Transcript
http://www.xiaoyu163.com
HCD-V8800 QQ 376315150 892498299 SERVICE MANUAL
E Model Chinese Model
TEL
TEL CD SECTION
HCD-V4500
CD Mechanism Type
CDM37L-5BD21AL
Base Unit Type
BU-5BD21AL
Optical Pick-up Type
KSS-213D/Q-NP
Model Name Using Similar Mechanism
HCD-V4500 TCM-220WR2
SPECIFICATIONS
— Continued on next page —
www MICROFILM
xiaoy u163. com
COMPACT DISC DECK RECEIVER
.
—1—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299 Tape Transport Mechanism Type
QQ
QQ
TEL 13942296513
TAPE DECK SECTION
Model Name Using Similar Mechanism
13942296513
13942296513
HCD-V8800 is the tuner, deck, Video CD and amplifier section in LBT-V8800AV.
http://www.xiaoyu163.com
QQ 376315150 892498299 TEL
TEL
13942296513
13942296513
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
• Abbreviation SP : Singapore model MY : Malaysia model IA : Indonesian model CH : Chinese model
Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing • Keep the temperature of soldering iron around 270˚C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. Laser component in this product is capable of emitting radiation exceeding the limit for Class 1. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior.
www
PARTS No.
MODEL E, SP model
4-992-220-0
MY model
4-992-220-1
CH model
4-992-220-2
IA model
4-992-220-3
SAFETY-RELATED COMPONENT WARNING !!
xiaoy u163. com This caution label is located inside the unit.
.
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
—2—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
MODEL IDENTIFICATION — BACK PANEL —
QQ
QQ
QQ 376315150 892498299
TEL 13942296513
CAUTION
http://www.xiaoyu163.com
QQ 376315150 892498299 TABLE OF CONTENTS
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT
1. SERVICING NOTE .......................................................... 4
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repain parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK
Carry out the “S curve check” in “CD section adjustment” and check that the S curve waveform is output three times.
4. TEST MODE .............................................................. 11 5. MECHANICAL ADJUSTMENTS ........................... 12 6. ELECTRICAL ADJUSTMENTS ............................... 12 7. DIAGRAMS
QQ 376315150 892498299
8. EXPLODED VIEWS
www
8-1. Case and Back Panel Section .............................................. 97 8-2. Front Panel Section 1 .......................................................... 98 8-3. Front Panel Section 2 .......................................................... 99 8-4. Chassis Section ................................................................. 100 8-5. TC Mechanism Section-1 (TCM-220WR2) ..................... 101 8-6. TC Mechanism Section-2 (TCM-220WR2) ..................... 102 8-7. TC Mechanism Section-3 (TCM-220WR2) ..................... 103 8-8. CD Mechanism Section (CDM37L-5BD21AL) ............... 104 8-9. Base Unit Section (BU-5BD21AL) .................................. 105
.
xiaoy u163. com
9. ELECTRICAL PARTS LIST ...................................... 106
—3—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
7-1. Circuit Boards Location ...................................................... 17 7-2. Block Diagrams • KEY CON Section ........................................................... 18 • CD Section ....................................................................... 19 • Video Section ................................................................... 21 • Deck Section .................................................................... 23 • Main Section .................................................................... 25 • Power Section .................................................................. 27 7-3. Printed Wiring Board — CD Section — ............................. 29 7-4. Schematic Diagram — CD Section — ............................... 31 7-5. Schematic Diagram — Video Section — ........................... 33 7-6. Printed Wiring Board — Video Section — ......................... 37 7-7. Printed Wiring Board — Main Section — .......................... 40 7-8. Schematic Diagram — Main Section — ............................ 43 7-9. Schematic Diagram — Deck Section — ............................ 47 7-10. Printed Wiring Board — Deck Section — ....................... 51 7-11. Schematic Diagram — Panel Section — ......................... 54 7-12. Printed Wiring Board — Panel Section — ....................... 57 7-13. Schematic Diagram — Power Section — ........................ 61 7-14. Printed Wiring Board — Power Section — ..................... 65 7-15. Schematic Diagram — CD Motor Section — .................. 68 7-16. Printed Wiring Board — CD Motor Section — ............... 69 7-17. Schematic Diagram — KEY CON Section — ................. 71 7-18. Printed Wiring Board — KEY CON Section — .............. 72 7-19. IC Block Diagrams ........................................................... 73 7-20. IC Pin Functions ............................................................... 80
QQ
QQ
TEL 13942296513
3-1. Front Panel ........................................................................... 7 3-2. Main Board ........................................................................... 8 3-3. Tape Mechanism Deck .......................................................... 8 3-4. Cassette Lid Assembly .......................................................... 9 3-5. CD Lid Assembly .................................................................. 9 3-6. CD Mechanism Deck .......................................................... 10 3-7. Base Unit ........................................................................... 10 3-8. Disc Table ........................................................................... 10
13942296513
13942296513
LASER DIODE AND FOCUS SEARCH OPERATION CHECK
3. DISASSEMBLY
TEL
TEL
The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
2. GENERAL .......................................................................... 6
http://www.xiaoyu163.com
SECTION 1 SERVICING NOTE
QQ 376315150 892498299
MC Cold Reset • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER , and DISC 1 simultaneously. 2. The fluorescent indicator tube becomes blank instantaneously, and the set is reset.
Change-over of FUNCTION Name • The FUNCTION name of external input terminal can be changed over to VIDEO or MD. With the FUNCTION selected to “MD”, about 5dB mute is applied to the input gain. Procedure: 1. Press POWER button to turn the set OFF. 2. Press POWER button together with FUNCTION button, and the power is turned on, the display of fluorescent indicator tube changes to “MD” or “VIDEO” instantaneously, and thus the FUNCTION is changed over.
www
1.
Aging Mode in CD Section
1-1. Operating procedure of Aging Mode 1. Set discs in DISC 1 and DISC 3 trays. 2. Select the function “CD”. 3. Press three buttons SPECTRUM ANALYZER , ENTER , and KARAOKE PON/MPX simultaneously. 4. The aging mode is activated, if a roulette mark on the fluorescent indicator tube is blinking. 5. In the aging mode, the aging is executed in a sequence given in “1-2. Operation during Aging Mode”. The aging continues unless an alarm occurred. 6. To exit from the aging mode, press POWER button to turn the set OFF. • If a button other than buttons In CD section is pressed during aging, the aging in the CD section is finished. • To execute aging to the tape deck section successively, press · button in the deck A. “AGING” is displayed on the fluorescent indicator tube. (For the aging in tape deck, see “2. Aging Mode in Tape Deck Section”. 1-2. Operation during aging Mode In the aging mode, the program is executed in the following sequence. 1. The disc tray turns to select a disc. (For a disc selection sequence, see Section 1-3.) 2. TOC of disc is read. 3. The pick-up accesses to the last track. 4. Steps 1 through 3 are repeated.
xiaoy u163. com
Change-over of AM Tuner Step between 9kHz and 10kHz • A step of AM channels can be changed over between 9kHz and 10kHz. Procedure: 1. Press POWER button to turn the set ON. 2. Select the function “TUNER”, and press TUNER/BAND button to select the BAND “AM”.
.
QQ 376315150 892498299
1-3. Disc Selection Sequence • During the aging mode, discs are selected in the following sequence: Disc 1 → Disc 3 ↑ ↓ Disc 3 ← Disc 1
—4—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
Sled Servo Mode • This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the pick-up. Procedure: 1. Select the function “CD”. 2. Press three buttons SPECTRUM ANALYZER , ENTER , and FUNCTION simultaneously. 3. The Sled Servo mode is selected, if “CD” is blanking on the fluorescent indicator tube. 4. With the CD in stop status, press ) button in CD section to move the pick-up to outside track, or 0 button to inside track. 5. To exit from this mode, perform as follows: 1) Move the pick-up to the most inside track. 2) Press three buttons in the same manner as step 2. Note: • Always move the pick-up to most inside track when exiting from this mode. Otherwise, a disc will not be unloaded. • Do not run the sled motor excessively, otherwise the gear can be chipped.
Aging Mode This mode can be used for operation check of CD section and tape deck section. • If an error occurred: The aging operation stops. • If no error occurs: The aging operation continues repeatedly.
13942296513
13942296513
MC Hot Reset • This mode resets the set with the preset data kept stored in the memory. The hot reset mode functions same as if the power cord is plugged in and out. Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER , and DISC 2 simultaneously. 2. The fluorescent indicator tube becomes blank instantaneously, and the set is reset.
LED and Fluorescent Indicator Tube All Lit, Key Check Mode Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER , and DISC 3 simultaneously. 2. LEDs and fluorescent indicator tube are all turned on. Press DISC 2 button, and the key check mode is activated. 3. In the key check mode, the fluorescent indicator tube displays “K 1 V0 J0”. Each time a button is pressed, “K”value increases. However, once a button is pressed, it is no longer taken into account. “J” Value increases like 1, 2, 3 ... if rotating JOG knob in “+” direction, or it decreases like 0, 9, 8 ... if rotating in “–” direction. “V” Value increases like 1, 2, 3 ... if rotating VOLUME knob in “+” direction, or it decreases like 0, 9, 8 ... if rotating in “–” direction. 4. To exit from this mode, press three buttons in the same manner as step 1, or disconnect the power cord.
TEL
TEL
CD Delivery Mode • This mode moves the pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press POWER button to turn the set ON. 2. Press PLAY MODE button and POWER button simultaneously. 3. A message “LOCK” is displayed on the fluorescent indicator tube, and the CD delivery mode is set.
3. Press POWER button to turn the set OFF. 4. Press ENTER/NEXT and POWER buttons simultaneously, and the display of fluorescent indicator tube changes to “AM 9k STEP” or “AM 10k STEP”, and thus the channel step is changed over.
http://www.xiaoyu163.com
QQ 376315150 892498299 2. Aging Mode in Tape Deck Section
SELF-DIAGNOSIS This model has the self-diagnosis function for the VIDEO and AUDIO decoder sections. Immediately after the power on, the self-diagnosis function searches each operation of IC’s around the mechanism control microcomputer (IC701). The results can be checked by connecting an oscilloscope to TP709 (LED) of the VIDEO board.
H
No error L Light
H L
MPEG decoder (IC201) error
L 2 time blinking H L
QQ
QQ
3 time blinking oscilloscope
+ –
Note: The LED for check (D701) is mounted to some sets (FORMER TYPE). In this case, confirm the lighting condition of LED. [VIDEO BOARD] (SIDE A)
IC771
[VIDEO BOARD] (SIDE B)
xiaoy u163. com TP709 (LED)
X901
IC751
IC251
—5—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
VIDEO board TP709 (LED)
D701
.
DRAM (IC251) error
13942296513
13942296513
H
QQ 376315150 892498299
2-3. Deck Selection Sequence • During the aging mode, decks are selected in the following sequence: Deck A (FWD) → Deck A (REV) ↑ ↓ Deck B (REV) ← Deck B (FWD)
www
External SRAM (IC751) error
1 time blinking
2-2. Operation during Aging Mode In the aging mode, the program is executed in the following sequence. 1. A tape on FWD side is played for one minute. 2. PAUSE STOP is made. 3. Recording is made for 3 minutes. (For the deck not having the record function, the play is executed.) 4. FF is executed up to the end of tape. 5. A tape is reversed, and the tape on REV side is played for one minute. 6. PAUSE STOP is made. 7. Recording is made for 3 minutes. (For the deck not having the record function, the play is executed.) 8. FF is executed up to the end of tape. 9. Steps 1 through 8 are executed for the other deck. 10. Steps 1 through 9 are repeated unless an alarm occurred.
TEL 13942296513
Symptom
Oscilloscope (Waveform)
TEL
TEL
2-1. Operating procedure of Aging Mode 1. Load a commercially available 10-minute tape into the decks A and B respectively. (If a 10-minute tape is not available, another tape may be used but a cycle time will be longer.) 2. Select the function “TAPE”. 3. Rewind tapes in advance by pressing 0 button respectively on decks A and B. 4. Press three buttons SPECTRUM ANALYZER , ENTER , and KARAOKE PON/MPX simultaneously. 5. Press · button on deck A. (This button triggers the aging mode.) 6. The aging mode is activated if “AGING A” is displayed on the fluorescent indicator tube. 7. In the aging mode, the aging is executed in a sequence given in “2-2. Operation during Aging Mode”. The aging continues unless an alarm occurred. 8. To exit from the aging mode, press POWER button to turn the set OFF.
http://www.xiaoyu163.com
SECTION 2 GENERAL
QQ 376315150 892498299
Front Panel
1
2
3
4
56
7
8
!∞ !¢ 9
!£ !™ !¡ !§
!•
!¶
0
@¡
@º
!ª
@™
#§
@£
#∞ @∞
#¢
#£
#™
#¡
@¶ @§
#º @ª @•
#• %º $ª $•
QQ 376315150 892498299 $º $¡ $™
$¶
$£ $∞
$§
$¢
%™
%£ %¢ %∞ %§
%¶
%• %ª
^º
&™ &¡ &º ^ª
^¡
^•
www ^¶
^§
^∞
.
xiaoy u163. com ^¢
^£
—6—
http://www.xiaoyu163.com
^™
376315150 892498299
376315150 892498299
TEL 13942296513
#ª
QQ
QQ
%¡
13942296513
13942296513
@¢
TEL
TEL
#¶
http://www.xiaoyu163.com
QQ 376315150 892498299 LOCATION OF PARTS AND CONTROLS
SUPER W MODE button GEQ control buttons GEQ CONTROL button ENTER button P FILE MEMORY button # button KEY CONTROL indicator ˜ button KARAOKE PON/MPX button PHONES jack ECHO LEVEL knob MIC 1, MIC 2 jacks MIC LEVEL knob Deck B ª, · button Deck B 0, ) button Deck B r REC button Deck B P button CD SYNC button Deck B 6 EJECT button H SPEED DUB button Deck B p button Deck A 0, ) button Deck A 6 EJECT button DOLBY NR button
$ª %º %¡ %™ %£ %¢ %∞ %§ %¶ %• %ª ^º ^¡ ^™ ^£ ^¢ ^∞ ^§ ^¶ ^• ^ª &º &¡ &™
DIRECTION button Deck A p button Deck A ª, · button 6 OPEN button CD · button CD p button CD P button DISC SKIP button CD FLASH button 1/ALL DISCS button PLAY MODE button CD 0, ) button REPEAT button ≠ AMS ± dial EDIT button NEXT button AUTO PBC indicator PREV button PBC indicator ˆ RETURN button VCD indicator CD LOOP button CD NON-STOP button DISC1-DISC5 buttons
3-1. FRONT PANEL
1 Three flat type wires (CN401, CN402, CN701)
3 Front panel
www
.
xiaoy u163. com 2 Four screws (BVTP3x8)
—7—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
Note: Follow the disassembly procedure in the numerical order given.
