 3 4 MUTE ADJ O O MUTE output H: Mute F TEX frequency division output 79 80 TC-PLAY C-DOOR I I Tape play switch input L: Tape CD door open/close switch input 5 6 C-SCLK C-SENS O I CD SENSE read clock output CD SENSE input 7 8 C-SQCK C-SQSO O I CD Sub-Q read clock output CD Sub-Q data input 9 10 C-XRST C-CLOCK O O CD system reset output CD system clock output 11 12 C-LATCH C-DATA O O CD system latch output CD command data output 13 14 C-AGCCONT R-COUNT O I CD AGC control output Tuner PLL data input 15 16 R-CLOCK R-DATA O O Tuner PLL clock output Tuner PLL data output 17 18 R-LATCH V-LATCH O O Tuner PLL latch output Volume latch output Not used. (Open) 19 20 V-DATA V-CLOCK O O Volume data output Volume clock output 21 22 P-CON REG CHK O I System power control output Regulator check signal input 23 24 25 – 28 REC SDA KEY-1 – 4 I I/O I 29 30 MODE CHECK RST I I Mode set input System reset input 31 32 EXTAL XTAL I O Oscillation input (4.19 MHz) Oscillation output (4.19 MHz) 33 34 VSS VL — O GND LCD drive port ON/OFF output 35 – 37 38 – 41 VLC3 – 1 COM0 – 3 O O LCD drive voltage output LCD drive common output 42 – 58 59 SEG0 – 16 SEG17 O O LCD drive segment output LCD drive segment output 60, 61 62 NC INIT — O Not used. (Open) Initial set signal output 63 64 TONE MEGA BASS O O TONE control output L: TONE-Hi, H: TONE-Lo MEGA BASS control output H: MEGA BASS off, L: MEGA BASS on 65 66 BT-CHK MT-CONT O O Battery check input H: BT-CHK MT control input H: MT-CONT 67 68 ISS1 ISS2 O O ISS1 output ISS2 output 69 70 TAPE RADIO O O Tape function output H: Tape Tuner function output H: Radio 71 72 CD VDD O — CD function output H: CD Power supply pin (+3.3 V) 73 74 TX TEX O I Oscillation output (153.6 kHz) Oscillation input (153.6 kHz) www . L: Close 6-2. CIRCUIT BOARDS LOCATION SECONDARY board POWER board BATTERY board PRE board MAIN board CD board H: PCON QQ 1 3 9 4 2 2 9 6 5 1 3 Tape record signal input EEPROM input/output Key input H: Mute H: REC 3 7 6 3 1 5 1 5 0 CONTROL board 8 9 2 4 9 8 2 9 9 HALF BATTERY board LCD board TUNER board SHILD board Not used. (Open) H: ISS1 H: ISS2 x ia o y u 1 6 3 – 17 – . c o m – 18 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 1 2 QQ QQ I/O 13942296513 13942296513 Pin Name TEL TEL Pin No. TEL Pin Description Pin No. http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-3. BLOCK DIAGRAM — CD SECTION — CD BOARD RF AMP IC701 CNP701 A 12 C 10 B 11 4 5 RFO PD1 FE TE 7 LD PD 5 LD POWER CONTROL Q701 2 3 51 RFDC 43 FE 39 SE 40 TE 41 VC 38 CE 42 13 11 LD PD OVER SAMPLING DIGITAL FILTER & SERIAL IN INTERFACE EFM DEMODULATOR D/A INTERFACE PD2 13 D 15 ASYMMETRY CORRECTION & DIGITAL PLL RFAC MAIN BOARD (1/2) SYSTEM SERVO PROCESSOR, DIGITAL SIGNAL PROCESSOR IC702 INTERNAL BUS OPERATIONAL AMPLIFIER ANALOG SWITCH & A/D CONVERTER CNP702(2/2) PWM AMP AOUT1 LOUT1 AOUT2 LOUT2 PWM AMP CNP502(2/2) 15 70 CNP505(1/3) 3 CD L 3 1 72 CD R 77 75 SUB CODE PROCESSOR LD ON SWITCH Q702 10 VC 19 LD ON AGC CONT 18 26 3 TEL 4 1 TRACKING COIL DRIVE TFDR 2 TRDR 3 FOCUS COIL DRIVE FFDR 24 FRDR 23 5 6 7 9 3 66 TF TR 67 VDD X701 16.9344MHz 1 3 9 4 2 2 9 6 5 1 3 17 F+ 18 F– 8 1 2 20 P. CONT FF FR QQ CNP702(1/2) 3 6 13 12 4 MUTE 20 9 2 POWER SWITCH Q951 D955 12 SL+ 11 SL– M M701 SPINDLE MOTOR SLED MOTOR DRIVE 15 SP+ 16 SP– M SFDR 5 SRDR 6 SF SR 15 12 5 6 14 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 8 7 5 11 AUDIO 6V REG Q955 VDD(SW) COM 3.3V REG Q957 9 10 11 13 7 AUDIO 6V CNP502(1/2) SPINDLE MOTOR DRIVE SPIN SLED/SPINDLE MOTOR DRIVE, TRACKING/FOCUS COIL DRIVE IC703 VREF D952 POWER SWITCH Q952,953 VDD COM 3.3V M702 SLED MOTOR D951 25 SECONDARY BOARD F902 27 POWER BOARD T901 POWER TRANSFORMER VREF CNJ901 AC IN D901 - 904 12 11 10 5 9 22 REG CHK 66 MT-CONT D509 CNB901(1/2) CD SYSTEM CONTROL IC501 (1/2) 1 70 RA6V • Signal path : CD AUDIO 6V 3.3V 3 CNP902 D956 3.3V REG 2 IC502 3 3 CNB901(2/2) VDD www R-ch : same as L-ch. 04 CD3.3V CD 3.3V REG Q511,512 1 1 COM 3.3V x ia o y u 1 6 3 3 . 4.5V DRY BATTERY SIZE " D " (IEC DESIGNATION R20) 6PCS,9V 71 KH321 RADIO 6V REG Q513,514 1 CD 65 BT-CHK RADIO D511 VDD(SW) REG,AC BATTERY CHECK Q501-504 6 8 7 1 C-DATA C-LATCH C-CLOCK C-SCLK C-XRST 80 C-DOOR VDD C-AGC CONT 13 S501 CD DOOR OPEN/ CLOSE C-SENS C-SQSO C-SQCK C-SCOR S702 (LIMIT) – 19 – AC-HI 2 2 . m 3 c o CNP904 1 2 CNP901 – 20 – http://www.xiaoyu163.com 4 3 BATTERY BOARD HALF BATTERY BOARD 4.5V 376315150 892498299 376315150 892498299 FOCUS COIL 13 T+ 14 T– 2 27 14 TIMING LOGIC QQ QQ TRACKING COIL CPU INTERFACE DIGITAL CLV MDP VREF OPTICAL PICK-UP BLOCK (KSS-213C) XTAO 16 VREF SERVO DSP & PWM GENERATOR XTAI 7 TFDR TF 30 TR TRDR 31 FFDR FF 32 FRDR FR 33 SFDR SF 28 SRDR SR 29 F XRST 8 DATA XLAT CLK SCLK 9 SERVO INTERFACE & SERVO AUTO SEQUENCER SENS SQSO SQCK SCOR F E SSTP XLON 14 13942296513 13942296513 E TEL TEL VREF http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-4. BLOCK DIAGRAM — MAIN SECTION — TC BOARD R.RO R.IN 8 R.LIN 14 MAIN BOARD (2/2) 9 CD R CNP301(1/3) CD L 1 4 24 3 HRP301 RECORD/PLAYBACK HEAD REC/PB PRE AMP IC301 DET L.RO L.LIN ALC 2 L.LO 6 20 LINE AMP Q121 6 8 VOUT2 VIN2 POWER AMP IC304 7 11 L.IN RADIO L -1 -2 21 22 LOGIC CONTROL CD3.3V TAPE 15 J321 i 5 SP301 SPEAKER (L-CH) EEPROM IC504 LPF Q123 5 4 16 R-CH MUTE Q124 CLOCK DATA L.RAD REC S301 (REC/PB) REC R.RAD 6 REF ISS2 Q302 ISS1 Q303 8 8 LINE 17 R-CH MEGA BASS CONTROL Q122 R-CH R.LO 18 5 L-CH HE301 ERASE HEAD VOLUME/SOUND CONTROL IC302 CNP505 (3/3) CNP301 (3/3) SP302 SPEAKER (R-CH) 5 SDA 6 SCL (S32L) R-CH P.CONT CNP322 2 VDD(SW) REC BIAS OSC Q301 10 12 13 5 1 9 10 12 13 5 1 9 S304 (TAPE PLAY) 3 4 M M301 CAPSTAN/REEL MOTOR CNP505(2/3) 1-4 CNP651 17-1 QQ 2 VDD(SW) 2-5 7 2-5 7 1 5 KH504 5 4 3 2 1 6 2 7 8 9 10 11 XIN MO/ST IF IN BAND BAND ST-IND 20 19 13 10 7 9 8 -1 MW MIX-OUT 4 AM MIX AM IF-IN T1 6 FM MIX MW SW Q42 18 LPF1/BAND ST-IND IF CUT IF BUFFER (S32L) FM IF-IN RA6V CT1 RA6V D1 D2 RA6V L2 FM FREQUENCY COVERAGE INIT MODE CHECK TC-PLAY D601 OPR/BATT 8 REMOTE CONTROL REG Q509 T2 MW/LW IF AC-HI 3 TUNER BOARD AM HIGH CUT Q12 DET-OUT 16 MPX-IN 15 FM MPX R 11 MUTE L 12 R-CH IF CUT T1 L2 SCL P-CON MODE SWITCH CONTROL Q505,506 8 FM DET 10 RA6V VDD (SW) (S32L) T2 x ia o y u 1 6 3 L1 6 AM DET CF2 FN RF-OUT FN OSC 24 21 2 13 AF BUFFER 7 FM OSC FM RF-IN 17 CF4 RA6V RA6V L3 MW/LW FERRITE-ROD ANTENNA CT1,L1 FM TRACKING S601-604 S607-626 S605,627 (S32L) S606 (S22L) 6 QUAD AM RF-IN 22 MODE SWITCH Q507 CONTROL BOARD 14 LPF2/MO-ST AM OSC FM/MW/LW FRONT-END, IF DET, FM STEREO DEMODULATOR IC1 IF-OUT 19 OSC-OUT CT5 MW SW Q41 04 20 LW SW Q43 -2 LW KH503 X1 75kHz RA6V . DO LW SW Q44 CT3 www 11 12 29 8 9 2 4 9 8 2 9 9 PLL IC2 XOUT 6 MW/LW L4 CE AM IN DI FM IN CL MW/LW Q14 CT3,L3-1 MW TRACKING ANT1 FM TELESCOPIC ANTENNA 1 2 3 4 18 LP-OUT D3 SDA 1 REMOTE CONTROL IC601 3 CNP1 L4 LW FREQUENCY COVERAGE AM OSC CT5,L3-2 LW TRACKING CNP501 62 CNP601 3.3V LCD BOARD REG Q61 79 3 7 6 3 1 5 1 5 0 IF REQ Q510 RESET IC503 X502 153.6kHz LIQUID CRYSTAL DISPLAY PANEL LCD501 21 A-MUTE 2 24 77 FM IF RA6V – 21 – . c o m – 22 – http://www.xiaoyu163.com Signal path : FM : AM : TAPE PLAY : TAPE REC : CD R-ch : same as L-ch. 376315150 892498299 376315150 892498299 21-18 25–28 76 (S32L) 1 X501 4.19MHz VOL 63 TONE 3 64 MEGA BASS 30 RMC 32 KEY1 | KEY4 MUTE 31 5-21 V-CLOCK V-DATA RST 73•74 1 3 9 4 2 2 9 6 5 1 3 CNP551 TAPE XTAL 17 16 15 14 42–58 20 19 EXTAL REC 38–41 SYSTEM CONTROL IC501 (2/2) TX TEX ISS2 69 TUNER R-LATCH R-DATA R-CLOCK R-COUNT 23 COM0 | COM3 SEG0 | SEG16 68 QQ QQ TEL 67 ISS1 AUDIO 6V 13942296513 13942296513 CNP301(2/3) TAPE SWITCH Q997 1 2 TEL TEL T301 PB http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-5. PRINTED WIRING BOARD — TUNER SECTION — • Refer to page 18 for Circuit Boards Location. 1 2 3 4 5 6 7 A • Semiconductor Location B IC1 IC2 D-5 H-5 Q12 Q14 Q41 Q42 Q43 Q44 Q61 F-5 H-3 G-3 E-3 G-3 G-4 G-4 13942296513 13942296513 Location E-4 E-4 F-4 B-3 B-3 TEL TEL C Ref. No. D1 D2 D3 D10 D11 D -2 LW QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 TP(VT) G DGS H I J 04 www Note on Printed Wiring Boards: • X : parts extracted from the component side. f • : internal component. • b : Pattern from the side which enables seeing. . (Page 34) x ia o y u 1 6 3 (Page 33) – 23 – . c o m – 24 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 F 1 3 9 4 2 2 9 6 5 1 3 -1 MW QQ QQ TEL E http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-6. SCHEMATIC DIAGRAM — TUNER SECTION — • Refer to page 47 for IC Block Diagrams. TEL TEL 13942296513 13942296513 QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL (Page 36) (Page 36) www . x ia o y u 1 6 3 – 25 – Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. f • : internal component. • U : B+ Line. • H : adjustment for repair. • Power voltage is dc 9V and fed with regulated dc power supply from battery terminal. . c o m – 26 – http://www.xiaoyu163.com • Voltage and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM ( ) : MW < > : LW • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Signal path. F : FM f : MW http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 6-7. PRINTED WIRING BOARD — CD SECTION — • Refer to page 18 for Circuit Boards Location. 2 1 3 4 5 6 7 8 9 8 9 2 4 9 8 2 9 9 • Waveforms (MODE: PLAY) 10 1 100mV/div 20nsec/div 2.2Vp-p A • Semiconductor Location Ref. No. IC701 IC702 IC703 Location H-7 E-5 B-5 Q701 Q702 F-8 J-7 16.9344MHz IC702 yj (XTAO) 2 100mV/div 2µsec/div 2Vp-p B 7.6µsec IC702 wh (MDP) 3 50mV/div 500nsec/div 4 100mV/div 1µsec/div C763 C764 D 2.5V Approx. 200mVp-p IC701 qd (FE) TP (RF) C766 C773 5 100mV/div 1µsec/div 1 3 9 4 2 2 9 6 5 1 3 QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2qa 9 9 Approx. 100mVp-p IC701 F G H I J 04 www . x ia o y u 1 6 3 – 27 – . c o m Note on Printed Wiring Boards: • X : parts extracted from the component side. • b : Pattern from the side which enables seeing. – 28 – http://www.xiaoyu163.com (TE) 376315150 892498299 376315150 892498299 TEL 2.5V QQ QQ (Page 33) E 13942296513 13942296513 IC701 qg (RFO) TEL TEL 1.2±0.3Vp-p C http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-8. SCHEMATIC DIAGRAM — CD SECTION — • Refer to page 47 for IC Block Diagrams. (Page 35) TEL TEL 13942296513 13942296513 QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. www m Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. . x ia o y u 1 6 3 c o • U : B+ Line. • Power voltage is dc 9V and fed with regulated dc power supply from battery terminal. – 29 – . • Voltage and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : CD STOP : Impossible to measure ∗ • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Circled numbers refer to waveforms. • Signal path. J : CD – 30 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-9. SCHEMATIC DIAGRAM — PRE SECTION — • Refer to page 48 for IC Block Diagrams. • Semiconductor Location 0.1V/div 5µsec/div 4Vp-p 19.5µsec Q301 C (REC) www . x ia o y u 1 6 3 – 31 – . c o ( ) : CFD-S32L only Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • C : panel designation. • U : B+ Line. • Power voltage is dc 9V and fed with regulated dc power supply from battery terminal. • Voltage and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM ( ) : PB < > : REC [ ] : CD STOP • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Signal path. F : FM E : PB a : REC J : CD m Note on Printed Wiring Boards: • X : parts extracted from the component side. • b : Pattern from the side which enables seeing. – 32 – http://www.xiaoyu163.com E-12 E-11 376315150 892498299 376315150 892498299 1 Q121 Q122 8 9 2 4 9 8 2 9 9 (Page 35) • Waveform C-3 E-10 F-12 H-9 H-10 I-8 G-7 Location G-11 G-12 E-11 E-11 F-11 G-12 B-2 B-3 B-3 D-8 D-8 E-8 E-8 I-8 E-8 I-8 E-7 D-9 D-7 D-7 B-9 C-8 D-13 D-13 D-13 D-12 C-13 B-13 QQ QQ QQ 3 7 6 3 1 5 1 5 0 IC301 IC302 IC304 IC501 IC502 IC503 IC504 Ref. No. (Q123) Q124 Q221 Q222 (Q223) Q224 Q301 Q302 Q303 Q501 Q502 Q503 Q504 Q505 Q506 Q507 (Q509) Q510 Q511 Q512 Q513 Q514 Q951 Q952 Q953 Q955 Q957 Q997 13942296513 13942296513 1 3 9 4 2 2 9 6 5 1 3 Location G-11 H-11 B-10 C-8 C-8 E-7 E-7 E-8 E-8 E-8 E-8 D-13 C-13 E-13 C-13 H-11 C-13 TEL TEL TEL Ref. No. D322 D323 D324 D504 D505 (D506) (D507) (D508) D509 D510 D511 D951 D952 D953 D955 D956 D957 http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 6-10. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 18 for Circuit Boards Location. 2 1 3 4 5 6 7 A 8 (Page 23) 8 9 2 4 9 8 2 9 9 9 10 11 12 13 14 B (Page 28) TEL TEL C (Page 43) L-CH 376315150 892498299 R-CH 1 3 9 4 2 2 9 6 5 1 3 (Page 23) QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 F G H LIQUID CRYSTAL DISPLAY PANEL I J www 04 (Page 40) . x ia o y u 1 6 3 – 33 – . c o m – 34 – http://www.xiaoyu163.com 376315150 892498299 TEL QQ QQ E 13942296513 13942296513 D http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 32 for Note on Schematic Diagram and page 48 for IC Block Diagrams. TEL TEL (Page 41) 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 (Page 37) www . x ia o y u 1 6 3 (Page 29) (Page 26) (Page 26) – 35 – . c o m – 36 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL 13942296513 13942296513 (Page 32) http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 32 for Note on Schematic Diagram and page 48 for IC Block Diagrams. TEL TEL 13942296513 13942296513 www QQ 3 7 6 3 1 5 1 5 0 (Page 35) . (Page 46) x ia o y u 1 6 3 – 37 – . c o 8 9 2 4 9 8 2 9 9 m – 38 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 6-13. PRINTED WIRING BOARD — CONTROL SECTION — • Refer to page 18 for Circuit Boards Location. 1 2 3 4 5 6 7 8 9 8 9 2 4 9 8 2 9 9 10 11 12 13 14 (Page 33) A B TEL TEL 13942296513 13942296513 C D 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 F G OPR/BATT H 04 www • Semiconductor Location . Note on Printed Wiring Boards: • X : parts extracted from the component side. • b : Pattern from the side which enables seeing. Ref. No. D601 Location G-5 (IC601) G-10 x ia o y u 1 6 3 ( ) : CFD-S32L only – 39 – . c o m – 40 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL E http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-14. SCHEMATIC DIAGRAM — CONTORL SECTION — (Page 36) TEL TEL 13942296513 13942296513 www . QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • C : panel designation. • U : B+ Line. • Power voltage is dc 9V and fed with regulated dc power supply from battery terminal. • Voltage and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. x ia o y u 1 6 3 – 41 – . c o m – 42 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 6-15. PRINTED WIRING BOARDS — POWER SUPPLY SECTION — • Refer to page 18 for Circuit Boards Location. 