QQ
QQ
QQ 376315150 892498299
SECTION 3 DISASSEMBLY
13942296513
13942296513
TEL 13942296513
@∞ @§ @¶ @• @ª #º #¡ #™ #£ #¢ #∞ #§ #¶ #• #ª $º $¡ $™ $£ $¢ $∞ $§ $¶ $•
TEL
TEL
1 POWER button 2 DISPLAY/DEMO button 3 SPECTRUM ANALYZER button 4 Display Window 5 ENTER/NEXT button 6 TUNER MEMORY button 7 TUNING MODE button 8 TUNER/BAND button 9 TUNING (+/–) button !º STEREO/MONO button !¡ SLEEP button !™ DAILY 2 button !£ DAILY 1 button !¢ t/CLOCK SET button !∞ REC button !§ WAVE button !¶ DSP button !• Equalizer indicators !ª PRO LOGIC button @º EFFECT button @¡ GROOVE button @™ FUNCTION button @£ VOLUME control @¢ SUPER WOOFER button
http://www.xiaoyu163.com
QQ 376315150 892498299
3-2. MAIN BOARD
5 Back panel
Installing the power cord for the Chinese model.
3 Seven screws (BVTP3x8)
Power transformer
4 Power cord 9 Connector (CN601)
2 Eleven screws (BVTP3x8)
0 Connector (CN9001)
Bushing cord
1 Flat type wire (CN1)
Ferrite core Wire clamp
TEL
TEL 6 Connector (CN961)
7 Flat type wire (CN801)
QQ 376315150 892498299 !¡ Two screws (BVTP3x8)
3-3. TAPE MECHANISM DECK 3 Three screws (BVTP2.6x8)
4 Three screws (BVTP2.6x8)
5 Remove the tape mechanism deck section to direction of the arrow A.
2 Open the cassette lids. A
www
.
xiaoy u163. com 1 Push the two buttons.
—8—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
!™ Connector (CN901)
QQ
QQ
8 Connector (CN830)
13942296513
13942296513
!£ MAIN board
http://www.xiaoyu163.com
QQ 376315150 892498299 3-4. CASSETTE LID ASSEMBLY
3 Two bracket
2 Two screws (BVTP2.6x8)
1 Two springs
TEL
TEL
13942296513
13942296513
4 Cassette lid assembly
3-5. CD LID ASSEMBLY 1 Four screws (BVTP2.6x8) 2 Connector (CN671)
4 CD lid assembly
www
3 Connector (CN661)
.
xiaoy u163. com —9—
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
3-6. CD MECHANISM DECK
3-7. BASE UNIT
1 Five screws (BVTP3x8)
3 Flat type wire
2 CD mechanism deck
3 Base unit
TEL
TEL 1 Yoke bracket
Note: When the disc table is installed, adjust the positions of roller cam and mark ” as shown in the figure, then set to the groove of disc table. A
4 Stop screw 2 Screw (BVTP3x8) 1 Screw (BVTP3x8) 3 Bracket (BU)
www
5 Disc table
xiaoy u163. com A
.
— 10 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
3-8. DISC TABLE
13942296513
13942296513
2 Boss
http://www.xiaoyu163.com
SECTION 4 TEST MODE
QQ 376315150 892498299 VIDEO CD COLOR-BARS MODE
[VIDEO BOARD] (SIDE B)
SL703 (AFADJ) SL702 (ADJ) IC751 IC251 SL701 (CAL BAR)
• Refer to SECTION 6 ELECTRICAL ADJUSTMENTS page 15.
www
.
QQ 376315150 892498299
xiaoy u163. com — 11 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
1. Connect the lead wire to both ends of the land of SL702 (ADJ) and SL703 (AFADJ) of the VIDEO board. 2. Turn the power on. Press FUNCTION button to select CD. 3. Short-circuit the lead wire. (At this time, “DISC” on the fluorescent indicator tube will blink (test mode). If it is not blinking, perform from step 1 again.) 4. Press the · button in playback. 5. Every pressing the REPEAT button, the tracking servo and the sledding servo are turned on or off. 6. When the servo is OFF, the counter on front panel will not be changed. 7. After measuring, remove the lead wire connected step 1.
13942296513
13942296513
E-F BALANCE MODE
TEL
TEL
On this mode, the data of the color-bars signal as a picture signal and the 1kHz sine wave signal as a sound signal are output by the mechanism control microcomputer (IC701) for video CD signal check. When measurement of the voltage and waveform on the VIDEO board, perform it in this mode. For refernce, the color-bars signal can be observed at J9001 (VIDEO OUT) and the sound signal can be observed at J101 (VIDEO (AUDIO) OUT) using an oscilloscope. 1. Connect the lead wire to both ends of the land of SL701 (CAL BAR) of the VIDEO board. 2. Turn the power on. Press FUNCTION button to select CD. 3. After 2 or 3 seconds later, connect the lead wire. 4. After measuring, remove the lead wire connected. NOTE: The 1 kHz sine wave is not outputted when the CD is played once, but it is not error.
http://www.xiaoyu163.com
SECTION 5 MECHANICAL ADJUSTMENTS
SECTION 6 ELECTRICAL ADJUSTMENTS
QQ 376315150 892498299
Precaution 1. Clean the following parts with a denatured alcohol-moistened swab: record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. After the adjustments, apply suitable locking compound to the parts adjusted. 5. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement
36 to 61 g • cm (0.5 - 0.84 oz • inch)
13942296513
FWD back tension
CQ-102C
2 to 6 g • cm (0.02 - 0.08 oz • inch)
REV
CQ-102RC
36 to 61 g • cm (0.5 - 0.84 oz • inch)
REV back tension
CQ-102RC
2 to 6 g • cm (0.02 - 0.08 oz • inch)
FF/REW
CQ-201B
61 to 143 g • cm (0.85 - 1.99 oz • inch)
FWD tension
CQ-403A
100 g or more (3.53 oz or more)
QQ
REV tension
CQ-403R
100 g or more (3.53 oz or more)
TEL
Signal
Used for
P-4-A100
10 kHz, –10 dB
Azimuth Adjustment
WS-48B
3 kHz, 0 dB
Tape Speed Adjustment
P-4-L300
315 Hz, 0 dB
Level Adjustment
NOTE: Set the test mode by following step before performing the adjustment of “DECK SECTION”. All effects for the output signal are canceled. If the adjustment is not performed in this test mode, you cannot adjust correctly. Procedure : With the power turned ON, press the SPECTRUM ANALYZER button, ENTER button, and EFFECT button simultaneously. (The “VOLUME” on the fluorescent display tube will blink while in the test mode.) To exit the test mode, press the POWER button.
QQ 376315150 892498299 Record/Playback Head Azimuth Adjustment (Deck A, Deck B) Note: Perform this adjustments for both decks. Procedure: 1. Mode : Playback test tape P-4-A100 (10kHz, –10dB)
VIDEO(AUDIO) OUT
level meter
set
+ –
www
.
xiaoy u163. com — 12 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
Tape
QQ
CQ-102C
FWD
1. Demagnetize the record/playback head with a head damagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjusted. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and R-CH. 7. Switches and controls should be set as follows unless otherwise specified.
13942296513
Meter reading
0 dB=0.775V
TEL
Torque meter
Torque
DECK SECTION
http://www.xiaoyu163.com
QQ 376315150 892498299 2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1 dB of peak.
L-CH peak
output level
within 1dB
R-CH peak
L-CH peak
screw position
R-CH peak
test tape P-4-A100 (10kHz, –10dB)
VIDEO (AUDIO) OUT
Procedure : With the power turned ON, press the SPECTRUM ANALYZER button, ENTER button, and EFFECT button simultaneously. (The “VOLUME” on the fluorescent display tube will blink while in the test mode.) To exit the test mode, press the POWER button. 1. Load WS-48B into deck A and a recordable tape into deck B. 2. Press the r REC button, and press the · button of deck B to set deck B into the recording state. 3. Play deck A. 4. While pressing the H SPEED DUB button, set double speed play. 5. Adjust RV652 of the AUDIO board so that the reading of the frequency counter becomes 6000 ± 90 Hz. 6. Release the H SPEED DUB button to set normal speed play. 7. Adjust RV651 of the AUDIO board so that the reading of the frequency counter becomes 3000 ± 90 Hz. Adjustment Location: AUDIO board
oscilloscope
set
R
Playback Level Adjustment (Deck A, Deck B) Procedure: Mode: Playback
Waveform of oscilloscope
45°
in phase
good
90°
135°
test tape P-4-L300 (315Hz, 0dB)
180°
level meter
set
wrong VIDEO (AUDIO) OUT
4. After the adjustments, apply suitable locking compound to the parts adjusted. Adjustment Location: Playback Head (Deck A) Record/Playback/Erase Head (Deck B)
Deck A is RV311 (L-CH) and RV411 (R-CH), deck B is RV301 (L-CH) and RV401 (R-CH) so that adjustment within the following adjustment level. Adjustment level: CN403 playback level: 301.5 to 338.3 mV (–8.2 to –7.2 dB) level difference between the channels: within ± 0.5 dB Adjustment Location: AUDIO board
reverse
www
.
xiaoy u163. com
forward
— 13 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
Sample Value of Wow and flutter W.RMS (JIS) less than 0.3% (test tape: WS-48B)
L
13942296513
13942296513
3. Mode: Playback
Note: Set the test mode using the following method and begin tape speed adjustment. In the test mode, the tape will move at double speed while the H SPEED DUB button is pressed.
TEL
TEL
screw position
within 1 dB
Tape Speed Adjustment (Deck A)
http://www.xiaoyu163.com
QQ 376315150 892498299 Record Level Adjustment (Deck B)
Procedure:
Procedure:
INTRODUCTION When set to the test mode performed in Tape Speed Adjustment, when the tape is rewound after recording, the “REC memory mode” which rewinds only the recorded portion and playback is set. This “REC memory mode” is convenient for performing this adjustment. During recording, the input signal FUNCTION will automatically switch to VIDEO.
INTRODUCTION When set to the test mode performed in Tape Speed Adjustment, when the tape is rewound after recording, the “REC memory mode” which rewinds only the recorded portion and playback is set. This “REC memory mode” is convenient for performing this adjustment. During recording, the input signal FUNCTION will automatically switch to VIDEO.
1. Press FUNCTION button to select VIDEO. (This step is not necessary if the above test mode has already been set.) 2. Load a tape into deck B, and press the r REC button. 3. Mode: Record
1. Press FUNCTION button to select VIDEO. (This step is not necessary if the above test mode has already been set.) 2. Load a tape into deck B, and press the r REC button. 3. Mode: Record
VIDEO (AUDIO) IN 1) 315Hz } 50 mV (–23.8 dB) 2) 10kHz
VIDEO (AUDIO) IN 315Hz 50 mV (–23.8 dB)
blank tape CS-123
600 Ω
blank tape CS-123
600 Ω attenuator
attenuator
set
set
4. Mode: Playback
4. Mode: Playback
recorded position
level meter
level meter
set
set
VIDEO (AUDIO) OUT
VIDEO (AUDIO) OUT
5. Confirm playback the signal recorded in step 2 become adjustment level as follows. If these levels do not adjustment level, adjust the RV341 (LCH) and RV441 (R-CH) on the AUDIO board to repeat steps 3 and 4.
5. Confirm playback the signal recorded in step 2 become adjustment level as follows. If these levels do not adjustment level, adjust the RV301 (LCH) and RV351 (R-CH) on the MAIN board to repeat steps 3 and 4.
Adjustment level: The playback output of 10 kHz level difference against 315 Hz reference should be ± 1.0 dB.
Adjustment level: CN403 playback level: 47.2 to 53.0 mV (–24.3 to –23.3 dB)
Adjustment Location: AUDIO board
Adjustment Location: MAIN board
Adjustment Location [AUDIO BOARD] (Conductor Side)
[MAIN BOARD] (Component Side)
RV301 Record Level (L CH)
RV341 (Lch), RV441 (Rch) Record Bias
IC401
RV651 (Normal Speed) RV651 RV652 RV652 (High Speed) Tape Speed
RV301 RV401 RV441 RV341
www
RV311
xiaoy u163. com RV411
RV301 (Lch), RV401 (Rch) Playback Level (Deck B)
RV311 (Lch), RV441 (Rch) Playback Level (Deck A)
.
— 14 —
http://www.xiaoyu163.com
RV351 Record Level (R CH)
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
recorded position
13942296513
13942296513
AF OSC
AF OSC
TEL
TEL
Record Bias Adjustment (Deck B)
http://www.xiaoyu163.com
QQ 376315150 892498299 CD SECTION
Note : A clear RF signal waveform means that the shape “◊” can be clearly distinguished at the center of the waveform.
NOTE :
RF signal waveform
1. CD Block is basically designed to operate without adjustment. Therefore, check each item in order given. 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. 3. Use an oscilloscope with more than 10MΩ impedance. 4. Clean the object lens by an applicator with neutral detergent when the signal level is low than specified value with the following checks.
VOLT/DIV : 200mV TIME/DIV : 500ns
level : 1.3 +0.25 Vp-p –0.20
S Curve Check oscilloscope
E-F Balance (Traverse) Check
BD board
oscilloscope + –
BD board
symmetry
QQ 376315150 892498299
A Within 3 ± 1 Vp-p
Traverse waveform
B
Center of the waveform
6. After check, remove the lead wire connected in step 2. Note : • Try to measure several times to make sure than the ratio of A : B or B : A is more than 10 : 7. • Take sweep time as long as possible and light up the brightness to obtain best waveform.
B A (DC voltage)
0V
level : 1.3 ± 0.6 Vp-p
RF Level Check 8. Press the REPEAT button. (The tracking servo and sledding servo are turned ON.) Confirm the C (DC voltage) is almost equal to the A (DC voltage) is step 7.
oscilloscope BD board TP (RF) TP (VC)
Traverse waveform
+ –
Procedure : 1. Connect oscilloscope to test point TP (RF) on BD board. 2. Turned Power switch on. 3. Put disc (YEDS-18) in to play the number five track. 4. Confirm that oscilloscope waveform is clear and check RF signal level is correct or not.
www
.
C (DC voltage)
0V
xiaoy u163. com Tracking servo Sled servo OFF
Tracking servo Sled servo ON
9. Remove the lead wire connected step 1.
— 15 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
Procedure : 1. Connect oscilloscpe to test point TP (TE) on BD board. 2. Connect the lead wire to both ends of the land of SL702 (ADJ) and SL703 (AFADJ) of the VIDEO board. 3. Turned Power switch on. Press FUNCTION button to select CD. 4. Short the lead wire. 5. Put disc (YEDS-18) in to play the number five track. 6. Press the REPEAT button. (The tracking servo and the sledding servo are turned OFF.) 7. Check the level B of the oscilliscope's waveform and the A (DC voltage) of the center of the Traverse waveform. Confirm the following : A/B x 100 = less than ± 22%
QQ
QQ
S-curve waveform
+ –
13942296513
13942296513
Procedure : 1. Connect oscilloscope to test point TP (FE) on BD board. 2. Connect between test point TP (FEI) and TP (VC) by lead wire. 3. Turned Power switch on. 4. Put disc (YEDS-18) in and turned Power switch on again and actuate the focus search. (actuate the focus search when disc table is moving in and out.) 5. Check the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 3±1 Vp-p.
TP (TE) TP (VC)
TEL
TEL
TP (FE) TP (VC)
http://www.xiaoyu163.com
QQ 376315150 892498299
RF PLL Free-run Frequency Check Procedure : 1. Connect frequency counter to TP (PLCK) with lead wire. frequency counter
BD board TP (PLCK)
VIDEO SECTION
Frequency adjustment
1. Connect the frequency counter to check point of the VIDEO board.
+ –
frequency counter VIDEO board TP410 (DCLK)
2. Turned Power switch on. 3. Put the disc (YEDS-18) in to play the number five track. Confirm that reading on frequency counter is 4.3218MHz.
+ –
2. Adjust CT401 of the VIDEO board so that the frequency counter read 13.5MHz ± 40Hz at STOP condition. TEL
TEL
13942296513
13942296513 1
[ VIDEO BOARD ] — SIDE B —
20 IC103
10
(FE)
(RF) 11
SL703 (AFADJ) SL702 (ADJ)
(FEI)
CT401 Frequency
(TE)
IC751 IC251
(VC)
SL701 (CAL BAR)
TP410 (DCLK)
(PLCK) IC101
www
.
xiaoy u163. com — 16 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
[ BD BOARD ] — SIDE A —
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
Adjustment Location :
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0 SECTION 7 DIAGRAMS
7-1. CIRCUIT BOARDS LOCATION
HCD-V8800
892498299
7-2. BLOCK DIAGRAMS — KEY CON SECTION —
TRANS board
VIDEO POWER board
FM/AM TUNER PACK
PANEL board
ECHO AMP IC760 (2/2)
MIC AMP IC760 (1/2)
J761
3
MIC 1
1
6
7
RV760 MIC LEVEL
TEL
TEL
ECHO IC761 J762
HP/MIC board
MIC 2
9
2
1 LPF1
8 LPF2
13942296513
RV761 ECHO LEVEL
TC-A SW board CD-LED board
MAIN board
CD-A SW board
KEY CON board
VIDEO OUT board
SWITCH IC1403
QQ
QQ
DOOR SW board
VIDEO board
CD-B2 SW board
4
3
CD-B1 SW board
9 10 11
KEY CONTROL IC1401
Note: pA is including in AUDIO board.
MIX OUT
LPF1 IN
pA MOTOR board
Rch
Q1401
K CON
15
22
AUDIO board (including pA)
L IN
A MAIN SECTION
(Page 25)
7 8 9 LATCH
LEAF SWITCH board
CLK DATA L OUT
TABLE SENSOR board
09
BD board
www CD MOTOR board
.
x ia o y u 1 6 3 . c o m LED board
— 17 —
http://www.xiaoyu163.com
— 18 —
• R CH : Same as Lch • Signal path : FM : MIC
376315150 892498299
376315150 892498299
QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
TEL 13942296513
5
POWER board
TC-B SW board
DATA CLOCK STORBE
13942296513
SURROUND boar d
http://www.xiaoyu163.com
HCD-V8800
QQ 3 7 6 3 1 5 1 5 0
892498299
— CD SECTION —
OPTICAL PICK-UP BLOCK (KSS-213D/Q-NP)
DIGITAL SERVO DIGITAL SIGNAL PROCESSOR IC101
RF AMP IC103
LASER DIODE
62 APC LD AMP
2
LDON
PRIORITY EMCODER
+5V
1
ADDRESS GENERATOR
CLOCK GENERATOR
39
DETECTOR
DIGITAL OUT
SBSO
RF SUMMING AMP
RF FQ AMP
INTEGRATOR
16
36
38
F FOCUS ERROR AMP
RF AC
ASY1
ASYMMETRY CORRECTION
EFM DEMODULATOR
MIX
D/A DATA PROCESSOR
REGISTER
SUBCODE Q PROCESSOR
PEAK DETECTOR
DATA BUS
4
ERROR CORRECTOR TRACKING ERROR AMP
13
FOK
10
11
VC BUFFER
VC
12
26 27
INTEGRATOR
28 29
RF DC
TIMING GENERATOR 1
DFCT MIRR
SERVO DSP FOCUS SERVO
SE FE
TRACKING SERVO
F+ FOCUS COIL
F–
M102 SLED MOTOR
M101 SPINDLE MOTOR
CLV SERVO PROCESSOR
TIMING GENERATOR 2
SERVO AUTO SEQUENCER
1B TIMS OVERSAMPLING FILTER
SERVO INTERFACE
NOISE SHAPER
TRACKING PWM GENERATOR
79
16 19 20
17
FFDR 8 FRDR 10
FOCUS PWM GENERATOR
SRDR SFDR
SLED PWM GENERATOR
S STOP
TFDR TRDR
GFS
4 6
4 5
2
54
12
2
10 9
100
23 24
96
B
80
SENS
C2PO 56
C2PO
VIDEO SECTION
(Page 21)
XRST 81
XRST
99
AMUTE
13 M
SENS
DATA XLT CLK
FOK 93 DFCT 92 MIRR 91
PWM GENERATOR
1
SCOR
DATA 86 XLT 87 CLK 88
CPU INTERFACE
SLED SERVO
FOCUS/TRACKING COIL DRIVE SPINDLE/SLED MOTOR DRIVE IC102
T–
SCOR 74 WFCK 73
QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
TE A/D CONVERTER
ADATA LRCK BCK
S901 LIMIT SWITCH
S201 UP SW UP SW
+5V
27 M 26
www
DISC TABLE SENSOR IC202
MDP
T.SENS
MOTOR DRIVER IC201
MUTE 15
09
.
x ia o y u 1 6 3 . c o m
— 19 —
M201 TABLE MOTOR
http://www.xiaoyu163.com
M
7 OUT1 3 OUR2
— 20 —
C MAIN SECTION
IN1 9 IN2 1
TBL.L TBL.R
• R CH: Same as L ch • SIGNAL PATH : CD : VIDEO
(Page 25)
376315150 892498299
376315150 892498299
TEL 13942296513
MIRR DFCT FOK DETECTOR
46 LRCK 45 BCLK 47
QQ
QQ
VC
T+
SQCK SCLK
DATA
SYNC PROTECTOR
TRACKING COIL
SUBQ
78 SCLK 83
SERIAL/PARALLEL PROCESSOR
DIGITAL PLL
1
8 9
77
SQCK
15
MUTE
A C B D
RF
3 4 5 6
75
13942296513
13942296513
SUBQ
E
384FS
DOUT 71 EXCK 76
SUBCODE P-W PROCESSOR
32K RAM
ASY0
70
TEL
TEL
MD2
19
LD DRIVE Q101
LD
XTAL
LD POWER
PD
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
HCD-V8800
892498299
— VIDEO SECTION —
10BIT VIDEO D/A CONVERTER IC401
MPEG DECODER IC201
HSYNC VSYNC FID DCLK XOSDEN OSD B OSD G OSD R
TIMING GEN.
XRST
A0
D7
A3
3 NR-XCS 29 MCLK 30 MDATA 31
IF
SYNC SLOPE GEN.
OSD B OSD G OSD R XOSDEN
5
7
32
3
4 3
1
SUB CARRIER GEN.
HSYNC
18 17 16
OUTPUT CONT.
VIDEO RAM
J9002 S VIDEO OUT
CLOSED CAPTION ENCODER
SYNC GEN. & TIMING CONT.
57
55
51
62
SIO & I2O-BUS CONT.
59 60
48 49 50
DATA INPUT SHIFT RESISTOR
4 3 2 1
MDATA OS-XLAT MCLK
15
• R CH: Same as L ch • SIGNAL PATH
QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 19
SYNC CONT.
DATA SEL.
20
DISPLAY POSITION CONT.
: VIDEO :Y : CHROMA : CD
OSC
8 CLOCK GENERATOR IC272 S-RAM IC751
DCLK
6.75MHz
1 CK 1/2 Q 5
DIGITAL FILTER & D/A CONVERTER IC101
XTCS
CE1 WE
11–13 • 15–19 2–10 •21 • 23–25 22
20 27
IC772
LRCK
6
BCLK
384FS
DATA CLK AMUTE
09
1
DATA CLK DF-XLAT
2
40
54
56 43 70
7 8
11
11
4
6
12
1
3
10
A17
AS
WR WAIT XHIRQ
VDAC-XLAT DF-XLAT
AMUTE
47 48 49 68 CMD0 CMD1 CMD2 CMD3 SACK QINT MREQ
1 2 3 4 5 6 72
34 35 36 37 44 18 43
3 4 5
CMD0 CMD1 CMD2 CMD3 SACK QINT MREQ
2
x ia o y u 1 6 3 . c o m
X101 33.8688MHz
22
27 25
D/A CONV.
INPUT
2 3
ACTIVE LPF IC102 1 6
7
PLM 16 18
R CH
52
AUTO
X701 10MHz
— 21 —
X1
51
PAL
X2
S9001 SYSTEM SELECT
NPIN 64
MODE
MUTE CIRCUIT
1
IIC INTERFACE IC901
CD-XRST
MECHA CONTROL IC701
.
13
MDATA MCLK OS-XLAT NR-XCS
41 A18
RD
A12
21–29 • 31–35 55
XTAL
(Page 20)
13
EXTAL
CD SECTION
13 – 20
A0
DATA CLK AMUTE SQCK SUBQ SCLK XLT LDON SCOR SENS RESET
D7
73 78 74 11 10 77 76 75 71 62 48
21
4
IC771 384FS DATA CLK AMUTE SQCK SUBQ SCLK XLT LDON SCOR SENS XRST
CLOCK GENERATOR
3
12
16
www B
5
11
D0
IC501 (2/2)
4
9
TIMING CIRCUIT
BUFFER IC181 ADATA
8
10
6
INT
A0
OE
A12
I/O8
I/O1
384FS
52
10
11
NTSC
http://www.xiaoyu163.com
RESET 15 IIC-DATA 55 IIC-CLK 56
XRST
X901 5MHz
— 22 —
L CH XRST IIC-DATA IIC-CLK
D MAIN SECTION
(Page 25)
376315150 892498299
376315150 892498299
TEL 13942296513
VSYNC
D-RAM IC251
29
56
1/2
X401 27MHz CT401 13.5MHZ
OSD IC271
16 15 30 31
A8
CLOCK GENARATOR IC402 5 6 4
DRAM
98 97 100
RAS W UCAS LCAS
A0
D0
Y C
QQ
QQ
DQ16
18
DELAY
7–13 • 16 5 • 6 • 119 • 120 114 116 115 117
38–43 •46–55 17–21 • 23 •24 •32 • 33 34 35 37
DQ1
58
MEMORY CONT.
107 XTL2I
2–5 •7–10 •35–38 •40–43 18–21 • 24–28
11
MODULATOR LPF
DATA CLK VDAC-XLAT
118
D-RAM INTERFACE
51
Y, C/Y, U, V SELECTOR & INTERPOLATOR
LPF
DEMPX, LEVEL TRANSLATOR & INTERPOLTATOR
9
Y/C AMP IC452
XHCS XWR XHDT XHIRQ
X201 45.1584MHz
3 XTL01 106 XTL2O
YUV-RGB CONV.
VSYNC HSYNC
HOST INTERFACE
MPEG AUDIO DECODER
100 101 102
NOISE REDUSER
11 C 18
XSGRST
4 • 6
67 RGB-YUV CONV.
7
13942296513
13942296513
EACH CIRCUIT BLOCK
97 95 92 93 94 89 56 57 58 59
2 XTL0O X202 28.63636MHz
C0-C7
63
C
60
Y
9
70
ADATA LRCK BCLK
4 • 6
80
FID
103
VIDEO POSTPROCESSOR & SYNC GENERATOR
XVRST
15
CD-ROM DECODER
MPEG VIDEO DECODER
5
RESET
(Page 20)
5
MPEG SYSTEM DECODER
DCLKI
384FS
112 111 110 109
J9001 VIDEO OUT
24
TEL
TEL
CD SECTION
11 12 13 14
V
1
HSYNC VSYNC DCLK
B
9 8 7 6
Y0-Y7
74 • 76
Y BCK ADATA LRCK C2PO
1
XRST
71
VIDEO AMP IC451
DCLK
BUFFER IC501 (1/2)
NOISE REDUCTION IC301
http://www.xiaoyu163.com
HCD-V8800
QQ 3 7 6 3 1 5 1 5 0
892498299
— DECK SECTION —
PB A/B
S1008 B CrO2
S1004 A CrO2
CN403 3 RV311
12
IC611
PB-A/B
L
A 120/70
B 120/70
70
A IN 2 B IN 4
L
RV301 10
R CH
3
EQIN
EQOUT
1
P HRPE101
IC602 R 4 REC/PB
NORM/HIGH NR ON/OFF
19
REC/PB/PASS
RIN
6
REC L
BIAS ON/OFF
BIAS SW
10
16 RM ON/OFF 17
BIAS ON/OFF RM ON/OFF
24 25 RELAY REC/PB CAP M SWITCH Q405, 407 +7.5V Q623, 901
BIAS OSC T621, Q621, 622
X
M1 CAPSTAN MOTOR
SPEED CONTROL Q651
Q Q 3 7 6 3 1 5 1 5 0 8E 9 2 4 9 8 2 9 9 M
RV651 NORMAL SPEED
SWITCH Q406
CAP M H / L
MAIN SECTION
RV652 HIGH SPEED
(Page 25)
REEL DETECT Q1001
A SHUT
REEL DETECT Q1002
B SHUT
S1001 (A PLAY)
• R CH : Same as L ch • SIGNAL PATH : PB (DECK A) : PB (DECK B) : REC (DECK B)
+5V
A PLAY S1002 (B PLAY) B PLAY
S1003 (A HALF)
A HALF
+5V
S1005 (REC A) 09
S1006 (B HALF)
BHALF
S1009 (REC B)
www
x ia o y u 1 6 3 . c o m VZ 4
M2 TRIGGER MOTOR
2 OUT1
M
10 OUT2
.
— 23 —
TRIGGER MOTOR DRIVE IC402
http://www.xiaoyu163.com
SWITCH Q408, 409
TRIG H / L
IN2 6
B TRIG
IN1 5
A TRIG
— 24 —
376315150 892498299
376315150 892498299
TEL 13942296513 REC BIAS
CAP M ON/OFF
QQ
QQ
RV341 REC BIAS
ERASE BIAS
DOLBY TYPE B
RECOUT
NORM
11
LM ON/OFF
PB
REC LEVEL R
PB L
NORM/ HIGH 14 NR ON/ OFF 18
PLAYBACK LEVEL DECK B
REC/PB HEAD (DECK B)
8
LM ON/ 20 OFF
DOLBY NR
13942296513
13942296513
RV301 IC601
PB OUT
DOL
DECK PROCESS IC401
R CH
1 PAS
120
R CH
R
ERASE HEAD
15
CROM
HP101 PB HEAD (DECK A)
13
TEL
TEL
PLAYBACK LEVEL DECK A
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
HCD-V8800
892498299
— MAIN SECTION —
DOLBY PRO LOGIC IC601
L IN DATA CLK LATCH K CON
A
(Page 18)
C-OUT 34 9 L-IN S-OUT 35 L-OUT 37 3 41 DATA 4 42 CLK 2 40 EN
3 4 5 6
L OUT
10 S-IN 8 L-IN
FRONT
3 3 DATA 4 2 CLK 2 4 EN
XTAL 23
X601 8MHz
XTAL 24
4 3 1
CENTER
3 14 8 9 10
IN IN CLK DATA LATCH
OUT 2
MUTE Q602
OUT 15
MUTE Q601
AMP IC861
REAR
REAR
CENTER
CENTER
6 5
FRONT
V TC ST CD
J101
1 2 4 5
7
INPUT SELECT IC103
INPUT SELECT IC102 3
A 10 B 9 INH 6
FRONT
69 71
4 5
3
28 29 30
9 10 11
65
MICON INTERFACE
3
44
43 +
42
38
FRONT MUTE Q254
62
EQUALIZER / VOLUME IC201 39
40 41
S.WOOFER MODE SWITCH Q206
DBFB SWITCH Q201
61
MUTE SWITCH Q120
LATCH
4
+
EQ
32 33 34
OUT L PB L REC L
45
64
13942296513
13942296513
VIDEO (AUDIO)
FRONT
L-MIX 16 OUT
AMP
1 7
TEL
TEL
MUTE Q121
3 5
1
PHONO EQ AMP IC101
IN L
S-OUT 13
REC 2A
3
IC603
REAR
REAR
J101
PHONO IN L
VOLUME IC604
DELAY IC602
CENTER
BB22 BB12
KEY CON SECTION
DBFB SWITCH Q202 DBFB
MUTE CONTROL Q123,124
INPUT CHANGE
TEL 13942296513 DECK SECTION
(Page 24)
LM ON/OFF CAP M H/L A TRG B TRG TRIG H/L CAP M ON/OFF ST L
FM/AM TUNER PACK ENCAPSLATED COMPONENT
1 2 3 4
COM DIN COM DATA STEREO TUNED ST CE MUTE
CD SECTION
www (Page 22)
4 5
K CON LAT K CON ON
TRG LOW CAP M ON/OFF VOL LAT PL LAT COM DOUT COM CLK ST DIN STEREO TUNED
POWER 98
POWER ON/OFF
DBFB H/L 2 TA MUTE 1 R RELAY 7
R RELAY
QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9 F LED1
IIC DATA 55 IIC CLK 56
28 DATA 27 CLOCK
RESET SWITCH Q951
.