1 2 3 4 5 6 7 8 9 8 9 2 4 9 8 2 9 9 10 11 A • Semiconductor Location Ref. No. D901 D902 D903 D904 DRY BATTERY SIZE " D " (IEC DESIGNATION R20) 3PCS, 4.5V B Location J-10 I-10 J-9 I-9 TEL TEL C 13942296513 13942296513 DRY BATTERY SIZE " D " (IEC DESIGNATION R20) 3PCS, 4.5V D 1 3 9 4 2 2 9 6 5 1 3 QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 F G T901 POWER TRANSFORMER H I J www (Page 34) 04 . x ia o y u 1 6 3 – 43 – . c o m Note on Printed Wiring Boards: • X : parts extracted from the component side. • b : Pattern from the side which enables seeing. – 44 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL QQ QQ E http://www.xiaoyu163.com CFD-S22L/S32L QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 6-16. SCHEMATIC DIAGRAM — POWER SUPPLY SECTION — (Page 38) TEL TEL 13942296513 13942296513 QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • C : panel designation. www Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. . x ia o y u 1 6 3 – 45 – . c o m • U : B+ Line. • Total current is measured with no cassette installed. • Power voltage is dc 9V and fed with regulated dc power supply from battery terminal. – 46 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 1 3 9 4 2 2 9 6 5 1 3 QQ QQ TEL http://www.xiaoyu163.com QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 • IC Block Diagrams IC1 TA2149N AF IF-IN 6 AM IF LEVEL DET 1/8 20 AM OSC 1/1 OR 1/16 19 OSC-OUT 10k 10k VCC 2k 15 MPX- IN PD1 8k VC DECODE 13 LPF1/BAND 54k 2k VEE VC 10k PD2 TAPE TAPE ON 7dB 20 L.LO LOGIC 19 VCC 18 R.LO MONITOR AMP MUTE RADIO 16 R.RAD 15 TAPE 14 R.LIN LINE BUF AMP A2 MIC AMP1 VC 14 LPF2/MO-ST VCO DIVIDE L-OUT 12 R.PO 11 6k 6p 7dB 17 LINE NAB AMP2 VC 4 ST/MO FM/AM MUTE 26dB R.NF 10 15k 10k BUF AMP B2 REC AMP2 ON 13 MIC MIC.NF 12 15 RF O 13942296513 13942296513 AF BUF AMP MUTE MONITOR AMP B1 R.RO 9 17 RFTC 16 RF I VC 2.1 R.IN 8 50µA 17 IF-OUT REF AMP GND 7 18 AGCCONT VC IF REQ FM DET R-OUT 11 REF 6 22 L.RAD 21 REC 56k 10k RADIO 26dB L.IN 5 55k 18 ST-IND 16 DET-OUT QUAD 10 L.RO 4 VEE 23 MIC I/EX TAPE REC AMP1 VEE SW AF BUFF AGC 19 LD ON 3 13.4k 670mV AM DET L.NF 3 24 L.LIN TEL TEL AGC 9 APC LD AMP 56k VREF 1.25V FM IF GND2 8 PD APC PD AMP VCC 10k AM OSC ST IF BUFF FM IF-IN 7 LD 2 NAB AMP1 BUF AMP A1 TAPE BUFF BUFF VCC2 5 1k LINE L.PO 2 20 VCC MUTE 21 FM OSC VCC DET FM OSC FM MIX AGCVTH 1 ALC2 ALC1 23 VCC1 22 AM RF-IN AM MIX AM LOW CUT 3 MIX OUT 4 AGC 1 24 FM RF-OUT FM RF FM RF-IN 2 IC301 TA2068N ON GND1 1 IC701 CXA2550M 2k 5 14 RFM VC 8k 2k 6p 24p 32k 174k 32k VEE 6 25k 1 3 9 4 2 2 9 6 5 1 3 260k 1 2 3 4 F E 7 13k VC 12p 30k VC 12p 30k 8 260k CCB I/F 13k VCC 19 XIN EI 26k 9 30k 5 MW/LW 6 BAND 7 ST-IND 8 BAND 9 12BITS PROGRAMMABLE DIVIDER DATA SHIFT REGISTER LATCH MUTE PHASE DETECTOR CHARGE PUMP VIN2 VOUT2 VCC CLOCK 8 9 2 4 9 8 2 9 9 8 7 6 5 VREF LOGIC CONTROL 11 TE VR 2 TRACKING VC ERROR AMP VOL AMP 2 VOL AMP 1 REF AMP 30k VC 18 LP-OUT 17 LP-IN 16 PD QQ IC302 M62429P 49 VC 10 REFERENCE DIVIDER 95k 3 7 6 3 1 5 1 5 0 96k VC 20 XOUT 12 FE BIAS VC 15k VR 1 VEE 1 2 3 4 VIN1 VOUT1 GND DATA 15 VSS UNLOCK DETECTOR POWER ON RESET 14 VDD IC504 BR2401A-W 13 MO/ST UNIVERSAL COUNTER SWALLOW COUNTER 1/16,1/17 4BITS 1/2 12 FM IN A0 8 VCC www 8BIT 7BIT 11 AM IN A1 IF IN 10 1K BIT EEPROM ARRAY 1 2 ADDRESS DECODER 7BIT SLAVE • WORD ADDRESS REGISTER START x ia o y u 1 6 3 A2 . GND 3 4 – 47 – STOP c o CONTROL CIRCUIT . HIGH VOLTAGE OCCURENCE CIRCUIT POWER SUPPLY VOLTAGE DETECTION DATA REGISTER m 6 SCL ACK – 48 – http://www.xiaoyu163.com 7 WP 5 SDA 376315150 892498299 376315150 892498299 TEL IC2 LC72137M-TLM CE DI CL DO 24p VC 13 FE FOCUS ERROR 154k AMP QQ QQ VEE 87k http://www.xiaoyu163.com QQ 376315150 892498299 DOUT VDD VSS AVDD PCO FILI FILO CLTV AVSS RFAC BIAS ASYI ASYO AVDD IGEN AVSS ADIO RFDC CE TE IC702 CXD2587Q 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 LRCK 61 D/A INTERFACE PCMD 62 ERROR CORRECTOR INTERNAL BUS DIGITAL OUT DIGITAL PLL 40 SE 39 FE 38 VC ASYMMETRY CORRECTION 16K RAM OPERATIONAL AMPLIFIER ANALOG SWITCH EFM DEMODULATOR BCK 63 A/D CONVERTER EMPH 64 XVDD 65 CLOCK GENERATOR TIMING LOGIC SERVO DSP SUBCODE PROCESSOR LOUT1 72 PWM AVSS1 73 AVSS2 74 PWM 3rd ORDER NOISE SHAPER LOUT2 75 AIN2 76 PWM GENERATOR FOCUS SERVO FOCUS PWM GENERATOR TRACKING SERVO TRACKING PWM GENERATOR SLED SERVO SLED PWM GENERATOR SERVO AUTO SEQUENCER SERIAL IN INTERFACE 24 FOK 23 DFCT 22 MIRR SCLK VDD ATSK C2PO SCOR 9 10 11 12 13 14 15 16 17 18 19 20 4 WFCK XUGF XPCK GFS 5 6 7 8 DATA XLAT CLK SENS CPU INTERFACE SYSM XRST MIRR, DFCT, FOK DETECTOR VREF NC SPIN FFDR FRDR CAP3 GND MUTE VCC F– F+ SP– SP+ 28 27 26 25 24 23 22 21 20 19 18 17 16 15 10k 50k POWER VCC 100k PRE VCC F R R MUTE + – 190k DRIVE BUFFER VCC IC703 BA5974FP-E2 30k INTERFACE F LEVEL SHIFT POWER VCC 50k 30k F THERMAL SHUTDOWN VREF INTERFACE xiaoy u163. com INTERFACE F R R 9 10 11 12 13 14 T+ T- SRDR 8 SL+ SFDR 7 SL- 6 VCC 5 VREFIN 4 GND 3 POWER VCC CAP2 2 CAP1 . TRDR VREFOUT 1 F R TFDR www R – 49 – http://www.xiaoyu163.com DRIVE BUFFER F 376315150 892498299 376315150 892498299 SQSO SQCK 26 MDP 25 LOCK QQ QQ 3 DIGITAL CLV QQ 376315150 892498299 TEL 13942296513 1 2 FRDR FFDR TRDR TFDR SRDR SFDR 21 COUT SPOA SPOB XLON RMUT 79 LMUT 80 33 32 31 30 29 28 27 SSTP SERVO INTERFACE OVER SAMPLING DIGITAL FILTER AOUT2 77 AVDD2 78 37 XTSL 36 TES1 35 TEST 34 VSS 13942296513 13942296513 66 67 68 69 70 71 TEL TEL XTAI XTAO XVSS AVDD1 AOUT1 AIN1 http://www.xiaoyu163.com SECTION 7 EXPLODED VIEWS QQ 376315150 892498299 NOTE: • The mechanical parts with no reference number in the exploded views are not supplied. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • Abbreviation IT : Italian model CET : East European & CIS model • Accessories and packing materials and hardware (# mark) list are given in the last of this parts list. • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet’s Color The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. 7-1. CABINET (FRONT) SECTION 13942296513 13942296513 #1 SP301 TEL TEL 9 #1 #2 #1 10 #1 7 not supplied 10 #2 376315150 892498299 3 10 #1 10 8 6 4 #1 2 SP302 1 Ref. No. Part No. Description 1 1 2 2 3 X-3378-563-1 X-3378-565-1 3-042-646-01 3-042-646-11 3-042-652-01 CABINET (FRONT) SUB ASSY (S22L) CABINET (FRONT) SUB ASSY (S32L) WINDOW (LCD) (S22L) WINDOW (LCD) (S32L) BUTTON (TEN KEY) 4 4 5 6 3-042-651-01 3-042-651-11 3-042-650-01 3-042-649-01 BUTTON (POWER) (S22L) BUTTON (POWER) (S32L) BUTTON (CD) BUTTON (FUNCTION) www . Remark Ref. No. Part No. Description * 7 * 7 8 8 9 A-3322-447-A A-3322-470-A 1-792-206-11 1-792-207-11 3-045-772-11 CONTROL BOARD, COMPLETE (S22L) CONTROL BOARD, COMPLETE (S32L) CABLE, FLEXIBLE FLAT (6 CORE) (S22L) CABLE, FLEXIBLE FLAT (8 CORE) (S32L) LID, BATTERY CASE 10 SP301 SP302 4-951-620-11 SCREW (2.6X10), +BVTP 1-529-215-11 SPEAKER (10cm) (L-CH) 1-529-215-11 SPEAKER (10cm) (R-CH) xiaoy u163. com – 50 – http://www.xiaoyu163.com Remark 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 QQ QQ 5 http://www.xiaoyu163.com QQ 376315150 892498299 7-2. CABINET (REAR) SECTION #1 #2 #2 #2 TEL TEL 56 57 13942296513 13942296513 61 59 #1 60 59 63 T901 57 F902 QQ 376315150 892498299 #1 62 54 #1 #1 64 55 51 #1 52 #1 64 53 Ref. No. Part No. Description 51 51 51 * 52 53 3-041-557-21 3-041-557-31 3-041-557-51 A-3322-563-A 3-041-560-01 * 54 * 55 56 57 1-676-629-11 1-676-530-11 3-036-886-51 4-960-167-01 www . The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Remark Ref. No. Part No. Description CABINET (REAR) (S22L:AEP,UK,IT) CABINET (REAR) (S32L:AEP,UK,IT) CABINET (REAR) (CET) TUNER BOARD, COMPLETE HOLDER (PWB) (TU) * 58 59 60 * 61 62 1-676-628-11 3-028-154-01 3-041-562-01 1-676-627-11 3-034-633-01 HALF BATTERY BOARD TERMINAL (–), BATTERY TERMINAL (REAR), ANTENNA BATTERY BOARD COVER (VOL SEL) SECONDARY BOARD POWER BOARD HANDLE SCREW (3X8) (DIA.10), +WH 63 64 0 F902 0 T901 3-047-439-01 3-363-898-01 1-532-464-51 1-433-578-11 CUSHION CUSHION FUSE (T2.5AL 250V) TRANSFORMER, POWER xiaoy u163. com – 51 – http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 TEL 13942296513 QQ QQ 58 http://www.xiaoyu163.com QQ 376315150 892498299 7-3. CABINET (UPPER) SECTION 117 ANT1 113 114 112 #1,#9 115 S501 LCD501 118 119 111 #1,#9 110 136 122 121 131 MF-S22-117 #1,#9 133 130 not supplied #1,#9 124 #1,#9 KSM-213CDM 129 #3 103 QQ 376315150 892498299 126 102 116 135 #1,#9 101 128 127 #1,#9 Ref. No. Part No. Description * 101 * 101 102 * 103 * 104 A-3322-561-A A-3322-603-A 1-792-203-11 3-041-554-01 A-3322-560-A 105 106 107 108 109 110 111 * 112 * 113 114 Ref. No. Part No. Description MAIN BOARD, COMPLETE (S22L) MAIN BOARD, COMPLETE (S32L) CABLE, FLEXIBLE FLAT (13 CORE) LEVER (REC) PRE BOARD, COMPLETE 120 121 * 122 123 124 3-041-559-31 3-923-736-01 3-041-561-01 3-038-948-01 3-038-948-11 CABINET (UPPER) COVER, CD TERMINAL (TOP), ANTENNA RUBBER, VIBRATION PROOF RUBBER, VIBRATION PROOF 3-045-771-31 3-045-770-31 