29
SIRCS SPEANA 1 SPEANA 2 SPEANA 3 SPEANA 4 L+R JOG A JOG B
39 42 43 44 45 46 26 41
KEY 5
37
KEY 1
33
DOOR SW
38
MASTER CONTROL IC701 RESET IC951
D951 +5V X1 11 X2 10
XT1 14
X701 5MHz
12 XOUT X601 8MHz
Q602,603
LED SWITCH
PANEL LED
LED CONTROL Q601 REMOTE CONTROL RECEIVER IC602 D/A S711 = AMS + ROTARY ENCODER
KEY MATRIX
• R CH: Same as L ch • SIGNAL PATH : FM : CD : PB : REC : VIDEO
S681 6 OPEN
S701 VOLUME
x ia o y u 1 6 3 . c o m SEG1–35
GR1–16
67 – 100 • 1
51 – 66
FL601 FLUORESCENT INDICATOR TUBE
D201 (DISC No.)
VOL A VOL B
24 40
ROTARY ENCODER
VF
62 TRAY LED
CD POWER
Q201
STK MUTE 100
MUTE SWITCH Q912
09
— 25 —
http://www.xiaoyu163.com
POWER SECTION
(Page 27)
X702 32.768KHz
CD POWER 46
D+5V
D+5V
13 XIN
57 XRST
XRST IIC-DATA IIC-CLK
LED18 LED SELECT
DISPLAY CONTROL IC601
14 RESET
AC CUT 20
3 10 • 15 • 16 • 18
23 • 25 • 47
RESET 15
XT2 13
L CH
D
TC MUTE CAP H/N A TRG B TRG
60 TBL L 61 TBL R 77 UP SW 76 T SENS
TBL. L TBL. R UP SW T. SENS
(Page 20)
VIDEO SECTION
93 82 83 84 85 86 41 42 44 45 66 70 69 68 72
99
ST CE ST MUTE 67 ST DOUT
5 6
C
REC MUTE NR ON/OFF R/P PASS
3
427 LAT SW F CON
— 26 —
STK MUTE
376315150 892498299
376315150 892498299
RELAY A SHUT B SHUT B HALF A HALF A PLAY SW B PLAY SW PB A/B EQ H//N BIAS
QQ
QQ
E
54 96 26 27 28 97 94 95 87 88 89 90 91 92
RELAY REC/PB A SHUT B SHUT B HALF A HALF A PLAY B PLAY PB A / B NORM/HIGH BIAS ON/OFF RM ON/OFF NR ON/OFF REC/PB PASS
http://www.xiaoyu163.com
HCD-V8800
QQ 3 7 6 3 1 5 1 5 0
892498299
— POWER SECTION —
POWER AMP IC601
REAR
1
REAR
CENTER
RY401
REAR
–1
10
18
TM402 SURROUND SPEAKER
REAR
CENTER
–2
13
CENTER
6
CENTER
RELAY DRIVE Q404
Rch
THERMAL DET Q670,671 THP670
POWER AMP IC201
TM401 FRONT SPEAKER RY402
1
FRONT FRONT
10
FRONT
–1
6
RELAY DRIVE Q403 RELAY CONTROL Q402
6
Rch
2
QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
1
Q323
(Page 26)
DBFB
HP / SP SWITCHING Q401,405
4
7
PROTECT SWITCH Q301
Rch MUTE SWITCH Q331
STK MUTE
D+5V (SW)
+3.3V REG IC801
D+3.3V
2
D+5V (UNSW)
+5V REG IC9001
+5V SW Q9001
1
R RELAY CD POWER
3
1
Q9002 +5V REG IC9002 A+5V (SW)
+5V
D905
D5V SWITCHED
+5V SW Q9003
+5V REG IC902 3
3
1
Q9004 1
+7V REG IC903 AU/D5V SW
+5V REG Q906
D7V
3
1 RECT D302,303
+7V, –7V REG IC901
Q907
VF
T501 POWER TRANSFORMER
VF 1 +7.5
A+7.5V
VCC 2 RECT D901
A–7.5V
www 09
POWER ON/OFF
10 –7.5
EN 4
VEE 9
UNREG –12V
E,SP,IA,CH
x ia o y u 1 6 3 . c o m Q901
VFDP
POWER B+ POWER B– SURR B+
+12V REG IC904
.
+12V
3
1
SURR B–
ST 10V PRO-LOG 10V
— 27 —
3
VF REG Q941
RECT D104,105
VOLTAGE SELECTOR S501
RECT D101 RECT D102
AC IN
1
+10V REG IC905
http://www.xiaoyu163.com
— 28 —
• R CH : Same as L ch • SIGNAL PATH : FM • Abbreviation SP : Singapore model. IA : Indonesian model. CH : Chinese model.
376315150 892498299
376315150 892498299
TEL 13942296513
PROTECTOR IC301
Rch
Rch
MAIN SECTION
J760 PHONES
QQ
QQ
OVER LOAD DET Q201
F
M901 FAN MOTOR
13942296513
13942296513
OVER LOAD DET Q601,651
M UNREG –12V
TEL
TEL
FAN MOTOR DRIVER Q961, 962
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
w w w
3
9
4
.
2
2
x
9
6
5
i
a
1
Q Q
3
o
y
u
1
3
6
http://www.xiaoyu163.com
3
7
6
.
3
1
c
5
1
o
5
0
m
8
9
2
4
9
8
2
9
9
376315150 892498299
376315150 892498299
E
QQ
QQ
T
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
w w w
3
9
4
.
2
2
x
9
6
5
i
a
1
Q Q
3
o
y
u
1
3
6
http://www.xiaoyu163.com
3
7
6
.
3
1
c
5
1
o
5
0
m
8
9
2
4
9
8
2
9
9
376315150 892498299
376315150 892498299
E
QQ
QQ
T
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
376315150
376315150
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
892498299
892498299
w w w
.
x
i
a o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
376315150
376315150
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
892498299
892498299
w w w
.
x
i
a o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
w w w
3
9
4
.
2
2
x
9
6
5
i
a
1
Q Q
3
o
y
u
1
3
6
http://www.xiaoyu163.com
3
7
6
.
3
1
c
5
1
o
5
0
m
8
9
2
4
9
8
2
9
9
376315150 892498299
376315150 892498299
E
QQ
QQ
T
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
w w w
3
9
4
.
2
2
x
9
6
5
i
a
1
Q Q
3
o
y
u
1
3
6
http://www.xiaoyu163.com
3
7
6
.
3
1
c
5
1
o
5
0
m
8
9
2
4
9
8
2
9
9
376315150 892498299
376315150 892498299
E
QQ
QQ
T
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
w w w
.
x
i
Q Q
3 7 6 3 1 5 1 5 0
a o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
w w w
.
x
i
Q Q
3 7 6 3 1 5 1 5 0
a o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
http://www.xiaoyu163.com
Q
Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
3
9
4
2
2
9
i
a
1
Q
3
Q
3
7
6
3
1
5
1
5
0
8
9
2
4
9
8
2
9
9
892498299
5
892498299
6
376315150
376315150
E
QQ
QQ
T
w w w
.
x
o
y
u
1
6
http://www.xiaoyu163.com
3
.
c
o
m
http://www.xiaoyu163.com
Q Q
7
3
6
1
3
5
1
5
0
8
2
9
4
9
2
8
9
9
TEL
TEL
13942296513
13942296513
L
1
3
9
4
2
2
9
i
a
1
Q Q
3
3
7
6
3
1
5
1
5
0
8
9
2
4
9
8
2
9
9
892498299
5
892498299
6
376315150
376315150
E
QQ
QQ
T
w w w
.
x
o
y
u
1
6
http://www.xiaoyu163.com
3
.
c
o
m
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
376315150
376315150
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
892498299
892498299
w w w
.
x
i
a o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
http://www.xiaoyu163.com
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
Q Q
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
376315150
376315150
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
T E L
892498299
892498299
w w w
.
x
i
a o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
http://www.xiaoyu163.com
QQ 376 315150
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
376315150
376315150
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
892498299
892498299
www
.
x ia o y u 1 6 3 http://www.xiaoyu163.com
.
c o
m
http://www.xiaoyu163.com
IC101 CXD2545Q
IC101 CXD8567AM
892498299
70 MD2
CPU INTERFACE
CLV PROCESSOR
PLM
MUTE L 13 89 91 92 93
COUT MIRR DFCT FOK
MUTE R 14
SLED PWM GENERATOR
TRACKING SERVO
TRACKING PWM GENERATOR
FOCUS SERVO
FOCUS PWM GENERATOR
2 2 2 2 2 2
3, 100 1, 2 4, 7 5, 6 8, 11 9, 10
3RD ORDER NOISE SHAPER
CLOCK GENERATOR
16 R1 (+) 15 D Vdd 1
QQ 3 7 6 3 1 5 1 5 0 8 9 2 4 9 8 2 9 9
SFON, SFDR SRON, SRDR TFDR, TFON TRON, TRDR FFDR, FFON FRON, FRDR
IC201 CXD1852AQ
VDD DCLK B/Cb7 B/Cb6 B/Cb5 B/Cb4 B/Cb3 B/Cb2 B/Cb1 B/Cb0 G/Y7 G/Y6 G/Y5 G/Y4 G/Y3 VSS VDD G/Y2 G/Y1 G/Y0 R/Cr7 R/Cr6 R/Cr5 R/Cr4 R/Cr3 R/Cr2 R/Cr1 R/Cr0 XVOE VSS
PWM GENERATOR
SLED SERVO
17 A Vdd R
14 16 17
21 40 23 35
41 90 15 65
81
22 37 44 45 66 82 83 84 85 98 99
RFC ADIO
TEST TES2 TES3
AVDD AVDD AVSS AVSS
ADD ADD DVSS DVSS
XRST
IGEN BIAS WDCK LRCK FSTI DIRC SCLK DFSW ATSK LOCK SSTP
90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 25 24
IC103 CXA1821M
IC102 BA6392FP
CH1 OUT F 1 CH1 OUT R 2
BUFF
LD 1
28 GND
F LEVEL SHIFT
R CAPA IN 1 3
27 CH4 OUT F
PD 2
26 CH4 OUT R
A 3
BUFF CH1 R IN 4 CH1 F IN 5
R F
VCC
19 LD ON 18 LC/PD
APC LD AMP
VREF VEE
25 VB IN
VEE
RF EQ AMP
B 4
INTERFACE
17 RFE VC RF SUMMING AMP
24 VS IN
C 5
BUFF VREF IN 6
20 VCC
VCC
BUFF
BUFF
VC
16 RFO
23 VB IN
D 6
GND 8 CH2 F IN 9 CH2 R IN 10 CAPA IN 2 11 CH2 OUT R 12 CH2 OUT F 13
22 VCC
www
F
R
INTERFACE
INTERFACE
R
F
BUFF BUFF
F
R
21 VCC F R
. BUFF
BUFF
VEE
VC
VC
19 CH3 R IN
TRACKING ERROR AMP
13 TE
E 9
17 CH3 OUT R 16 CH3 OUT F
— 73 —
EI 10
VC
VC BUFFER
VC
18 CAPA IN 3
14 FE BIAS
F 8
VC
15 MUTE
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31
VIDEO POSTPROCESSOR & SYNC GENERATOR
CLOCK MPEG AUDIO DECODER
MPEG VIDEO DECODER
CLOCK
MPEG SYSTEM DECODER
CD-ROM DECODER
x ia o y u 1 6 3 . c o m VEE 7
VC
20 CH3 F IN
MUTE
GND 14
15 FE FOCUS ERROR AMP
91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120
12 VC
VCC
VEE
11 EO
HOST INTERFACE
EACH CIRCUIT BLOCK
D-RAM INTERFACE
RESET
TEST
CLOCK
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
VSS XTLOO XTLO1 VDD HA2 HA3 HD0 HD1 HD2 HD3 HD4 HD5 HD6 VDD VSS HD7 MA3 MA4 MA2 MA5 MA1 VSS MA6 MA0 BC TCKI TDI TENAI TDO VST
VREF OUT 7
VSS HSYNC VSYNC FID/FHREF CBLNK/FSC CSYNC XSGRST CLK0O DOUT DATO LRCO BCKO FSXI VDD VSS XTL2O XTL2I VDD C2PO LRCI DATI BCKI DOIN XHCS XHDT XRW XHIRQ XRST HA0 HA1
http://www.xiaoyu163.com
— 74 —
VDD OSDR OSDG OSDB XOSDEN MD15 MD0 MD14 MD1 MD13 MD2 MD12 MD3 MD11 MD4 VSS VDD MD10 MD5 MD9 MD6 MD8 MD7 XCAS0 XCAS2/MA9 XMWE XRAS MA8 MA7 VSS
376315150 892498299
376315150 892498299
SERVO DSP
18 R2 (+)
80 SENS
SERVO MICRO PROGRAM INTERFACE
A/D CONVERTER
DC DITHER
DATA 11
TEL 13942296513
SWITCH & BUFFER
19 A Vss R
LRCK 12
SERVO AUTO SEQUENCER
TIMING GENERATOR 2
18-TIMES OVERSAMPLING FILTER
20 X Vdd
XBCK 10
86 DATA 88 CLOK 87 XLAT
IIR
SUBCODE Q PROCESSOR
21 X OUT
MCKSEL 9
ERROR CORRECTOR
SUBCODE P-W PROCESSOR
22 512IN
QQ
QQ 26 27 28 29 30
D Vss 8
PLM
TIMING GENERATOR 1
24 A Vss L 23 X Vss
TEST1 7 71 D OUT
MIRR DFCT FOK DETECTOR
RFDC TE SE FE VC
LATCH 5
25 L2 (+)
256FSO 6
PEAK DETECTOR DIGITAL OUT
NOISE SHAPER
DA01-16
79 MUTE
D/A DATA PROCESSOR
MUX
61-46
SAMPLE HOLD (X1)
16
FIR3
SERIAL PARALLEL PROCESSOR
26 A Vdd L
FIR1
ASYMMETRY CORRECTION
SHIFT 4
ATT
SYNC PROTECTOR
PRIORITY ENCODER
TIMING CIRCUIT
EFM DEMODULATOR
)
RESISTER
(
ADDRESS GENERATOR
27 L1 (+)
ATT 3
43 PSSL
DIGITAL PLL VARI-PITCH DOUBLE SPEED
FIR2
CLOCK GENERATOR
13942296513
13942296513
68 69 18 13 12 33 32 31 34 36 38 39 42 73 74 76 75 72 78 77 95 94 96 97
TEL
TEL
C4M C16M PDO VCO1 VCO0 PCO FILI FILO CLTV RFAC ASYI ASYO ASYE WFCK SCOR EXCK SBSO EMPH SQCK SQSO MON FSW MDP MDS
28 D Vdd 2
INIT 1 SYSM 2
32K RAM
MODE
20 19
S/P
67 62 63 64
MUTE CIRCUIT
VCKI VPCO
• Video section
FSTO XTAI XTAO XTSL
• BD section
AC DITHER
QQ 3 7 6 3 1 5 1 5 0
7-19. IC BLOCK DIAGRAMS
http://www.xiaoyu163.com
QQ 376315150 892498299 IC271 BU6257AFV
18 17 16 15 14 13 12 11
VB VG VR BBLK GBLK RBLK VC1 BLK1
HSYNC VSYNC
20 19
HORIZONTAL SIZE COUNTER
HORIZONTAL POSITION COUNTER
HORIZONTAL ADDRESS COUNTER
CHARACTER DATA 3 BIT × 288 WORD
VERTICAL ADDRESS REGISTER
PROTECT CIRCUIT
TEL
VERTICAL POSITION COUNTER
CHARACTER DATA 8 BIT × 288 WORD
CHARACTER GENERATOR ROM 12 × 18 BIT × 255 WORD
VERTICAL ADDRESS COUNTER
6
7
TEST
5
OSCIN
4
BACKGROUND CONTROLLER DATA REGISTER
OSCILLATOR CIRCUIT
OSCOUT
CKOUT
3
VDD
DATA
2
RESET
1
CSB
CLK
DATA INPUT SHIFT REGISTER
13942296513
13942296513
DISPLAY CONTROLLER DATA REGISTER
8
VSS 10
CBLNKO VSYNCO HSYNCO VSS5 BO7 BO6 BO5 BO4 BO3 BO2 BO1 BO0 VDD3 Y/GO7 Y/GO6 Y/GO5 Y/GO4 Y/GO3 Y/GO2 Y/GO1 Y/GO0 VDD2 C/RO7 C/RO6 C/RO5 C/RO4 C/RO3 C/RO2 C/RO1 C/RO0
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
8
81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
8
8
MICRO COMPUTER INTERFACE
Y
B-Y
YUV-RGB CONVERSION C/R-Y
TIMING GENERATOR
D-RAM
Y
B-Y
NOISE REDUCER
C/R-Y
CSYNCO HAPGAIN0 HAPGAIN1 TEST TEN HAPBPF0 IFSEL1 HAPBPF1 NRON LEVEL0 LEVEL1 FNR UFRZ XRST VSS7 CSYNCI CBLNKI VSYNCI HSYNCI VDD5 DCLKI
RGB-YUV CONVERSION
8
MEMORY CONTROLLER
8
50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31
VSS4 VCPT VCP HVCCT HVCC ADVS ADVD CORON BLCKST3 VSS3 BLCKST2 BLCKST1 BLCKST0 VDD1 BLCKSIZE BLCKNR1 BLCKNR0 SXP COM SDO SDI
8
VSSO BI7 BI6 BI5 BI4 BI3 BI2 BI1 BI0 VSS1 Y/GI7 Y/GI6 Y/GI5 Y/GI4 Y/GI3 Y/GI2 Y/GI1 Y/GI0 VSS2 C/RI7 C/RI6 C/RI5 C/RI4 C/RI3 C/RI2 C/RI1 C/RI0 VDD0 XCS XSCK
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
www
.