3-045-769-31 3-045-768-31 3-045-767-31 BUTTON (PAUSE) BUTTON (STOP) BUTTON (FF) BUTTON (REW) BUTTON (PLAY) 125 126 * 127 128 129 3-921-725-01 1-792-209-11 A-3322-451-A 1-792-208-11 3-031-561-01 SCREW (2.6X10), +PWH WIRE, PARALLEL (16 CORE) CD BOARD, COMPLETE WIRE, PARALLEL (17 CORE) SPRING (CASSETTE) 3-045-766-31 1-792-205-11 3-041-646-01 1-676-531-11 3-922-112-21 BUTTON (REC) CABLE, FLEXIBLE FLAT (21 CORE) HOLDER (LCD) LCD BOARD DAMPER 130 131 132 133 134 4-960-167-01 3-031-560-01 3-922-112-41 3-031-562-01 4-951-620-01 SCREW (3X8) (DIA.10), +WH SHAFT (MD) DAMPER SPRING (CD) SCREW (2.6X8), +BVTP 135 136 ANT1 LCD501 S501 3-363-898-01 3-831-441-11 1-501-883-21 1-803-873-11 1-692-960-11 CUSHION CUSHION (B) ANTENNA, TELESCOPIC DISPLAY PANEL, LIQUID CRYSTAL SWITCH, PUSH (1 KEY) (CD DOOR OPEN/CLOSE) www 115 116 117 118 119 X-3378-728-1 3-048-457-01 3-036-885-71 1-452-899-11 3-019-395-01 Remark #5 xiaoy u163. com HOLDER ASSY, CASSETTE TAPE (CD SHIELD PLATE) LID (CD) MAGNET PLATE, CHUCKING . – 52 – http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 TEL 13942296513 124 125 QQ QQ 134 123 125 125 #3 104 123 125 #1,#9 #4 #4 120 132 13942296513 13942296513 109 108 107 106 105 #7 TEL TEL #6 http://www.xiaoyu163.com QQ 376315150 892498299 7-4. TAPE MECHANISM SECTION-1 (MF-S22-117) 159 HRP301 HE301 TEL TEL 170 160 161 157 13942296513 13942296513 158 162 164 168 167 163 165 169 156 154 153 166 151 152 Ref. No. Part No. Description Ref. No. Part No. Description 151 152 153 154 155 3-933-010-01 3-933-025-01 3-040-857-01 3-933-024-01 3-933-019-01 SPRING (S/P), TORSION SPRING (P), TORSION LEVER (P) ROLLER, PINCH SPRING (F/R), TORSION * 162 * 163 164 * 165 * 166 3-008-587-01 3-008-591-01 3-933-004-01 3-933-021-01 3-933-006-01 SLIDER (STOP) SLIDER (PAUSE) CLAW, REEL SLIDER (FRP) SLIDER (EJECT) 156 157 158 159 * 160 3-933-028-01 3-933-016-01 3-008-590-01 3-008-592-01 3-008-588-01 SPRING (FWD), TORSION GEAR (S REEL) SLIDER (REC) BASE (H), HEAD SLIDER (REW) 167 168 169 * 170 HE301 3-934-833-01 3-022-794-02 3-933-007-01 3-012-114-01 1-543-876-11 SPRING (FRP) SPRING (BT) PLATE, LOCK LEVER (FR) HEAD (ERASE) * 161 3-008-589-13 SLIDER (FF) www . Remark xiaoy u163. com Remark HRP301 1-500-454-11 HEAD, MAGNETIC (RECORD/PLAYBACK) – 53 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 QQ QQ 155 http://www.xiaoyu163.com QQ 376315150 892498299 7-5. TAPE MECHANISM SECTION-2 (MF-S22-117) 207 206 211 208 212 TEL TEL 205 219 13942296513 13942296513 204 203 S304 220 218 M301 376315150 892209498299 210 217 214 #8 201 Ref. No. 215 216 202 Part No. Description Part No. Description 201 202 203 204 205 3-933-029-01 3-933-182-01 3-932-995-01 X-3371-667-1 3-932-997-01 LEVER, ERASING PREVENTION SPRING, CASSETTE GEAR (MID) CLUTCH ASSY GEAR (CAM) 212 213 214 215 216 X-3372-924-1 3-932-993-01 3-343-358-01 3-933-005-01 3-016-349-01 FLYWHEEL ASSY CHASSIS, OUTSERT RING, RETAINING SPRING (CAM), COMPRESSION WASHER * 206 207 208 209 210 3-932-999-01 3-932-998-01 3-009-648-01 3-936-438-01 X-3373-572-1 SLIDER (SW) SPRING (GROUND), TORSION LEVER (S.OFF) LEVER (K) REEL ASSY (N), T 217 218 219 220 M301 3-937-760-01 3-934-336-01 3-939-383-02 3-009-650-02 A-3320-446-A SPRING (GROUND), COMPRESSION BEARING SPRING, COMPRESSION SPRING (K), COMPRESSION MOTOR ASSY (CAPSTAN/REEL) S304 1-692-302-11 SWITCH, LEAF (TAPE PLAY) www 211 . 3-933-020-01 BELT Remark Ref. No. xiaoy u163. com – 54 – http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 QQ TEL 13942296513 QQ QQ 213 http://www.xiaoyu163.com QQ 376315150 892498299 7-6. OPTICAL PICK-UP SECTION (KSM-213CDM) 255 not supplied TEL TEL 251 13942296513 13942296513 256 252 254 M701 M702 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. www Ref. No. Part No. 0 251 252 253 254 8-848-483-05 3-713-786-51 2-626-908-01 X-2626-202-1 . xiaoy u163. com Description Remark PICK-UP, OPTICAL KSS-213C SCREW +P 2X3 SHAFT, SLED CHASSIS ASSY (MB), MOTOR (SPINDLE) (INCLUDING M701) Ref. No. 255 256 M702 Part No. Description 2-626-907-01 GEAR (A) 2-627-003-02 GEAR (B) (RP) X-2625-769-1 GEAR ASSY (MB), MOTOR (SLED) – 55 – http://www.xiaoyu163.com Remark 376315150 892498299 376315150 892498299 253 QQ QQ QQ 376315150 892498299 TEL 13942296513 http://www.xiaoyu163.com SECTION 8 ELECTRICAL PARTS LIST QQ 376315150 892498299 BATTERY CD NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable Part No. * 1-676-627-11 BATTERY BOARD ************** Description Remark A-3322-451-A CD BOARD, COMPLETE ******************* * 3-048-457-01 TAPE (CD SHIELD PLATE) When indicating parts by reference number, please include the board. • Abbreviation IT : Italian model CET : East European & CIS model CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 680PF 150PF 150PF 680PF 0.01uF 10% 5% 5% 10% 10% 50V 50V 50V 50V 50V Remark C746 C747 C757 C758 C759 1-126-925-11 1-163-059-11 1-163-181-00 1-163-005-11 1-163-021-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 470uF 0.01uF 100PF 470PF 0.01uF 20% 10% 5% 10% 10% 10V 50V 50V 50V 50V C760 C761 C762 C763 C764 1-163-251-11 1-104-665-11 1-163-021-11 1-163-251-11 1-163-251-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100uF 0.01uF 100PF 100PF 5% 20% 10% 5% 5% 50V 10V 50V 50V 50V C765 C766 C768 C770 C773 1-163-001-11 1-163-251-11 1-163-021-11 1-163-251-11 1-163-251-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 220PF 100PF 0.01uF 100PF 100PF 10% 5% 10% 5% 5% 50V 50V 50V 50V 50V C780 C781 1-163-021-11 CERAMIC CHIP 1-104-665-11 ELECT 0.01uF 100uF 10% 20% 50V 10V < CAPACITOR > C701 C702 C703 C704 C706 1-104-665-11 1-115-185-11 1-163-113-00 1-104-664-11 1-163-009-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 100uF 0.033uF 68PF 47uF 0.001uF 20% 10% 5% 20% 10% 10V 50V 50V 10V 50V C707 C708 C709 C710 C711 1-104-665-11 1-104-665-11 1-163-021-11 1-104-665-11 1-163-021-11 ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP 100uF 100uF 0.01uF 100uF 0.01uF 20% 20% 10% 20% 10% 10V 10V 50V 10V 50V C712 C713 C714 C715 C716 1-163-019-00 1-164-343-11 1-104-329-11 1-163-189-00 1-163-001-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0068uF 0.056uF 0.1uF 220PF 220PF 10% 10% 10% 10% 10% 50V 25V 50V 50V 50V C717 C718 C720 C721 C722 1-104-665-11 1-163-059-11 1-163-021-11 1-163-059-11 1-126-959-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 100uF 0.01uF 0.01uF 0.01uF 0.47uF 20% 10% 10% 10% 20% 10V 50V 50V 50V 50V C723 C726 C727 C728 C729 1-163-189-00 1-163-011-11 1-104-760-11 1-163-021-11 1-104-665-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 220PF 0.0015uF 0.047uF 0.01uF 100uF 5% 10% 10% 10% 20% 50V 50V 50V 50V 10V C730 C731 C732 C733 C734 1-163-021-11 1-163-021-11 1-163-059-11 1-163-235-11 1-163-235-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.01uF 0.01uF 22PF 22PF 10% 10% 10% 5% 5% 50V 50V 50V 50V 50V C735 C736 C737 C738 1-126-963-11 1-126-963-11 1-163-021-11 1-163-021-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP 4.7uF 4.7uF 0.01uF 0.01uF 20% 20% 10% 10% 50V 50V 50V 50V TEL 13942296513 www . QQ 376315150 892498299 < CONNECTOR > CNP701 1-779-466-11 CONNECTOR, FFC (LIF (NON-ZIF)) 16P CNP702 1-784-739-11 CONNECTOR, FFC 17P < IC > IC701 IC702 IC703 8-752-083-15 IC CXA2550M 8-752-386-85 IC CXD2587Q 8-759-549-28 IC BA5974FP-E2 < JUMPER RESISTOR > JC701 JC702 JC703 JC704 JC705 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC706 JC707 JC708 JC709 JC710 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC711 1-216-296-00 SHORT 0 xiaoy u163. com – 56 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 Description 1-163-007-11 1-163-255-11 1-163-255-11 1-163-007-11 1-163-021-11 QQ QQ Part No. C739 C740 C743 C744 C745 13942296513 13942296513 3-028-154-01 TERMINAL (–), BATTERY ************************************************************* Ref. No. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. TEL TEL Ref. No. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. • CAPACITORS uF : µF • COILS uH : µH http://www.xiaoyu163.com QQ 376315150 892498299 CD Ref. No. Remark JC767 JC768 JC769 JC770 JC771 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC717 JC718 JC719 JC720 JC721 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC772 JC773 JC774 JC775 JC776 1-216-295-00 1-216-296-00 1-216-296-00 1-216-295-00 1-216-295-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC722 JC723 JC724 JC725 JC726 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC777 JC778 1-216-295-00 SHORT 1-216-295-00 SHORT 0 0 JC727 JC728 JC729 JC730 JC731 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC732 JC733 JC734 JC735 JC736 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC737 JC738 JC739 JC740 JC741 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC742 JC743 JC744 JC745 JC746 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC747 JC748 JC750 JC751 JC752 1-216-296-00 1-216-296-00 1-216-295-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC754 JC755 JC756 JC757 JC758 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC759 JC760 JC761 JC762 JC763 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC764 JC765 JC766 1-216-295-00 SHORT 1-216-295-00 SHORT 1-216-296-00 SHORT 0 0 0 TEL 13942296513 www . Ref. No. Remark < COIL > L701 L702 L703 L704 L705 1-216-296-00 1-216-296-00 1-216-295-00 1-216-295-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 L706 L707 L708 L709 L710 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 L711 1-216-296-00 SHORT 0 < TRANSISTOR > QQ 376315150 892498299 Q701 Q702 8-729-903-46 TRANSISTOR 2SB1132-T100-QR 8-729-900-53 TRANSISTOR DTC114EKA-T146 < RESISTOR > R701 R702 R703 R704 R705 1-216-254-00 1-216-254-00 1-216-061-00 1-216-059-00 1-216-089-11 RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP 220K 220K 3.3K 2.7K 47K 5% 5% 5% 5% 5% 1/8W 1/8W 1/10W 1/10W 1/10W R708 R709 R712 R713 R714 1-216-001-00 1-216-234-00 1-216-222-00 1-216-085-00 1-216-099-00 METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP 10 33K 10K 33K 120K 5% 5% 5% 5% 5% 1/10W 1/8W 1/8W 1/10W 1/10W R715 R716 R717 R718 R719 1-216-085-00 1-216-085-00 1-216-073-00 1-216-097-11 1-216-270-00 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 33K 33K 10K 100K 1M 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/8W R720 R721 R722 R723 R724 1-216-073-00 1-216-061-00 1-216-061-00 1-216-075-00 1-216-075-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 3.3K 3.3K 12K 12K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R725 1-216-075-00 METAL CHIP 12K 5% 1/10W xiaoy u163. com – 57 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 Description 0 0 0 0 0 QQ QQ Part No. SHORT SHORT SHORT SHORT SHORT 13942296513 13942296513 Description 1-216-296-00 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 TEL TEL Part No. JC712 JC713 JC714 JC715 JC716 http://www.xiaoyu163.com QQ 376315150 892498299 CD Ref. No. CONTROL 12K 12K 12K 4.7K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/8W Remark R741 R759 R760 R761 R762 1-216-037-00 1-216-097-11 1-216-246-00 1-216-097-11 1-216-246-00 METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 330 100K 100K 100K 100K 5% 5% 5% 5% 5% 1/10W 1/10W 1/8W 1/10W 1/8W R774 R775 R776 R777 R779 1-216-055-00 1-216-049-11 1-216-065-11 1-216-055-00 1-216-049-11 METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP 1.8K 1K 4.7K 1.8K 1K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R780 R781 R782 R783 R785 1-216-065-11 1-216-049-11 1-216-055-00 1-216-089-11 1-216-222-00 RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP 4.7K 1K 1.8K 47K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/8W R786 R787 R788 R790 R791 1-216-065-11 1-216-206-00 1-216-049-11 1-216-049-11 1-216-246-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 4.7K 2.2K 1K 1K 100K 5% 5% 5% 5% 5% 1/10W 1/8W 1/10W 1/10W 1/8W R799 1-216-089-11 RES-CHIP 47K 5% 1/10W Part No. Description Remark < RESISTOR > R601 R602 R603 R604 R605 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11 1-249-429-11 CARBON CARBON CARBON CARBON CARBON 680 820 1.2K 1.8K 10K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R606 R607 R608 R609 R610 1-249-432-11 1-249-415-11 1-249-416-11 1-249-418-11 1-249-420-11 CARBON CARBON CARBON CARBON CARBON 18K 680 820 1.2K 1.8K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R611 R612 R613 R616 R617 1-247-843-11 1-249-427-11 1-249-432-11 1-249-415-11 1-249-424-11 CARBON CARBON CARBON CARBON CARBON 3.3K 6.8K 18K 680 3.9K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R618 R619 R620 R621 R622 1-247-843-11 1-249-427-11 1-249-432-11 1-249-415-11 1-249-416-11 CARBON CARBON CARBON CARBON CARBON 3.3K 6.8K 18K 680 820 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R623 R624 R625 R626 R627 1-249-418-11 1-249-420-11 1-247-843-11 1-249-427-11 1-249-432-11 CARBON CARBON CARBON CARBON CARBON 1.2K 1.8K 3.3K 6.8K 18K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1-762-812-11 SWITCH, LEAF (LIMIT) 1-247-815-11 CARBON 1-247-826-00 CARBON 1-249-437-11 CARBON 220 620 47K 5% 5% 5% 1/4W 1/4W 1/4W (S32L) < VIBRATOR > < SWITCH > X701 1-577-253-11 VIBRATOR, CERAMIC (16.9344MHz) ************************************************************* A-3322-447-A CONTROL BOARD, COMPLETE (S22L) A-3322-470-A CONTROL BOARD, COMPLETE (S32L) ************************* * * < CAPACITOR > C602 1-161-494-00 CERAMIC 0.022uF 25V (S32L) S601 S602 S603 S604 S605 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 SWITCH, KEY BOARD (OPERATE) SWITCH, KEY BOARD (SLEEP) SWITCH, KEY BOARD (+ VOLUME) SWITCH, KEY BOARD (– VOLUME) SWITCH, KEY BOARD (MEGA BASS) (S32L) S606 S607 S608 S609 S610 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 SWITCH, KEY BOARD (MEGA BASS) (S22L) SWITCH, KEY BOARD (N X) SWITCH, KEY BOARD (x) SWITCH, KEY BOARD (> + TUNING) SWITCH, KEY BOARD (– . TUNING) S611 < CONNECTOR > < DIODE > S612 S613 S614 8-719-059-97 LED L-34HD (OPR/BATT) S615 1-762-798-11 SWITCH, KEY BOARD (PLAY MODE MONO/ST ISS) 1-762-798-11 SWITCH, KEY BOARD (DISPLAY ENT MEMORY) 1-762-798-11 SWITCH, KEY BOARD (CD) 1-762-798-11 SWITCH, KEY BOARD (RADIO BAND AUTO PRESET) 1-762-798-11 SWITCH, KEY BOARD (TAPE) S616 S617 S618 S619 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 * CNP601 1-770-516-31 CONNECTOR, FFC/FPC 8P (S32L) CNP601 1-770-540-31 CONNECTOR, FFC/FPC 6P (S22L) D601 < IC > IC601 8-749-014-88 IC SPS-440-E (S32L) www . SWITCH, KEY BOARD (9) SWITCH, KEY BOARD (0/10) SWITCH, KEY BOARD (>10) SWITCH, KEY BOARD (1) xiaoy u163. com – 58 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 R628 R629 R630 < SWITCH > S702 Ref. No. QQ QQ METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 13942296513 13942296513 Description 1-216-075-00 1-216-075-00 1-216-075-00 1-216-065-11 1-216-238-11 TEL TEL Part No. R726 R727 R728 R730 R731 http://www.xiaoyu163.com QQ 376315150 892498299 CONTROL Ref. No. S620 S621 S622 S623 S624 Part No. Description 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 1-762-798-11 SWITCH, KEY BOARD (2) SWITCH, KEY BOARD (3) SWITCH, KEY BOARD (4) SWITCH, KEY BOARD (5) SWITCH, KEY BOARD (6) Remark S625 1-762-798-11 SWITCH, KEY BOARD (7) S626 1-762-798-11 SWITCH, KEY BOARD (8) S627 1-762-798-11 SWITCH, KEY BOARD (TONE) (S32L) ************************************************************* 1-676-628-11 HALF BATTERY BOARD ******************* * 3-028-154-01 TERMINAL (–), BATTERY * CNP904 1-580-163-11 PIN, CONNECTOR (PC BOARD) 2P ************************************************************* Part No. LCD Description MAIN Remark 1-162-302-11 CERAMIC 1-126-960-11 ELECT 1-127-888-21 CERAMIC 0.0022uF 30% 1uF 20% 0.1uF 10% C228 C229 1-162-294-31 CERAMIC 1-104-664-11 ELECT 0.001uF 47uF 10% 20% 16V 50V 50V (S32L) 50V 10V C230 