xiaoy u163. com — 75 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
IC301 CXD1854Q
TEST CIRCUIT
9
TEL
VERTICAL SIZE COUNTER
COLOR DATA 3 BIT × 288 WORD
OUTPUT CONTROL
WRITE ADDRESS COUNTER
VIDEO RAM
HORIZONTAL ADDRESS REGISTER
DATA SELECTOR
CHARACTER SIZE REGISTER
http://www.xiaoyu163.com
QQ 376315150 892498299 XVRST
XCS SCK SI
VSS
TDO TCK TMS TDI VDD TRST VSS XTEST1 XTEST3 TD8 TD9 VDD TD1O
IC401 CXD1913Q
51
50 49 48
47
46 45 44 43 42 41 40 37-39 36 35 34 33
-
F1 52 VDD 53
3
XTEST4 54 SYNC Gen. and Timing Controller
XRST 55
BURST FLAG CSYNC
SYSCLK 56 57 58 59 60 61 62 63 64
TEST MODE
1/2 SIO and I2O-Bus Controller
Closed Caption Encoder (for NTSC)
32 CO
10bit DAC
Delay LPF Modulator
CHROMA
LPF
Y, C/ Y, U, V selector and Interpolator
8
10bit DAC
29 YO
10bit DAC
28 AVSS2 27 AVDD2
QQ
4
6-9 10 11-18
19
-
-
VSS
Y7 Y4 VSS Y3 Y0 VDD C7 C0
5
-
• Main section IC102 MC14052BCP
VDD
2
1
COMMON
0
3
SEL.A
SEL.B
IC103, 1702 MC14053BCP
16
15
14
13
12
11
10
9
B1
1
B0
2
16 VDD 15 B.COM OPEN
C1
3
C.COM
4
14 A.COM 13 A1
www
4
5
6
7
8
1
INHIBIT
VEE
VSS
3
3
2
COMMON
0
1
2
DECODER
OPEN
.
CO
5
12 A0
INH
6
11 A
VEE
7
VSS
8
OPEN
10 B 9
C
xiaoy u163. com — 76 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513 1-4
VG VB COMPO AVSS1 AVDD1 VREF IREF
QQ
26 25 24 23 22 21 20
8
4
31 AVSS3 30 AVDD3
13942296513
13942296513
Y Dempx, Level Translator U and Interpolator 4 : 2 : 2 to V 4:4:4
TEL
TEL
PDCLK VSS VSYNC HSYNC SO FID VDD XIICEN
SYNC Slope Gen.
Sub Carrier Gen.
http://www.xiaoyu163.com
QQ 376315150 892498299 IC601 LA2786
1 2
NOISE FILTER
VREF
3
V REF
LPF
NOISE CH
NOISE GENERATOR BALANCE CONTROL DIVIDER
VSS
11
OSC1
38
VCC
37
L-OUT
36
R-OUT
35
S-OUT
VR
VR
P. S. P. S.
VCA
VCA
VCA
VCA
VCA
VCA
VCA
13 14
DC CUT DC CUT R RECT L RECT
15 16 17 18
VLR-TH
19
VLR-1 VLR-2
20 21
TEL 13942296513 RECT
RECT
DUAL T CONTROL
RECT
+
LOG DIFF
QQ +
RECT
LOG DIFF
30 29
R-BPF2 R-BPF3
28 27 26 25
DC CUT
24
VCS-TH
23 22
VCS-1 VCS-2
DC CUT L-R RECT L+R RECT
IC901 LA5617
VSS 1
16 VDD
OUT 2
15 OUT L-CH DATA LATCH CIRCUIT
IN 3
R-BPF1
376315150 892498299
IC604 TC9210P
L-CH
31
R-CH DATA LATCH CIRCUIT
14 IN
A-GND 4
ON/OFF
CURRENT LIMITER
CURRENT LIMITER
VMUTE
R-CH
VCC
13 A-GND VREF VCC
OVER HEAT PROTECT
xiaoy u163. com
ERROR AMP
1
2
3
4
5
6
7
8
9
10
CN2
VEE
VO2
9 DATA
NC
10 STB
GND
STROBE OSC CIRCUIT
LEVEL SHIFT CIRCUIT
EN DISPLAY
.
SHIFT RESISTER (13bit)
VREF _1.8V ~
EN
LEVEL SHIFT CIRCUIT
ERROR AMP
11 CS2
CN1
CK 8
VREF
VCC
www
START CIRCUIT
12 NC
CS1 6
GND 7
ON/OFF
VO1
NC 5
376315150 892498299
376315150 892498299
L-BPF2 L-BPF3
LPF
C-OUT CMODE-CAP. C-TRIM DC CUT
QQ
QQ
12
34 33 32
13942296513
13942296513
VCA
LPF L-BPF1
DATA ENABLE
~_140uA COMPARATER
10
39
CTRIM
R-IN
OSC
MUTE
9
CLK
TEL
L-IN
TEL
R-CH DC OUT VREF
4 5 6 7 8
42 41 40
VR CONTROL
CMODE
S-CH DC OUT C-CH DC OUT L-CH DC OUT
CONTROL
BPF1 BPF2
— 77 —
http://www.xiaoyu163.com
http://www.xiaoyu163.com
QQ 376315150 892498299 S-OUT
19
VREF
20
21
R-OUT
22
L-OUT
VDD
23
A.GND
OSC
24
DC-CUT
OSC
IC602 LV1016
18
17
16
15
14
13
ADM A
B
INV-PHASE
SRAM +
+
L+DELAY
R+DELAY
A
B
A
ADM-CONT
B
A
VDD
A
B
VOL/MUTE
B OUT-FILTER (7k/5k)
–
DC-OUT
L–R
TEL
TEL
IN-FILTER (40kHz)
S-TRIM
+ L+R (–6dB)
7
8
9
10
NR-IREF
VCC
L-IN
R-IN
S-IN
12
IC602 uPC1330HA
T.S.D
INVERTER
O.C.P MOTOR DRIVE
MOTOR DRIVE
COMPARATER 2
1
SW R1 GND
4
3
SW P1 CONT
5
6
GND
VCC
7
8
9
SW P2 GND
SW R2
1
2
3
4
5
6
7
8
9
10
GND
MOTOR DRIVE
NOISE FILTER
CLAMP
FWD.IN
REV.IN
VCC 1
VCC 2
NOISE FILTER
MOTOR DRIVE
FWD/REV/STOP CONTROL LOGIC
OP2IN
OP2OUT
LPF2IN
LPF2OUT
IC301 uPC1237HA
REF
IC761 M65850P CLOCK
• Power section
VCC
• Panel section
14
13
12
11
10
9
8
OVER LOAD DET VCC ON MUTE
F/F OSCILLATOR
D/A
OFFSET DET
LPF2
1/2 VCC
A/D
2
3
4
5
OP1OUT
OP1IN
CC1
LPF1IN
1
LPF1OUT
LPF1
MO MI
.
xiaoy u163. com LATCH/ AUTORESET
20KBIT SRAM
AC OFF DET
1
6
2
3
7
GND
www MAIN RESET CONTROL D1 DO0
CC2
DO1
CLOCK
AUTO RESET
— 78 —
http://www.xiaoyu163.com
4
5
6
7
VCC 8
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
IC402 LB1641
QQ
QQ
• Deck section
11
DC-CUT
6
B
A
5
DELAY-OUT
4
NR-DET
B
A
3
ENABLE
B
2
DATA
D.GND
1
CLK
DEC
13942296513
13942296513
A
B-NR
http://www.xiaoyu163.com
QQ 376315150 892498299 • CD motor section IC201 TA8409S
VREF BLOCK
STANDBY BLOCK
TEL
TEL
HEAT CUT OFF BLOCK 5 GND
4 NC
6 VS
8 VREF
7 OUT1
9 IN1
• KEY CON section
KEY UP
CLKO/KEY0
SDATA/KEY1
11
12
13
15 MIXOUT
14
VCC
KEY DOWN
10
GND
DA2CONT
9
REF
DA1CONT
8
KEY5
7
KEY4
6
16 MIXIN
REF
STROBE/KEY3
5
MIX
REF
CLOCK GENERATOR
SCK/KEY2
4
17 LPF2OUT
18 LPF2IN
LPF2
IC1403 MC14053BCP B1
1
B0
2
16 VDD 15 B.COM OPEN
C1
3
C.COM
4
14 A.COM 13 A1 OPEN
CO
5
12 A0
INH
6
11 A
VEE
7
www VSS
OPEN
8
10 B
xiaoy u163. com 9
.
C
— 79 —
http://www.xiaoyu163.com
376315150 892498299
3
–
REF
LOGIC
2
QQ 376315150 892498299 +
1
HPF
REF
RAM
D/A
–
+
RESET
–
+
LPF1 REF
19 HPFOUT
20 HPFIN
21 LPF1OUT
22 LPF1IN
24 ADINTOUT
25 DAIINTIN
26 DAIINTOUT
27 MODE1
23 ADINTIN
–
A/D
+
376315150 892498299
TEL 13942296513
QQ
QQ
28 MODE2
IC1401 M65847FP
ADCONT
13942296513
3 OUT2
13942296513
2 VCC
1 IN2
http://www.xiaoyu163.com
QQ 376315150 892498299
7-20. IC PIN FUNCTIONS
• IC101 DIGITAL SIGNAL PROCESSOR (CXD2545Q)/BD board Pin No.
Pin Name
Function
I/O O
Sled drive output
3
SFON
O
Sled drive output (Not used)
4
TFDR
O
Tracking drive output
5
TRON
O
Tracking drive output (Not used)
6
TRDR
O
Tracking drive output
7
TFON
O
Tracking drive output (Not used)
8
FFDR
O
Focus drive output
9
FRON
O
Focus drive output (Not used)
10
FRDR
O
Focus drive output
11
FFON
O
Focus drive output (Not used)
12
VCOO
O
VCO output for analog EFM (Eight to Fourteen Modulation) PLL (Not used)
13
VCOI
I
VCO input from analog EFM (Eight to Fourteen Modulation) PLL (Ground)
14
TEST
I
TEST pin connected normally to ground
15
DVSS
–
Digital ground
16
TES2
I
TEST pin connected normally to ground
17
TES3
I
TEST pin connected normally to ground
18
PDO
O
Charge-pump output for analog EFM (Eight to Fourteen Modulation) PLL (Not used)
19
VPCO
O
Charge-pump output for variable pitch PLL (Not used)
20
VCKI
I
Clock input from variable pitch external VCO (Ground)
21
AVD2
–
Analog power supply
22
IGEN
I
Power supply pin for operational amplifiers
23
AVS2
–
Analog ground
24
ADIO
I
(Not used)
25
RFC
O
(Not used)
26
RFDC
I
RF signal input
27
TE
I
Tracking error signal input
28
SE
I
Sled error signal input
29
FE
I
Focus error signal input
30
VC
I
Center voltage input pin
31
FILO
O
Filter output for master PLL
32
FILI
I
Filter input for master PLL
33
PCO
O
Charge-pump output for master PLL
34
CLTV
I
Control voltage input for master VCO
35
AVS1
–
Analog ground
36
RFAC
I
EFM (Eight to Fourteen Modulation) signal input
37
BIAS
I
Asymmetry circuit constant current input
38
ASYI
I
Asymmetry comparate voltage input
39
ASYO
O
EFM (Eight to Fourteen Modulation) full swing output
40
AVD1
–
Analog power supply
41
DVDD
–
Digital power supply
42
ASYE
I
Asymmetry circuit ON/OFF
43
PSSL
44
WDCK
45
LRCK
46
DATA
47
BCLK
48
64DATA
49
64BCLK
50
64LRCK
TEL 13942296513
www
.