C231 C232 C321 C322 1-104-665-11 1-126-926-11 1-136-165-00 1-126-934-11 1-104-664-11 ELECT ELECT MYLAR ELECT ELECT 100uF 1000uF 0.1uF 220uF 47uF 20% 20% 5% 20% 20% 10V 10V 50V 10V 10V C323 C324 C325 C326 C327 1-126-964-11 1-162-306-11 1-126-937-11 1-126-934-11 1-162-282-31 ELECT CERAMIC ELECT ELECT CERAMIC 10uF 0.01uF 4700uF 220uF 100PF 20% 20% 20% 20% 10% 50V 16V 16V 16V 50V 1-162-282-31 1-162-306-11 1-104-664-11 1-104-664-11 CERAMIC CERAMIC ELECT ELECT 100PF 0.01uF 47uF 47uF 10% 20% 20% 20% 1-676-531-11 LCD BOARD ********** * 3-041-646-01 HOLDER (LCD) C501 1-126-933-11 ELECT 100uF 20% 50V 16V 10V 10V (S32L) 16V C502 C503 C504 C505 C506 1-162-306-11 1-104-665-11 1-104-665-11 1-162-306-11 1-162-201-31 0.01uF 100uF 100uF 0.01uF 12PF 20% 20% 20% 20% 5% 16V 10V 10V 16V 50V < CONNECTOR > CNP651 1-568-864-11 CONNECTOR, FFC 21P < LIQUID CRYSTAL DISPLAY > QQ 376315150 892498299 LCD501 1-803-873-11 DISPLAY PANEL, LIQUID CRYSTAL ************************************************************* A-3322-561-A MAIN BOARD, COMPLETE (S22L) A-3322-603-A MAIN BOARD, COMPLETE (S32L) ********************* * * C507 C508 C513 C514 C518 1-162-201-31 1-126-960-11 1-128-802-21 1-128-802-21 1-126-964-11 C519 CERAMIC ELECT CERAMIC CERAMIC ELECT 12PF 1uF 27PF 27PF 10uF 5% 20% 5% 5% 20% 50V 50V 50V 50V 50V 1-126-964-11 ELECT 10uF 20% C520 1-104-664-11 ELECT 47uF 20% C522 C531 C532 1-104-665-11 ELECT 1-162-282-31 CERAMIC 1-162-286-21 CERAMIC 100uF 100PF 220PF 20% 10% 10% 50V (S32L) 10V (S32L) 10V 50V 50V C533 C535 C536 C537 C538 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-306-11 CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC 100PF 100PF 100PF 100PF 0.01uF 10% 10% 10% 10% 20% 50V 50V 50V 50V 16V C540 C541 C542 C543 C544 1-162-306-11 1-126-960-11 1-162-306-11 1-162-282-31 1-162-282-31 CERAMIC ELECT CERAMIC CERAMIC CERAMIC 0.01uF 1uF 0.01uF 100PF 100PF 20% 20% 20% 10% 10% 16V 50V 16V 50V 50V C545 C547 C951 C952 C953 1-162-294-31 1-162-306-11 1-162-306-11 1-162-306-11 1-126-934-11 CERAMIC CERAMIC CERAMIC CERAMIC ELECT 0.001uF 0.01uF 0.01uF 0.01uF 220uF 10% 20% 20% 20% 20% 50V 16V 16V 16V 10V 7-685-645-79 SCREW +BVTP 3X6 TYPE2 N-S < CAPACITOR > C121 C122 C123 C124 C125 1-126-956-11 1-162-294-31 1-126-961-11 1-127-876-21 1-162-302-11 C126 C127 0.1uF 0.001uF 2.2uF 0.01uF 0.0022uF 20% 10% 20% 10% 30% 50V 50V 50V 50V 16V 1-126-960-11 ELECT 1-127-888-21 CERAMIC 1uF 0.1uF 20% 10% C128 C129 C130 1-162-294-31 CERAMIC 1-104-664-11 ELECT 1-104-665-11 ELECT 0.001uF 47uF 100uF 10% 20% 20% 50V 50V (S32L) 50V 10V 10V C131 C132 C221 C222 C223 1-126-926-11 1-136-165-00 1-126-956-11 1-162-294-31 1-126-961-11 1000uF 0.1uF 0.1uF 0.001uF 2.2uF 20% 5% 20% 10% 20% 10V 50V 50V 50V 50V C224 1-127-876-21 CERAMIC 0.01uF 10% 50V www . ELECT CERAMIC ELECT CERAMIC CERAMIC ELECT MYLAR ELECT CERAMIC ELECT xiaoy u163. com – 59 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 TEL 13942296513 CERAMIC ELECT ELECT CERAMIC CERAMIC QQ QQ * C328 C329 C331 C335 13942296513 13942296513 C225 C226 C227 TEL TEL < CONNECTOR > Ref. No. HALF BATTERY http://www.xiaoyu163.com QQ 376315150 892498299 MAIN Ref. No. C957 C959 C999 CNP322 CNP323 CNP501 CNP501 CNP502 Part No. Description Remark < CONNECTOR > TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC945TP-QP 2SC945TP-QP KRC110M-AT (S32L) KTC3198GR-A KRA107M-AT 1-506-986-11 1-506-986-11 1-691-040-31 1-784-767-11 1-784-739-11 PIN, CONNECTOR (PC BOARD) 4P PIN, CONNECTOR (PC BOARD) 4P CONNECTOR, FFC 8P (S32L) CONNECTOR, FFC 6P (S22L) CONNECTOR, FFC 17P Q502 Q503 Q504 Q505 Q506 8-729-036-58 8-729-037-34 8-729-036-77 8-729-036-77 8-729-036-77 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KRC102M-AT KRA107M-AT KRC107M-AT KRC107M-AT KRC107M-AT Q507 Q509 Q510 Q511 Q512 8-729-036-77 8-729-036-89 8-729-036-77 8-729-036-77 8-729-037-13 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KRC107M-AT KTC3198GR-A (S32L) KRC107M-AT KRC107M-AT KTA1271Y-AT Q513 Q514 Q951 Q952 Q953 8-729-037-13 8-729-036-77 8-729-036-57 8-729-037-13 8-729-036-57 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KTA1271Y-AT KRC107M-AT KRC101M-AT KTA1271Y-AT KRC101M-AT Q955 Q957 Q997 8-729-021-82 TRANSISTOR 2SD2396K 8-729-036-86 TRANSISTOR KTC3203Y-AT 8-729-036-57 TRANSISTOR KRC101M-AT 20% 20% 10% CNP505 1-784-774-11 CONNECTOR, FFC 13P CNP551 1-784-782-11 CONNECTOR, FFC 21P < DIODE > TEL 13942296513 DIODE DIODE DIODE DIODE DIODE 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 1SS133T-77 D506 D507 D508 D509 D510 8-719-109-89 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 DIODE DIODE DIODE DIODE DIODE MTZJ-T-77-5.6B (S32L) 1SS133T-77 (S32L) 1SS133T-77 (S32L) 1SS133T-77 1SS133T-77 D511 D951 D952 D953 D955 8-719-991-33 8-719-991-33 8-719-991-33 8-719-109-97 8-719-991-33 DIODE DIODE DIODE DIODE DIODE 1SS133T-77 1SS133T-77 1SS133T-77 MTZJ-T-77-6.8B 1SS133T-77 D956 D957 8-719-991-33 DIODE 1SS133T-77 8-719-109-72 DIODE RD3.9ES-T1B2 Remark < RESISTOR > < IC > 8-759-539-45 8-759-426-51 8-752-915-52 8-759-658-46 8-759-645-87 IC IC IC IC IC IC504 8-759-641-21 IC BR24C01A-W M62429P BA5417 CXP83620-022Q S81233SGY-Z PST9128-T < JACK > J321 1-779-050-11 JACK (i) < CABLE HOLDER > * KH321 * KH503 1-565-385-11 HOLDER, CABLE 4P 1-565-386-11 HOLDER, CABLE 5P < TRANSISTOR > Q121 Q122 Q123 Q124 8-729-194-57 8-729-194-57 8-729-036-80 8-729-036-89 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR www . 1-249-419-11 1-249-422-11 1-247-895-11 1-247-843-11 1-249-421-11 CARBON CARBON CARBON CARBON CARBON 1.5K 2.7K 470K 3.3K 2.2K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R127 R128 R130 R131 R132 1-249-429-11 1-249-415-11 1-247-815-11 1-249-437-11 1-247-807-31 CARBON CARBON CARBON CARBON CARBON 10K 680 220 47K 100 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R140 R221 R222 R223 R225 1-249-421-11 1-249-419-11 1-249-422-11 1-247-895-11 1-247-843-11 CARBON CARBON CARBON CARBON CARBON 2.2K 1.5K 2.7K 470K 3.3K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R226 R227 R228 R230 R231 1-249-421-11 1-249-429-11 1-249-415-11 1-247-815-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON 2.2K 10K 680 220 47K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R232 R240 R321 R322 R323 1-247-807-31 1-249-421-11 1-249-408-11 1-249-417-11 1-247-903-00 CARBON CARBON CARBON CARBON CARBON 100 2.2K 180 1K 1M 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R324 R327 R501 1-249-441-11 CARBON 1-249-413-11 CARBON 1-249-417-11 CARBON 100K 470 1K 5% 5% 5% 1/4W 1/4W 1/4W QQ 376315150 892498299 TEL 13942296513 IC302 IC304 IC501 IC502 IC503 R121 R122 R123 R125 R126 2SC945TP-QP 2SC945TP-QP KRC110M-AT (S32L) KTC3198GR-A xiaoy u163. com – 60 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 8-719-991-33 Ref. No. QQ QQ D322 D323 D324 D504 D505 16V 10V 50V 13942296513 Description 8-729-194-57 8-729-194-57 8-729-036-80 8-729-036-89 8-729-037-34 0.01uF 100uF 0.022uF TEL Part No. Q221 Q222 Q223 Q224 Q501 1-162-306-11 CERAMIC 1-104-665-11 ELECT 1-127-880-31 CERAMIC http://www.xiaoyu163.com QQ 376315150 892498299 MAIN Ref. No. Part No. Description Remark Ref. No. POWER 4.7K 10K 4.7K 4.7K 4.7K 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/4W 1/4W 1/4W R586 R587 R588 R589 R590 1-249-425-11 1-249-437-11 1-249-417-11 1-249-441-11 1-247-843-11 CARBON CARBON CARBON CARBON CARBON 4.7K 47K 1K 100K 3.3K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R591 R592 R593 R594 R595 1-247-832-11 1-249-421-11 1-247-895-11 1-249-422-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1.1K 2.2K 470K 2.7K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W (S32L) R596 1-247-807-31 CARBON 100 5% R597 R598 R599 R951 1-249-417-11 1-249-437-11 1-249-425-11 1-249-437-11 CARBON CARBON CARBON CARBON 1K 47K 4.7K 47K 5% 5% 5% 5% 1/4W (S32L) 1/4W 1/4W 1/4W 1/4W R952 R954 R955 R956 R958 1-249-417-11 1-247-815-11 