QQ 376315150 892498299
xiaoy u163. com I
Audio data output mode selection input
O
48-bit slot D/A interface. word clock.
O
48-bit slot D/A interface. LR clock.
O
DA 16 output when PSSL=1. 48-bit slot serial data when PSSL=0
O
DA 15 output when PSSL=1. 48-bit slot data when PSSL=0
O
DA 14 output when PSSL=1. 64-bit slot data when PSSL=0 (Not used)
O
DA 13 output when PSSL=1. 64-bit slot data when PSSL=0 (Not used)
O
DA 12 output when PSSL=1. 64-bit slot data when PSSL=0 (Not used)
— 80 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
Sled drive output (Not used)
QQ
QQ
O
SRDR
13942296513
13942296513
SRON
2
TEL
TEL
1
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin No.
Pin Name
Function
I/O
53
XPLCK
O
DA 09 output when PSSL=1. XPLCK output when PSSL=0
54
GFS
O
DA 08 output when PSSL=1. GFS output when PSSL=0
55
PFCK
O
DA 07 output when PSSL=1. RFCK output when PSSL=0
56
C2PO
O
DA 06 output when PSSL=1. C2PO output when PSSL=0 (Not used)
57
XRAOF
O
DA 05 output when PSSL=1. XRA0F output when PSSL=0
58
MNT3
O
DA 04 output when PSSL=1. MNT3 output when PSSL=0
59
MNT2
O
DA 03 output when PSSL=1. MNT2 output when PSSL=0
60
MNT1
O
DA 02 output when PSSL=1. MNT1 output when PSSL=0
61
MNT0
O
DA 01 output when PSSL=1. MNT0 output when PSSL=0
62
XTAI
I
X’tal oscillator circuit input
63
XTAO
O
X’tal oscillator circuit output (Not used)
64
XTSL
I
X’tal selection input pin (Ground)
13942296513
65
DVSS
–
Digital ground
66
FSTI
I
2/3 divider input of pins 62, 63
67
FSTO
O
2/3 divider output of pins 62, 63
68
FSOF
O
(Not used)
69
C16M
O
16.9344 MHz output (Not used)
70
MD2
I
Digital-out ON/OFF control pin (+5V)
71
DOUT
O
Digital-out output pin
QQ
72
EMPH
O
Playback disc output in emphasis mode (Not used)
73
WFCK
O
WFCK (Write Frame Clock) output
74
SCOR
O
Sub-code sync output
75
SBSO
O
Sub-P through Sub-W serial output (Not used)
76
EXCK
I
Clock input for SBSO read-out (Ground)
77
SUBQ
O
Sub-Q 80-bit output
78
SQCK
I
Clock input for SQSO read-out
79
MUTE
I
Muting selection pin
80
SENS
O
SENS output
81
XRST
I
System reset
82
DIRC
I
Used in 1-track jump mode (+5V)
83
SCLK
I
SENS serial data read-out clock
84
DFSW
I
Defect selection pin (Ground)
85
ATSK
I
Input pin for anti-shock (Ground)
86
DATA
I
Serial data input, supplied from CPU
87
XLAT
I
Latch input, supplied from CPU
88
CLOK
I
Serial data transfer clock input, supplied from CPU
89
COUT
O
Numbers of track counted signal output (Not used)
90
DVDD
–
Digital power supply
91
MIRR
O
Mirror signal output
92
DFCT
O
Defect signal output
93
FOK
O
Focus OK output
94
FSW
O
Output to select spindle motor output filter (Not used)
O
Output to control ON/OFF of spindle motor (Not used)
O
Output to control spindle motor servo
O
Output to control spindle motor servo (Not used)
376315150 892498299
TEL 13942296513
www 95
MON
96
NDP
97
MDS
98
LOCK
99
SSTP
100
SFDR
.
QQ 376315150 892498299
xiaoy u163. com O
GFS (Guarded Frame Sync) is sampled by 460 Hz.
H when GFS (Guarded Frame Sync) is H (Not used)
I
Input signal to detect disc inner most track
O
Sled drive output
— 81 —
http://www.xiaoyu163.com
376315150 892498299
DA 10 output when PSSL=1. XUGF output when PSSL=0 (Not used)
QQ
DA 11 output when PSSL=1. GTOP output when PSSL=0 (Not used)
O
13942296513
O
XUGF
TEL
GTOP
52
TEL
51
http://www.xiaoyu163.com
QQ 376315150 892498299
• IC201 MPEG DECODER (CXD1852AQ)/VIDEO board Pin No.
Pin Name
Function
I/O
1
VSS
–
2
XTL0O
O
3
XTL0I
I
8fsc), and 35.4686 MHz (PAL 8fsc).
4
VDD
–
+5V power supply
5
HA2
I
Address input pin. In some cases, serves as the control signal and data input according to
6
HA3
I
the setting of the control mode.
7
HD0
I/O
8
HD1
I/O
Ground
Video decoder master clock pin. Input the XTL0I clock or connect an oscillator between XTL0I and XTL0O. The recommended frequencies are 27MHz, 28.6363MHz (NTSC
I/O
HD3
I/O
11
HD4
I/O
12
HD5
I/O
13
HD6
I/O
14
VDD
–
+5V power supply
15
VSS
–
Ground
16
HD7
I/O
17
MA3
O
18
MA4
O
19
MA2
O
QQ
20
MA5
O
21
MA1
O
376315150 892498299
22
VSS
–
23
MA6
O
24
MA0
O
25
BC
I
26
TCKI
I
27
TDI
I
28
TENAI
I
29
TDO
I
30
VST
I
For test (Connect to ground)
31
VSS
–
Ground
32
MA7
O
33
MA8
O
34
XRAS
O
35
XMWE
O
Data input/output
Address signal pin. Connect to the DRAM address pin with the same number.
For test (Not used)
Address signal pin. Connect to the DRAM address pin with the same number. RAS signal pin. Connect to the RAS pin of the DRAM. Same for the 256Kw × 16b, 256Kw × 16b × 2, and 512Kw × 8b × 2 DRAM structures. WE signal pin. Connect to the WE pin of the DRAM. CAS signal. Connect to the CAS pin of the DRAM so as to control the lower bytes of the
XCAS2
O
/MA9
upper word (256K to 512K-1) for the 256Kw × 16b × 2 DRAM structure. / Address signal pin. Connect to the DRAM address pin with the same number. (Not used) CAS signal. Connect to the CAS pin of the DRAM so as to control the lower bytes (MD0
37
XCAS0
www
38
MD7
39
MD8
40
MD6
O
to MD7) for 256Kw × 16b and 512Kw × 8b × 2 DRAM structures, and to control the lower bytes of the lower word (0 to 256K-1) for the 256Kw × 16b × 2 DRAM structure.
xiaoy u163. com I/O I/O
.
I/O
Data input/output signal pin. Connect to the DRAM data pin so that the lower and upper bytes of the data correspond to the CAS0 to CAS3 controls.
— 82 —
http://www.xiaoyu163.com
376315150 892498299
Address signal pin. Connect to the DRAM address pin with the same number.
QQ
QQ 376315150 892498299
Ground
13942296513
13942296513
Data input/output
TEL 13942296513
36
TEL
HD2
TEL
9 10
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin Name
Pin No.
I/O
Function
41
MD9
I/O
42
MD5
I/O
43
MD10
I/O
44
VDD
–
+5V power supply
45
VSS
–
Ground
46
MD4
I/O
47
MD11
I/O
48
MD3
I/O
49
MD12
I/O
50
MD2
I/O
Data input/output signal pin. Connect to the DRAM data pin so that the lower and upper
51
MD13
I/O
bytes of the data correspond to the CAS0 to CAS3 controls.
TEL
52
MD1
I/O
53
MD14
I/O
54
MD0
I/O
13942296513
55
MD15
I/O
56
XOSDEN
I
57
OSDB
I
58
OSDG
I
59
OSDR
I
60
VDD
–
+5V power supply
61
VSS
–
Ground
Data input/output signal pin. Connect to the DRAM data pin so that the lower and upper bytes of the data correspond to the CAS0 to CAS3 controls.
TEL
OSD data input pin. When the XOSDEN input is “L”, the color registered in the register specified by this 3 inputs (3 bits) is output as the image data.
QQ 376315150 892498299
XVOE
I
63
R/Cr0
O
64
R/Cr1
O
65
R/Cr2
O
66
R/Cr3
O
Output pin of the R or Cr signal of the image data. MSB is R/Cr7. Synchronizes with
67
R/Cr4
O
DCLK.
68
R/Cr5
O
69
R/Cr6
O
70
R/Cr7
O
71
G/Y0
O
72
G/Y1
O
73
G/Y2
O
74
VDD
–
+5V power supply
75
VSS
–
Ground
76
G/Y3
O
77
G/Y4
O
78
G/Y5
O
79
G/Y6
O
80
G/Y7
O
www
.
output. When set to “H”, disables (high impedance). Output control can also be performed by writing in the register. (Connected to ground)
Output pin of the G or Y signal of the image data. MSB is G/Y7. Synchronizes with DCLK.
Output pin of the G or Y signal of the image data. MSB is G/Y7. Synchronizes with DCLK.
xiaoy u163. com — 83 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513 62
QQ
QQ
Video output enable signal pin. When set to “L”, enables the image data output and DCLK
13942296513
OSD enable signal
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin Name
Pin No.
I/O
Function
81
B/Cb0
O
82
B/Cb1
O
83
B/Cb2
O
84
B/Cb3
O
Output pin of the B or Cb signal of the image data. MSB is B/Cb7. Synchronizes with
85
B/Cb4
O
DCLK. (Not used)
86
B/Cb5
O
87
B/Cb6
O
88
B/Cb7
O
89
DCLK
I
Dot clock (DCLK) signal pin. The DCLK frequency is normally 13.5MHz. The DCLK can be input from this pin or can be made by frequency-dividing (1/integer) the clock input from XTL0I. –
+5V power supply
91
VSS
–
Ground
92
HSYNC
I
Horizontal sync signal pin. When using the built-in sync generator, a signal is made by frequency-dividing the dot clock (DCLK). Serves as the input when not using the built-in sync generator. 93
VSYNC
I
Vertical sync signal pin. When using the built-in sync generator, a signal is made by frequency-dividing the DCLK. Serves as the input when not using the built-in sync generator. Field determination signal. Odd field correspond to “H” and even field correspond to “L”.
94
Serves as an output when the built-in sync generator is used, and as an input when not.
FID
I
/FHREF
/ Signal obtained by frequency-dividing the clock input from XTL0I or XTLI. When the
TEL 13942296513
95
Composite blanking signal pin. Serves as an output when the built-in sync generator is
CBLNK
I
/FSC
used, and as an input when not. / Signal obtained by frequency-dividing the clock input from XTL0I or XTLI. When the input clock is 8 fsc, it can be used as the fsc signal. Composite sync signal pin. A signal is made by frequency-dividing the DCLK. Cannot be
96
CSYNC
O
97
XSGRST
I
98
CLK0O
O
99
DOUT
O
Digital output (Not used)
100
DATO
O
Audio serial data output to Audio D/A converter (IC101)
101
LRCO
O
LR clock output to Audio D/A converter (IC101)
102
BCKO
O
Bit clock output to Audio D/A converter (IC101)
103
FSXI
I
Input 384fs (16.9344MHz) or 768fs (33.8688MHz).
104
VDD
–
+5V power supply
105
VSS
–
Ground
106
XTL2O
O
CD-ROM decoder, audio decoder master clock. Input a clock to the XTL21 or connect an
input. (Not used) Sync generator reset signal pin. The signal generator is initialized by setting this pin to “L”. Outputs the frequency-divided clock of the clock input to XTL0I. The frequency dividing ratio can be selected from 1/2, 1/4, and 1/8. (Not used)
oscillator between XTL2I and XTL2O. The recommended frequency is 45 MHz. This 107
XTL2I
I
clock is for the internal circuit. Does not synchronize with inputs and outputs.
108
VDD
–
+5V power supply
109
C2PO
I
C2 pointer input (CXD2545Q)
www
110
xiaoy u163. com I
LRCI
.
LR clock input (CXD2545Q)
— 84 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
signal.
QQ
QQ
input clock is 8 fsc, it can be used as the horizontal sync signal phase comparison reference
13942296513
13942296513
VDD
TEL
TEL
90
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin No.
Pin Name
I/O
Function
111
DATI
I
Serial data input (CXD2545Q)
112
BCKI
I
Bit clock input (CXD2545Q)
113
DOIN
I
Digital input signal (Not used)
114
XHCS
I
Register access chip select signal pin.
115
XHDT
I/O
116
HRW
I
Register access control signal pin.
117
XHIRQ
O
Interrupt request signal
118
XRST
I
Hardware reset input pin. When set to “L”, all registers and operations are reset and initialized.
119
HA0
I
Address input pin. In some cases, serves as the control signal and data input according to
120
HA1
I
the setting of the control mode.
Data acknowledge/wait signal pin for DMA transmission, register access, transparent memory access.
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com — 85 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299
• IC301 NOISE REDUCTION (CXD1854Q)/VIDEO board Pin No.
Pin Name
I/O
Function
1
VSS
–
Ground
2
BI7
I
[MSB]
3
BI6
I
4
BI5
I
5
BI4
I
6
BI3
I
7
BI2
I
8
BI1
I
B input 0–7 (Connect to ground)
I
[LSB]
VSS
–
Ground [MSB]
I
13
Y/GI5
I
14
Y/GI4
I
15
Y/GI3
I
16
Y/GI2
I
17
Y/GI1
I
18
Y/GI0
I
[LSB]
19
VSS
–
Ground
20
C/RI7
I
[MSB]
C/RI6
I
G (Y) input 0–7
22
C/RI5
I
376315150 892498299
23
C/RI4
I
24
C/RI3
I
25
C/RI2
I
26
C/RI1
I
27
C/RI0
I
[LSB]
28
VDD
–
Power supply (+5V)
29
XCS
I
Chip select input from IIC interface (IC901)
30
XSCK
I
Serial clock input from IIC interface (IC901)
31
SDI
I
Serial data input from IIC interface (IC901)
32
SDO
O
Serial data output. (Not used)
33
SXP COM
I
Serial/parallel select
34
BLCKNR0
I
NR effect level control input
35
BLCKNR1
I
NR effect level control input
36
BLCKSIZE
I
Block size select input
37
VDD
–
Power supply (+5V)
38
BLCKST0
I
RAS signal for DRAM (Connected to ground)
39
BLCKST1
I
CAS signal for DRAM (Connected to ground)
40
BLCKST2
I
Write enable signal for DRAM (Connected to ground)
41
VSS
–
Ground
42
BLOCKST3
I
DRAM data input (Connected to ground)
43
CORON
I
DRAM data input (Connected to +5V)
I
DRAM data input (Connected to +5V)
I
DRAM data input (Connected to ground)
I
DRAM data input (Not used)
I
DRAM data input (Connected to +5V)
I
DRAM data input (Not used)
I
DRAM data input (Connected to ground)
–
Ground
TEL 13942296513
www
44
ADVD
45
ADVS
46
HVCC
47
HVCCT
48
VCP
49
VCPT
50
VSS
.
R (Cb/Cr) input 0–7
QQ 376315150 892498299
xiaoy u163. com — 86 —
http://www.xiaoyu163.com
376315150 892498299
QQ
21
QQ
I
Y/GI6
13942296513
Y/GI7
TEL
11 12
TEL
BI0
13942296513
9 10
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin Name
Pin No.
Function
I/O
C/RO0
O
52
C/RO1
O
53
C/RO2
O
54
C/RO3
O
55
C/RO4
O
56
C/RO5
O
57
C/RO6
O
58
C/RO7
O
[LSB]
59
VDD
–
Power supply (+5V)
60
Y/GO7
O
[MSB]
61
Y/GO6
O
TEL
62
Y/GO5
O
63
Y/GO4
O
64
Y/GO3
O
13942296513
65
Y/GO2
O
66
Y/GO1
O
67
Y/GO0
O
[LSB]
68
VDD
–
Power supply (+5V)
69
BO0
O
[MSB]
70
BO1
O
71
BO2
O
QQ
[MSB]
51
72
BO3
O
G (Y) output 0–7
74
BO5
O
75
BO6
O
76
BO7
O
[LSB]
77
VSS
–
Ground
78
HSYO
O
H SYNC output (Not used)
79
VSYO
O
V SYNC output (Not used)
80
CBLO
O
Composit blanking output (Not used)
81
CSYO
O
Composit SYNC output (Not used)
82
HAPGAIN0
I
Profile cooperation effect level control
83
HAPGAIN1
I
Profile cooperation effect level control
84
TEST
I
Test pin (Connect to ground)
85
TEN
I
Test pin (Connect to +5V)
86
HAPBPF0
I
Profile cooperation correction band control
87
IFSEL 1
I
Matrix select Y/C, RGB (Connect to ground)
88
HAPBPF1
I
Profile cooperation correction band control
89
NRON
I
Noise reducer on/off (L: off, H: on)
90
LEVEL 0
I
Noise reducer level select
91
LEVEL 1
I
0: weak –3: strong (Not used)
92
FNR UFRZ
I
NR feedback coefficient deser processor select (Connect to +5V)
93
XRST
I
Power on reset
94
VSS
–
Ground
I
Composit SYNC input (Connect to ground)
I
Composit blanking input (Connect to +5V)
I
V SYNC input
I
H SYNC input
–
Power supply (+5V)
I
Dot clock input (13.5MHz)
www 95
CSYI
96
CBLI
97
VSYI
98
HSYI
99
VDD
100
DCLKI
.
xiaoy u163. com — 87 —
http://www.xiaoyu163.com
376315150 892498299
O
QQ
QQ 376315150 892498299
BO4
13942296513
B output 0–7 (Not used)
73
TEL
376315150 892498299
TEL 13942296513
R (Cb/Cr) output 0–7
http://www.xiaoyu163.com
QQ 376315150 892498299
• IC401 10 BIT VIDEO D/A CONVERTER (CXD1913Q)/VIDEO board Pin No.
Pin Name
I/O
Function
1
Y7
I
8-bit pixel data input pins (PD0 to 7).
2
Y6
I
When control register bit “PIF MODE”=“0”, serve as input pins for multiplexed Y, Cb,
3
Y5
I
Cr signals.
4
Y4
I
When control register bit “PIF MODE”=“1”, serve as input pins for Y signal
5
VSS
–
Digital ground
6
Y3
I
8-bit pixel data input pins (PD0 to 7).
7
Y2
I
When control register bit “PIF MODE”=“0”, serve as input pins for multiplexed Y, Cb,
8
Y1
I
Cr signals.
9
Y0
I
When control register bit “PIF MODE”=“1”, serve as input pins for Y signal
10
VDD
–
Digital power supply
I
C6
I
8-bit pixel data input pins/test data bus.
13
C5
I
When control register bit “PIF MODE”=“0”, these input pins cannot be used.
14
C4
I
When control register bit “PIF MODE”=“1”, serve as input pins for multiplexed Cb, Cr
15
C3
I
signals.
16
C2
I
In the test mode, used for internal circuit test data bus.
17
C1
I
The test mode is allowed to use only for device vendors
18
C0
I
19
VSS
–
20
IREF
O
Digital ground Reference current output pin.
VREF
I
22
AVDD1
–
Analog power supply
QQ 376315150 892498299
23
AVSS1
–
Analog ground
Sets the output full-scale value
10-bit D/A converter output. 24
COMPO
O
When control register bit “YC/YUV”=“1”, outputs the composite signal. When control register bit “YC/YUV”=“0”, outputs the color difference (V) signal
25
VB
I
Connect to Vss with an approx. 0.1 µF capacitor
26
VG
I
Connect to AVDD with an approx. 0.1 µF capacitor
27
AVDD2
–
Analog power supply
28
AVSS2
–
Analog ground
29
YOUT
O
30
AVDD3
–
Analog power supply
31
AVSS3
–
Analog ground
10 bit D/A converter output. (Luminance (Y) signal output.)
10-bit D/A converter output. 32
COUT
O
When control register bit “YC/YUV”=“1”, outputs the chroma (C) signal. When control register bit “YC/YUV”=“0”, outputs the color difference (U) signal Test data bus.
33
TD10
O
34
VDD
–
In the test mode, used for internal circuit test data bus. The test mode is allowed to use only for device vendors (Not used)
www
.
Digital power supply
xiaoy u163. com — 88 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
Voltage reference input pin.
21
QQ
QQ
Connect a resistor ×16 times (“16R”) of the output resistance value “R”
13942296513
13942296513
C7
TEL
TEL
11 12
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin No. 35
Pin Name
TD9
I/O O
Function
Test data bus.
In the test mode, used for internal circuit test data bus.
36
TD8
O
The test mode is allowed to use only for device vendors (Not used)
37
XTEST1
I
Test mode control input pin. Pulled-up.
38
XTEST2
I
When these pins are “H”, CXD1913Q is not in the test mode.
39
XTEST3
I
The test mode is allowed to use only for device vendors
40
VSS
–
Digital ground
41
TRST
I
42
VDD
–
TEL
43
TDI
I
44
TMS
I
45
TCK
I
Test mode control input pin. Fix at “H”
13942296513
46
TDO
O
Test data bus pin. (Not used)
47
VSS
–
Digital ground
Test mode reset input pin. During power on/reset, set to “L” for more than 40 clocks (SYSCLK) (Not used) Digital power supply
When the XIICEN pin is “H”, sets into the SONY SIO mode, and becomes the SI serial 48
SI
I
data input pin. When the XIICEN pin is “L”, sets into the I2C-BUS mode, and becomes the SDA input/ output pin
SCK
When the XIICEN pin is “H”, sets into the SONY SIO mode, and becomes the SCK serial
I
clock input pin.
When the XIICEN pin is “L”, sets into the I2C-BUS mode, and becomes the SCL input pin The functions of this pin are selected by Pin 64 XIICEN. Pulled-up. When the XIICEN pin is “H”, sets into the SONY SIO mode, and becomes the XCK chip
50
XCS
I
select input pin. When the XIICEN pin is “L”, sets into the I2C-BUS mode, and becomes the SA slave address selection input signal which selects the I2C-BUS slave address Active “L” vertical sync reset input pin. Pulled-up.
51
XVRST
I
Used for synchronizing external vertical sync and internal vertical sync. When XVRST is “L”, the internal digital sync generator is reset according to the F1 state Field ID input pin. When externally synchronizing with the XVRST signal, the field to be reset is determined
52
F1
I
by this signal. “H” indicates the first field. “L” indicates the second field
53
VDD
–
Digital power supply Test mode control input pin. Pulled-up.
54
XTEST4
I
When these pins are “H”, CXD1913Q is not s test mode. The test mode is allowed to use only for device vendors
55
XRST
www 56
SYSCLK
.
I
System reset input pin when active “L”. During power on/reset, set to “L” for more than 40 clocks (SYSCLK)
xiaoy u163. com I
System clock input pin.
To generate the correct sub carrier frequency, precisely 27MHz is required
— 89 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513 49
QQ
QQ
The functions of this pin are selected by Pin 64 XIICEN.
13942296513
The functions of this pin are selected by Pin 64 XIICEN.
TEL
Test mode control input pin. (Not used)
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin No.
Pin Name
Function
I/O
13.5MHz pixel data clock output pin.
This clock is obtained by 1/2 frequency-dividing SYSCLK.
57
PDCLK
O
58
VSS
–
Digital ground
59
VSYNC
O
V.sync signal output
60
HSYNC
O
H.sync signal output
Used only in the 16-bit pixel data mode
The functions of this pin are selected by Pin 64 XIICEN. 61
SO
O
When the XIICEN pin is “H”, sets into the SONY SIO mode, and becomes the S0 serialout output pin. When the XIICEN pin is “L”, this pin is not used and sets into high impedance (Not used) Field ID output.
FID
O
second field. When control register bit “FDS”=“0”, “H” indicates the first field and “L” indicates the
63
VDD
–
Digital power supply Serial interface mode selection input pin. Pulled-up.
64
I
XIICEN
When “L”, Pins 48 to 50, and 61 set into the I2C-BUS mode. When “H”, Pins 48 to 50, and 61 set into the SONY SOP mode
.
xiaoy u163. com — 90 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
13942296513
13942296513
second field
TEL
TEL
When control register bit “FDS”=“1”, “L” indicates the first field and “H” indicates the 62
http://www.xiaoyu163.com
QQ 376315150 892498299 • IC701 MECHANISM CONTROL (HD6433032SK12F)/VIDEO board Pin No.
Pin Name
Function
I/O
1
CMD0
I/O
Input/output terminal exchanging data bus 0 with IIC interface (IC901)
2
CMD1
I/O
Input/output terminal exchanging data bus 1 with IIC interface (IC901)
3
CMD2
I/O
Input/output terminal exchanging data bus 2 with IIC interface (IC901)
4
CMD3
I/O
Input/output terminal exchanging data bus 3 with IIC interface (IC901)
5
SACK
O
Outputs command acknowledge to IIC interface (IC901)
6
QINT
O
Outputs command output pulses to IIC interface (IC901)
7
VDAC-XLAT
O
Serial data latch pulse output to Video D/A converter (IC401)
8
DF-XLAT
O
Serial data latch pulse output to Audio D/A converter (IC101)
P90/TXD
–
Not used
SUBQ
I
Sub Q 80bit input (CXD2545Q)
11
SQCK
O
SQSO readout clock output (CXD2545Q)
12
VSS
–
Ground Connect to the power supply (+5V)
A0 to A7
O
Address bus output (IC201, 751)
VSS
–
Ground
31 to 35
A8 to A12
O
Address bus output (IC201, 751)
36 to 39
A13 to A16
O
Address bus output (Not used)
A17, A18
O
Addres bus output (IC772)
42
A19
O
Address bus output (Not used)
43
WAIT
I
BUS control wait input (IC201)
22 to 29 30
40, 41
D0 to D7
QQ 376315150 892498299
MD0
I
Operation mode setting terminal (Connected to +5V)
45
MD1
I
Operation mode setting terminal (Connected to ground)
46
φ
O
System clock output (Not used)
47
STBY
I
48
RESET
I
Set into reset when the reset input pin becomes “Low”. (IC901)
49
NM1
I
Requests mask disable interruption. (Unable to use H level fixed) (Connected to +5V)
50
VSS
–
Ground
51
EXTAL
I
52
XTAL
I
Connected to the Crystal oscillator. (10 MHz)
53
VCC
–
Power supply (+5V)
54
AS
O
55
RD
O
56
WR
O
57
RESO
O
Reset output (Not used)
58
AVSS
–
A/D converter (Pin62-69) ground
59
TEST0
I
Color-bar test input (“L” = test)
60
TEST1
I
AFADJ test input (“L” = test)
I
ADJ test input (“L” = test)
I
Internal state (SENSE) monitor input (CXD2545Q)
I
Audio D/A converter select mode setting terminal (Connected to +5V)
I
NTSC/PAL output mode setting terminal (0V : NTSC, 1.5V : AUTO, 3V : PAL)
–
Ground
I
Not used
I
A/D converter (Pin62-69) reference voltage input (Connected to +5V)
www
(Unable to use H level fixed) (Connected to +5V)
Connected to the Crystal oscillator. The EXTAL pin is also able to input external clocks. (10 MHz)
When the address strobe pin is “Low”, indicates that address outputs on the address bus are valid. (IC772) When the read pin is “Low”, indicates that the external addresses space is in the read state. (IC201, 751) When the read pin is “Low”, indicates that the external addresses space is in the write state and the data bus are valid. (IC201, 751)
xiaoy u163. com
61
TE
62
SENS
63
DAC-SELECT
64
NPIN
65
VSS
66
VREQ
67
VREF
.
Shifts to the hardware standby mode when the standby terminal becomes “Low”.
— 91 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513 44
QQ
QQ
Data bus input/output (IC201, 751)
–
21
13942296513
13942296513
I/O
VCC
13 to 20
TEL
TEL
9 10
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin No.
Pin Name
Function
I/O
AVCC
–
A/D converter (Pin62-29) power supply (Connected to +5V)
69
CHECK-LED
O
Check LED control (Error : flashing)
70
XHIRQ
I
Interruption request input from MPEG decoder
71
SCOR
I
Subcode sync input (CXD2545Q)
72
MREQ
I
Inputs command request from IIC interface (IC901)
73
DATA
O
Serial data output
74
AMUTE
O
Mute output (“H” = mute)
75
LDON
O
Laser diode ON/OFF output
76
XLT
O
Latch output (CXD2545Q)
77
SCLK
O
SENS serial data reading clock output (CXD2545Q)
78
CLK
O
Serial data clock output
79
NR-SEL
I
Connected to +5V
80
—
–
Not used
TEL
TEL
68
13942296513
13942296513
.
xiaoy u163. com — 92 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
QQ 376315150 892498299 • IC901 IIC INTERFACE (uPD780016YGF-012-3BA)/VIDEO board Pin No. 1 to 8
Pin Name P80 to P87
I/O I
Function
Connected to ground
TEST
–
Connected to ground
10
X2
O
X’ tall (5MHz)
11
X1
I
X’ tall (5MHz)
12
VDD
–
Power supply +5V
13
XT2
–
Not used
14
XT1
–
Connected to +5V
15
RESET
I
System reset input
PO0, PO1
I
Not used (Fixed at “L”)
QINT
I
CD-BUS interrupt input
PO3 to PO6
I
Not used (Fixed at “L”)
23
VDD
–
Power supply +5V
24
AVDD
–
Power supply +5V
16, 17 18 TEL
19 to 22
I
Connected to ground
AVSS
–
Ground
34
CMD0
I/O
Input/output terminal exchanging data bus 0 with mecha-con, (IC901)
35
CMD1
I/O
Input/output terminal exchanging data bus 1 with mecha-con, (IC901)
36
CMD2
I/O
Input/output terminal exchanging data bus 2 with mecha-con, (IC901)
37
CMD3
I/O
Input/output terminal exchanging data bus 3 with mecha-con, (IC901) Connected to ground
VSS
–
Ground
P26, P27
I
Connected to ground
43
MREQ
O
Output command request to mecha-con. (IC701)
44
SACK
I
Input command acknowledge from mecha-con. (IC701)
45
CDGM
I
Not used (Fixed at “L”)
46
P93
I
Connected to ground
47
MDATA
O
Serial data output (IC271, 301)
48
MCLK
O
Serial clock output (IC271, 301)
49
OS-XLAT
O
Serial latch output to OSD (IC271)
50
G-XLAT
O
Not used
51
G-XRST
O
Not used
52
CD-XRST
O
Video CD section reset output
53
CDPOW
O
Not used
54
DOUT
O
Not used
55
IIC-DATA
I
Serial data input from master control (IC701)
56
IIC-CLK
I
Serial clock input from master control (IC701)
P40 to P47
I
Connected to ground
65
NRON
O
Not used
66
LEVEL0
O
Not used
67
LEVEL1
O
Not used
68
NR-XCS
O
Chip select output to noise reduction (IC301)
69, 70
P54, P55
I
Connected to ground
VSS
I
Ground
40 41, 42
TEL 13942296513
57 to 64
71
www 72, 73
P56, P57
QQ 376315150 892498299
xiaoy u163. com I
Connected to ground
74 to 81
P60 to P67
I
Connected to ground
82 to 85
P100 to P103
I
Connected to ground
86 to 93
P30 to P37
I
Connected to ground
94 to 100
P150 to P156
I
Connected to ground
.