1-247-807-31 1-249-393-11 1-249-411-11 CARBON CARBON CARBON CARBON CARBON 1K 220 100 10 330 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R503 R504 R505 R506 1-249-417-11 1-249-441-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON 1K 100K 1K 1K 5% 5% 5% 5% 1/4W (S32L) 1/4W 1/4W 1/4W 1/4W R507 R508 R509 R510 R511 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R512 R513 R514 R515 R516 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R517 R518 R519 R520 R521 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R522 R523 R524 R525 R526 1-249-417-11 1-249-429-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1K 10K 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R527 R528 R529 R530 R534 1-249-417-11 1-249-417-11 1-249-417-11 1-249-429-11 1-247-843-11 CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 10K 3.3K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W QQ 376315150 892498299 R535 R536 R537 R538 R539 1-249-429-11 1-249-429-11 1-249-429-11 1-249-421-11 1-249-421-11 CARBON CARBON CARBON CARBON CARBON 10K 10K 10K 2.2K 2.2K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R540 R541 R562 R563 1-249-417-11 1-249-417-11 1-249-425-11 1-249-429-11 CARBON CARBON CARBON CARBON 1K 1K 4.7K 10K 5% 5% 5% 5% R565 1-249-417-11 CARBON 1K 5% 1/4W 1/4W 1/4W 1/4W (S32L) 1/4W R566 R567 R568 R569 R570 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R571 R576 R577 R578 R579 1-249-417-11 1-247-843-11 1-249-417-11 1-249-429-11 1-249-417-11 CARBON CARBON CARBON CARBON CARBON 1K 3.3K 1K 10K 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R580 1-249-417-11 CARBON 1K 5% 1/4W TEL 13942296513 R960 R961 R997 1-249-393-11 CARBON 1-249-417-11 CARBON 1-249-429-11 CARBON 10 1K 10K 5% 5% 5% 1/4W 1/4W 1/4W < VIBRATOR > X501 1-781-775-11 VIBRATOR, CERAMIC (4.19MHz) X502 1-781-721-11 VIBRATOR, CRYSTAL (153.6kHz) ************************************************************* 1-676-530-11 POWER BOARD ************* * < CAPACITOR > C908 1-126-964-11 ELECT 10uF 20% 50V < AC INLET > www . 0 CNJ901 1-526-838-11 INLET, AC 2P (- AC IN) < CONNECTOR > * CNP901 1-580-155-11 PIN, CONNECTOR (PC BOARD) 3P * CNP902 1-580-165-21 PIN, CONNECTOR (PC BOARD) 4P ************************************************************* xiaoy u163. com The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. – 61 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 5% QQ QQ CARBON CARBON CARBON CARBON CARBON 1K 13942296513 13942296513 Description 1-249-425-11 1-249-429-11 1-249-425-11 1-249-425-11 1-249-425-11 1-249-417-11 CARBON TEL TEL Part No. R581 R582 R583 R584 R585 R502 http://www.xiaoyu163.com QQ 376315150 892498299 PRE SECONDARY TUNER Ref. No. Part No. * A-3322-560-A PRE BOARD, COMPLETE ******************** Description Remark Ref. No. < CAPACITOR > CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.0015uF 47uF 0.039uF 0.0022uF 47PF 10% 20% 10% 10% 5% 50V 10V 25V 100V 50V C106 C201 C202 C203 C204 1-126-960-11 1-163-011-11 1-104-664-11 1-162-587-11 1-164-161-11 ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP 1uF 0.0015uF 47uF 0.039uF 0.0022uF 20% 10% 20% 10% 10% 50V 50V 10V 25V 100V C205 C206 C301 C302 C303 1-163-243-11 1-126-960-11 1-104-665-11 1-104-665-11 1-104-665-11 CERAMIC CHIP ELECT ELECT ELECT ELECT 47PF 1uF 100uF 100uF 100uF 5% 20% 20% 20% 20% 50V 50V 10V 10V 10V C304 C305 C306 C307 C308 1-104-664-11 1-137-431-11 1-163-021-11 1-163-011-11 1-163-255-11 ELECT MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47uF 560PF 0.01uF 0.0015uF 150PF 20% 5% 10% 10% 5% 10V 50V 50V 50V 50V C310 1-163-257-11 CERAMIC CHIP 180PF 5% 50V RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP 100 5.6K 1M 4.7K 4.7K 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/8W 1/8W Remark R304 R305 R306 R307 R308 1-216-198-11 1-216-180-00 1-216-069-00 1-216-150-11 1-216-081-00 RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP 1K 180 6.8K 10 22K 5% 5% 5% 5% 5% 1/8W 1/8W 1/10W 1/8W 1/10W R309 R310 R311 R312 R313 1-216-166-00 1-216-121-11 1-216-121-11 1-216-049-11 1-216-049-11 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 47 1M 1M 1K 1K 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/10W 1/10W < SWITCH > S301 1-762-565-11 SWITCH, SLIDE (REC/PB) < TRANSFORMER > T301 1-416-041-11 TRANSFORMER, BIAS OSCILLATION ************************************************************* 1-676-629-11 SECONDARY BOARD ***************** * C901 C902 C903 C904 < IC > IC301 8-759-264-71 IC TA2068N 1-101-005-00 1-101-005-00 1-101-005-00 1-101-005-00 < TRANSISTOR > Q301 Q302 Q303 50V 50V 50V 50V D901 8-719-063-79 DIODE 1N4002B D902 8-719-063-79 DIODE 1N4002B D903 8-719-063-79 DIODE 1N4002B D904 8-719-063-79 DIODE 1N4002B ************************************************************* < RESISTOR > R101 R102 R103 R104 R105 1-216-077-11 1-216-023-00 1-216-097-11 1-216-061-00 1-216-077-11 RES-CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP 15K 82 100K 3.3K 15K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R106 R110 R111 R201 R202 1-216-057-00 1-216-025-11 1-216-067-00 1-216-077-11 1-216-023-00 METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP 2.2K 100 5.6K 15K 82 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R203 R204 R205 R206 1-216-097-11 1-216-061-00 1-216-077-11 1-216-057-00 RES-CHIP METAL CHIP RES-CHIP METAL CHIP 100K 3.3K 15K 2.2K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W . 22000PF 22000PF 22000PF 22000PF < DIODE > 8-729-281-53 TRANSISTOR 2SC1815GR-TPE2 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR www CERAMIC CERAMIC CERAMIC CERAMIC A-3322-563-A TUNER BOARD, COMPLETE *********************** * < CAPACITOR > C1 C2 C3 C4 C5 1-163-263-11 1-163-021-11 1-163-021-11 1-163-009-11 1-163-021-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 330PF 0.01uF 0.01uF 0.001uF 0.01uF 5% 10% 10% 10% 10% 50V 50V 50V 50V 50V C6 C7 C8 C9 C10 1-163-021-11 1-163-113-00 1-163-009-11 1-163-098-00 1-126-960-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 0.01uF 68PF 0.001uF 16PF 1uF 10% 5% 10% 5% 20% 50V 50V 50V 50V 50V xiaoy u163. com – 62 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 QQ 376315150 892498299 TEL 13942296513 < CAPACITOR > CNP301 1-784-774-11 CONNECTOR, FFC 13P QQ QQ 1-533-233-31 HOLDER, FUSE < CONNECTOR > 13942296513 13942296513 1-163-011-11 1-104-664-11 1-162-587-11 1-164-161-11 1-163-243-11 Description 1-216-174-00 1-216-067-00 1-216-121-11 1-216-214-00 1-216-214-00 TEL TEL C101 C102 C103 C104 C105 Part No. R210 R211 R301 R302 R303 http://www.xiaoyu163.com QQ 376315150 892498299 TUNER Ref. No. 10% 20% 5% 5% 20% 25V 50V 50V 50V 50V Remark C17 C18 C19 C20 C21 1-126-960-11 1-126-934-11 1-163-243-11 1-115-339-11 1-126-960-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT 1uF 220uF 47PF 0.1uF 1uF 20% 20% 5% 10% 20% 50V 10V 50V 50V 50V CT1 CT3 CT5 C22 C23 C24 C25 C28 1-115-339-11 1-126-960-11 1-163-003-11 1-163-059-11 1-104-665-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT 0.1uF 1uF 330PF 0.01uF 100uF 10% 20% 10% 10% 20% 50V 50V 50V 50V 10V D1 D2 D3 D10 D11 C30 C31 C32 C33 C34 1-163-021-11 1-163-237-11 1-163-009-11 1-163-021-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 27PF 0.001uF 0.01uF 0.001uF 10% 5% 10% 10% 10% 50V 50V 50V 50V 50V C35 C40 C41 C42 C44 1-115-339-11 1-163-098-00 1-115-339-11 1-163-130-00 1-115-339-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 16PF 0.1uF 360PF 0.1uF 10% 5% 10% 5% 10% 50V 50V 50V 50V 50V C45 C46 C51 C52 C53 1-163-021-11 1-115-339-11 1-163-229-11 1-163-098-00 1-136-171-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR 0.01uF 0.1uF 12PF 16PF 0.33uF 10% 10% 5% 5% 5% 50V 50V 50V 50V 50V C54 C55 C56 C57 C58 1-126-934-11 1-163-251-11 1-163-205-00 1-163-009-11 1-163-021-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 220uF 100PF 0.001uF 0.001uF 0.01uF 20% 5% 5% 10% 10% 10V 50V 50V 50V 50V C59 C60 C61 C62 C63 1-163-021-11 1-163-009-11 1-163-251-11 1-163-251-11 1-163-181-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.01uF 0.001uF 100PF 100PF 100PF 10% 10% 5% 5% 5% 50V 50V 50V 50V 50V C64 C66 C67 C68 C77 1-163-251-11 1-163-251-11 1-163-251-11 1-163-251-11 1-163-021-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100PF 100PF 100PF 0.01uF 5% 5% 5% 5% 10% 50V 50V 50V 50V 50V C80 C93 C95 1-163-021-11 CERAMIC CHIP 1-163-021-11 CERAMIC CHIP 1-163-009-11 CERAMIC CHIP 0.01uF 0.01uF 0.001uF 10% 10% 10% 50V 50V 50V TEL 13942296513 Ref. No. Part No. Description Remark < CONNECTOR > * CNP1 1-785-663-11 PIN, CONNECTOR (PC BOARD) 11P < TRIMMER > 1-141-227-00 CAP, TRIMMER 1-141-304-21 CAP, TRIMMER 1-141-605-11 CAP, ADJ 20PF 10PF < DIODE > 8-719-078-48 8-719-078-48 8-719-050-69 8-719-988-61 8-719-988-61 DIODE DIODE DIODE DIODE DIODE KV1471ETR1-3 KV1471ETR1-3 KV1520NT-2 1SS355TE-17 1SS355TE-17 < JUMPER RESISTOR > FB1 1-216-295-00 SHORT 0 < IC > IC1 IC2 8-759-662-67 IC TA2149N 8-759-483-40 IC LC72137M-TLM < JUMPER RESISTOR > JC3 JC4 JC6 JC7 JC8 1-216-295-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC9 JC10 JC13 JC14 JC15 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC16 JC19 JC20 JC23 JC24 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-295-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC25 JC27 JC28 JC29 JC30 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC31 JC33 JC38 JC39 JC40 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 1-216-296-00 SHORT SHORT SHORT SHORT SHORT 0 0 0 0 0 JC41 JC43 JC44 JC45 1-216-296-00 1-216-296-00 1-216-295-00 1-216-295-00 SHORT SHORT SHORT SHORT 0 0 0 0 QQ 376315150 892498299 < FILTER > CF2 CF4 1-579-083-11 FILTER, CERAMIC 1-781-344-12 FILTER, AM CERAMIC www . xiaoy u163. com – 63 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 0.1uF 4.7uF 0.015uF 0.015uF 1uF QQ QQ CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT 13942296513 13942296513 Description 1-163-077-00 1-126-963-11 1-163-023-00 1-163-023-00 1-126-960-11 TEL TEL Part No. C11 C12 C14 C15 C16 http://www.xiaoyu163.com QQ 376315150 892498299 TUNER Ref. No. Part No. Description Remark < COIL > L1 L2 L3 L4 L21 1-416-533-11 1-416-509-11 1-754-116-11 1-411-199-31 1-410-509-11 R64 R91 R92 R93 R94 COIL, AIR-CORE COIL, AIR-CORE ANTENNA, FERRITE-ROD (MW/LW) COIL, MW/LW OSC INDUCTOR 10uH T1 T2 8-729-027-46 8-729-120-28 8-729-920-31 8-729-931-02 8-729-920-38 Q44 Q61 8-729-931-02 TRANSISTOR 2SC2413KT146-PQ 8-729-106-07 FET 2SK514TP-F DTC114YKA-T146 2SC2412K-T-146-QR DTC343TK-T-146 2SC2413KT146-PQ 2SC2059K-T146-N 1/10W 1/8W 1/8W 1/8W 1/10W 1-433-741-11 TRANSFORMER, IF 1-419-465-11 COIL (DET) MISCELLANEOUS *************** 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R7 R9 R10 R11 R12 1-216-113-00 1-216-097-11 1-216-166-00 1-216-061-00 1-216-238-11 METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP 470K 100K 47 3.3K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/8W 1/10W 1/8W R13 R16 R17 R18 R19 1-216-206-00 1-216-222-00 1-216-057-00 1-216-065-11 1-216-057-00 RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP 2.2K 10K 2.2K 4.7K 2.2K 5% 5% 5% 5% 5% 1/8W 1/8W 1/10W 1/10W 1/10W R22 R24 R25 R30 R31 1-216-073-00 1-216-033-00 1-216-001-00 1-216-077-11 1-216-061-00 METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP 10K 220 10 15K 3.3K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R32 R40 R41 R42 R43 1-216-097-11 1-216-113-00 1-216-073-00 1-216-097-11 1-216-222-00 RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 100K 470K 10K 100K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/8W R50 R51 R53 R54 R56 1-216-198-11 1-216-073-00 1-216-069-00 1-216-043-11 1-216-041-00 RES-CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP 1K 10K 6.8K 560 470 5% 5% 5% 5% 5% 1/8W 1/10W 1/10W 1/10W 1/10W R58 R59 R60 R61 R63 1-216-206-00 1-216-206-00 1-216-206-00 1-216-206-00 1-216-214-00 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 2.2K 2.2K 2.2K 2.2K 4.7K 5% 5% 5% 5% 5% 1/8W 1/8W 1/8W 1/8W 1/8W 128 0 251 254 ANT1 0 F902 CABLE, FLEXIBLE FLAT (6 CORE) (S22L) CABLE, FLEXIBLE FLAT (8 CORE) (S32L) CABLE, FLEXIBLE FLAT (13 CORE) CABLE, FLEXIBLE FLAT (21 CORE) WIRE, PARALLEL (16 CORE) 1-792-208-11 WIRE, PARALLEL (17 CORE) 8-848-483-05 PICK-UP, OPTICAL KSS-213C X-2626-202-1 CHASSIS ASSY (MB), MOTOR (SPINDLE) (INCLUDING M701) 1-501-883-21 ANTENNA, TELESCOPIC 1-532-464-51 FUSE (T2.5AL 250V) QQ 376315150 892498299 HE301 HRP301 M301 M702 S304 1-543-876-11 1-500-454-11 A-3320-446-A X-2625-769-1 1-692-302-11 HEAD (ERASE) HEAD, MAGNETIC (RECORD/PLAYBACK) MOTOR ASSY (CAPSTAN/REEL) GEAR ASSY (MB), MOTOR (SLED) SWITCH, LEAF (TAPE PLAY) S501 1-692-960-11 SWITCH, PUSH (1 KEY) (CD DOOR OPEN/CLOSE) SP301 1-529-215-11 SPEAKER (10cm) (L-CH) SP302 1-529-215-11 SPEAKER (10cm) (R-CH) 0 T901 1-433-578-11 TRANSFORMER, POWER ************************************************************ xiaoy u163. com The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. – 64 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 470 220 10K 10K 0 1-792-206-11 1-792-207-11 1-792-203-11 1-792-205-11 1-792-209-11 QQ QQ METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT 8 8 102 111 126 13942296513 13942296513 1-216-041-00 1-216-033-00 1-216-073-00 1-216-073-00 1-216-295-00 . 5% 5% 5% 5% 5% X1 1-760-130-11 VIBRATOR, CRYSTAL (75kHz) ************************************************************* R1 R2 R3 R4 R5 www Remark 1K 1K 1K 1K 1K < VIBRATOR > < RESISTOR > TEL 13942296513 Description RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP TEL TEL Q12 Q14 Q41 Q42 Q43 Part No. 1-216-049-11 1-216-198-11 1-216-198-11 1-216-198-11 1-216-049-11 < TRANSFORMER > < TRANSISTOR > TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Ref. No. http://www.xiaoyu163.com QQ 376315150 892498299 Ref. No. Part No. Description Remark ACCESSORIES & PACKING MATERIALS ******************************** 0 0 CORD, POWER ADAPTOR, CONVERSION PLUG 3P (UK) LID, BATTERY CASE (for RMT-CS32AD) (S32L) MANUAL, INSTRUCTION (ENGLISH) (AEP,UK) MANUAL, INSTRUCTION (SPANISH) (AEP) 3-043-356-51 3-043-356-71 3-043-356-81 3-043-356-91 3-044-465-11 MANUAL, INSTRUCTION (FRENCH) (AEP) MANUAL, INSTRUCTION (DUTCH) (AEP) MANUAL, INSTRUCTION (PORTUGUESE) (AEP) MANUAL, INSTRUCTION (ITALIAN) (IT) MANUAL, INSTRUCTION (SWEDISH) (CET) 3-044-465-21 3-044-465-31 3-044-465-41 3-044-465-51 3-044-465-71 MANUAL, INSTRUCTION (FINNISH) (CET) MANUAL, INSTRUCTION (POLISH) (CET) MANUAL, INSTRUCTION (CZECH) (CET) MANUAL, INSTRUCTION (HUNGARIAN) (CET) MANUAL, INSTRUCTION (SLOVAKIAN) (CET) TEL TEL 1-769-412-13 1-770-019-11 3-027-153-11 3-043-356-31 3-043-356-41 13942296513 13942296513 3-044-465-81 MANUAL, INSTRUCTION (RUSSIAN) (CET) A-3258-004-A REMOTE COMMANDER RMT-CS32AD (S32L) ************************************************************* ************** HARDWARE LIST ************** SCREW +BVTP 3X10 TYPE2 N-S SCREW +BVTP 3X12 TYPE2 N-S SCREW +BVTP 3X6 TYPE2 N-S SCREW +BVTT 2X4 (S) SCREW +P 2X6 #6 #7 #8 #9 7-682-548-04 7-685-533-19 7-621-770-87 7-682-647-11 SCREW +B 3X8 SCREW +BTP 2.6X6 TYPE2 N-S SCREW +B 2.6X5 SCREW +PS 3X6 (S32L) TEL 13942296513 www . QQ 376315150 892498299 xiaoy u163. com The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. – 65 – http://www.xiaoyu163.com 376315150 892498299 376315150 892498299 7-685-647-79 7-685-648-79 7-685-645-79 7-685-851-04 7-621-255-45 QQ QQ #1 #2 #3 #4 #5 http://www.xiaoyu163.com CFD-S22L/S32L QQ 376315150 892498299 TEL TEL 13942296513 13942296513 9-927-962-11 . xiaoy u163. com Sony Corporation Personal Audio Division Company – 66 – http://www.xiaoyu163.com 2000C0451-1 Printed in Japan C2000. 3 Published by General Engineering Dept. 376315150 892498299 376315150 892498299 www QQ 376315150 892498299 QQ QQ TEL 13942296513