— 93 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
I
QQ
QQ
P24, P25
38, 39
13942296513
13942296513
P10 to P17
33
25 to 32
TEL
9
http://www.xiaoyu163.com
QQ 376315150 892498299
• IC701 MASTER CONTROL (uPD780016YGF-019-3BA)/MAIN board Pin Name TA-MUTE
I/O O
Line mute signal outputA
2
DBFB-H/L
O
DBFB H/L select signal output
3
427-LT
O
Latch signal output for IC201 (62427)
4
KCON-LT
O
Latch signal output for key control
Pin No. 1
Function
KCON-ON
O
Key control ON/OFF signal output
F-RELAY
O
Front speaker relay control output (Not used)
7
R-RELAY
O
Rear speaker relay control output
8
PL-RELAY
O
Not used Connected to ground
TEST
I
X2
O
11
X1
I
12
VDD
–
13
XT2
O
14
XT1
I
15
RESET
I
16
INT/IN
I
17
INT/IN/OUT
I
18
SCOR
O
Subcode data request signal output (Connected to ground)
19
SOFT-TEST
O
Software test port
20
AC-CUT
I
Back up signal input
RDS-INT
I
Not used
X’tal (5MHz) TEL
TEL
9 10
13942296513
5 6
Power supply (+5V)
Reset signal input Connected to ground
RDS-DATA
I
Not used
376315150 892498299
23
VDD
–
Power supply (+5V)
24
AVDD
I
Analog reference voltage input.
25
ADJ
I
CD adjust point port Normal “H”
26
A-SHUT
I
A Deck reel pulse detector
27
B-SHUT
I
B Deck reel pulse detector
28
B-HALF
I
Half detector signal input
29
CLK-CHECK
I
Connected to ground
30
SPEC-IN
I
Version select signal input
31
ADJ 2
I
Connected to ground
32
DEMO-CHANGE
I
DEMO H/L select signal input
33
AVSS
–
Ground
34
SQ-DATA-IN
I
Subcode Q data clock input (Not used)
35
—
I
Not used
36
SQ-CLK
I
Sub code Q data clock input (Not used)
37
SW-ON/OFF
O
Not used
TEL 13942296513
38, 39
QQ 376315150 892498299
(Fixed at fixed at “L”)
FUNC 1, 2
I
Connected to ground
VSS
–
Ground
41
VOL-LAT
O
Latch signal to erectrial volume (IC604)
42
PL-LAT
O
Latch signal to pro-logic (IC601, 602)
43
COM-DIN
I
Connected to ground
44
COM-DOUT
O
Common serial data output
O
Common serial clock output
O
CD power on signal output
O
CD data output (Not used)
O
CD clock output (Not used)
O
Not used
I
Connected to ground
40
www
45
COM-CLK
46
CD-POWER
47
CD-DATA
48
CD-CLK
49
MSM-CMD
50
MSM-BUSY
.
xiaoy u163. com — 94 —
http://www.xiaoyu163.com
376315150 892498299
22
QQ
QQ
21
13942296513
X’tal (32.768 KHz)
http://www.xiaoyu163.com
QQ 376315150 892498299 Pin No. 51
Pin Name MSM-LT
I/O O
Function
MSM-NAR
I
53
MSM-CH
O
54
INPUT-CHANGE
O
Input sensitivity switching output
55
IIC-DATA
O
Data output for IC601, 901
56
IIC-CLK
O
Clock output for IC601, 901
57
XRST
O
CD reset signal output
58
XLT
O
CD latch signal output (Not used)
59
FOUCUS-SW
O
Not used
60
TBL-L
O
61
TBL-R
O
62
TRAY-LED
O
63
LOAD-OUT
O
64
LOAD-IN
O
13942296513
65
ST-CLK
O
Tuner clock output
66
ST-DIN
I
Tuner data input
67
ST-DOUT
O
Tuner data output
68
ST-CE
O
Tuner chip enable output
69
TUNED
I
Tuned detection for tuner
70
STEREO
I
Stereo detection for tuner
71
VSS
–
Ground
QQ
72
ST-MUTE
O
Tuner mute signal output
73
SENS2
I
74
SENS
I
75
DISC-SENS
I
Not used
76
T-SENS
I
CD table detection signal input
77
UP-SW
I
Up SW (S201) signal input
78
ENC 3
I
79
ENC 2
I
80
ENC 1
I
81
OUT-OPEN
I
Not used
82
CAP-M-H/N
O
Capstan motor H/N speed select signal output
83
B-TRG
O
Trigger motor control output
84
A-TRG
O
Trigger motor control output
85
TRG-LOW
O
Trigger motor control output
86
CAP-M-ON/OFF
O
Capstan motor ON/OFF signal output
87
PB-A/B
O
PB Deck A/Deck B select output
88
EQ-H/N
O
Equalizer H/N select output
89
BIAS
O
Bias ON/OFF signal output
90
REC-MUTE
O
REC mute ON/OFF selection output
91
NR-ON/OFF
O
NR ON/OFF signal output
92
R/P-PASS
O
REC/PB/PASS selection output
93
TC-MUTE
O
TC mute ON/OFF selection output
94
A-PLAY-SW
I
Deck A play detect
Not used
Not used
Not used
xiaoy u163. com
95
B-PLAY-SW
I
Deck B play detect
96
TC-RELAY
O
REC/PB head selection output for IC602
97
A-HALF
98
POWER
99
100
I
Deck A cassette detect
O
POWER ON/OFF signal output
SW-F-CHG
O
Super woofer mode signal output
STK-MUTE
O
Power amp ON/OFF signal output
.
— 95 —
http://www.xiaoyu163.com
376315150 892498299
QQ 376315150 892498299
BD Condition signal input (Not used)
QQ
www
CD tray LED ON/OFF output
13942296513
376315150 892498299
TEL 13942296513
Table motor control output TEL
TEL
52
http://www.xiaoyu163.com
QQ 376315150 892498299
• IC601 DISPLAY CONTROL (TMP87CM75-6565)/PANEL board Pin No. 1 2 3 to 10
Pin Name SEG35
I/O O
FL segment signal output
Function
VLOAD
O
Power supply (–25V) for FL segment signal output
O
LED driver output
VSS
–
Ground
12
X-OUT
O
13
X-IN
I
14
RESET
I
15
LED 9
O
16
LED10
O
17
TEST
I
LED11 to LED16
O
LED driver output
18 to 23
X’tall (8MHz) Reset signal input from main controller Connected ground
VOL-A
I
Rotary encoder (S701) pulse input
25
LED17
O
LED driver output
26
JOG-A
I
Rotaly encoder (S711) pulse input
27
CLOCK
I
Serial clock input from main controller
28
DATA
I
Serial data input from main controller
29
LED SELECT
O
LED select signal output
30
VDD
–
Power supply (+5V)
31
VSS
–
Ground
32
MODEL
I
Version select signal input
I
Key input
DOOR SW
I
DOOR SW (S691) ON/OFF signal input
39
SIRCS
I
Remote commander signal input
40
VOL-B
I
Rotary encoder (S701) pulse input
41
JOG-B
I
Rotary encoder (S711) pulse input
42
SPEANA-1
I
Spectrum analyzer input
43
SPEANA-2
I
Spectrum analyzer input
44
SPEANA-3
I
Spectrum analyzer input
45
SPEANA-4
I
Spectrum analyzer input
46
L+R
I
Spectrum analyzer (high frequency) input
47
LED18
O
LED driver output
48
VASS
–
Ground
49
VAREF
I
Analog reference voltage input
50
QQ 376315150 892498299
TEL 13942296513
VDD
–
Power supply (+5V)
51 to 56
GR1 to GR16
O
FL gride signal output
67 to 100
SEG1 to SEG34
O
FL segment signal output
• Abbreviation FL : Fluorescent indicator tube
www
.
xiaoy u163. com — 96 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
KEY1 to KEY5
38
QQ
QQ
33 to 37
13942296513
13942296513
24
TEL
TEL
LED1 to LED8
11
http://www.xiaoyu163.com
SECTION 8 EXPLODED VIEWS
QQ 376315150 892498299 NOTE: • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
• Abbreviation SP : Singapore model MY : Malaysia model IA : Indonesia model CH : Chinese model
8-1. CASE AND BACK PANEL SECTION
#2
2 TEL
TEL
#2
4
13942296513
13942296513
3 #1 #3 #1`
#2
1
#1
4
1
#1
FRONT PANEL
6
5
M901
#1
Ref. No.
Part No.
www * * * *
1 2 3 3 3
4-929-973-01 4-987-052-31 4-992-220-01 4-992-220-11 4-992-220-21
.
xiaoy u163. com Description
Remark
SCREW (CASE, 3 POINT) CASE PANEL, BACK (E,SP) PANEL, BACK (MY) PANEL, BACK (CH)
Ref. No.
Part No.
Description
* 3 4 5 6 M901
4-992-220-31 3-363-099-01 1-233-545-11 1-769-974-11 1-698-792-11
PANEL, BACK (IA) SCREW (CASE 3 TP2) ENCAPSULATED COMPONENT WIRE (FLAT TYPE)(13 CORE) FAN, DC
— 97 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
#1
http://www.xiaoyu163.com
QQ 376315150 892498299
8-2. FRONT PANEL SECTION 1
58
57
57
57
59
TCM-220WR2
55
61 57
57
62
60
not supplied
#1 not supplied
77 56
TEL
TEL
62
73
63
76 62
54 66
not supplied
64
57
not supplied
57 57
70
75
51
52
QQ 376315150 892498299 68
Supplied with S711
71
74
69
72 57 57
Ref. No.
Part No.
Description
51 52 * 53 54 * 55
4-987-995-01 4-987-001-01 1-664-019-11 X-4948-663-1 1-664-012-11
SPRINAG (CD EJECT), COMPRESSION BUTTON (EJECT CD) CD-A SW BOARD PANEL (A) SUB ASSY TC-A SW BOARD
56 57 58 59 60
4-986-999-01 4-951-620-01 1-773-163-11 1-769-949-11 3-354-963-01
BUTTON (EJECT A) SCREW (2.6X8), +BVTP WIRE (FLAT TYPE)(21 CORE) WIRE (FLAT TYPE)(11 CORE) DAMPER
1-664-017-11 4-957-577-01 1-664-016-11 4-987-038-21
CD-LED BOARD SCREW PTP WH (2.6X8)(DIA. 10) DOOR SW BOARD LID, DISC
* 61 62 * 63 64
www
.
Remark
Ref. No.
Part No.
* 65
4-987-933-01 BRACKET (TA)
Description
66 * 67 * 68 69 70
4-987-000-01 1-664-013-11 1-664-020-11 X-4947-969-1 4-987-037-01
BUTTON (EJECT B) TC-B SW BOARD CD-B1 SW BOARD BUTTON (CD STOP) ASSY KNOB (JOG)
71 * 72 73 74 75
X-4948-296-1 1-664-021-11 3-568-749-00 4-987-002-01 4-987-014-01
PANEL (B) SUB ASSY CD-B2 SW BOARD CUSHION, ECM BUTTON (CD PLAY) INDICATOR (CD)
xiaoy u163. com 76 77 78
4-987-997-01 SPRING (CD, LID), TORSION 4-987-998-01 SPRING (LOCK SHAFT), TORSION X-4948-664-1 BUTTON (LOOP) ASSY
— 98 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
TEL 13942296513
not supplied
not supplied
QQ
QQ
73
78
53
67
13942296513
13942296513
57 65
http://www.xiaoyu163.com
QQ 376315150 892498299 8-3. FRONT PANEL SECTION 2
110 Supplied with RV760, RV761
110
119
111
not supplied
130 112
FL601
114
109 117
132
TEL
TEL
Supplied with J760
129
108 106
131
105
118
13942296513
13942296513
113
107
120
110 116 115 123
122
121
104 124
TEL 13942296513
110
not supplied
128
102
not supplied
103
101
Ref. No.
127
Part No.
Description
101 102 103 104 105
X-4948-662-1 4-987-036-01 X-4947-961-1 4-987-032-01 4-987-028-01
PANEL ASSY KNOB (VOL) LID ASSY, CASSETTE DISPLAY (TA) DISPLAY (ST)
106 107 108 109 110
4-987-021-01 4-986-997-01 4-963-404-21 4-973-644-01 4-951-620-01
INDICATOR (TC A) BUTTON (DECK.A) EMBLEM (5-A), SONY KNOB (MIC) SCREW (2.6X8), +BVTP
* 111 112 113 114 115
A-4392-486-A 4-986-986-01 4-987-012-01 X-4947-990-1 4-986-990-01
HP/MIC BOARD, COMPLETE BUTTON (POWER) INDICATOR (TA) BUTTON (SOUND) ASSY BUTTON (CURSOR)
116 * 117
4-978-683-01 SPRING, COMPRESSION 4-987-041-01 COVER, CURSOR
www
126
.
Remark
Ref. No.
Part No.
Description
118 * 119 120
X-4947-963-1 BUTTON (FUNCTION) ASSY A-4398-986-A PANEL BOARD, COMPLETE 1-773-051-11 WIRE (FLAT TYPE)(17 CORE)
121 122 123 124 125
X-4947-962-1 4-987-013-01 X-4947-968-1 X-4947-967-1 4-987-022-01
BUTTON (TUNER) ASSY INDICATOR (TUNER) BUTTON (WOOFER) ASSY BUTTON (DECK B) ASSY INDICATOR (TC B)
126 127 128 129 * 130
4-987-996-01 4-948-236-01 4-987-930-01 4-988-219-01 4-986-870-11
SPRING (TC LID), TENSION CUSHION (107) PLATE (VOL), ORNAMENTAL BUTTON (DOLBY) HOLDER, FL TUBE
131 * 132 FL601
4-987-017-01 INDICATOR (KEY.CON) 4-949-935-81 CUSHION (FL) 1-517-617-11 INDICATOR TUBE, FLUORESCENT
xiaoy u163. com — 99 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
QQ 376315150 892498299 126
QQ
QQ
125
Supplied with S701
http://www.xiaoyu163.com
QQ 376315150 892498299
8-4. CHASSIS SECTION
#1
162
not supplied
#1
#2
151 T501
#1
(CH)
167
CNP901
#1
161 (IA)
153 #2
166
(IA, CH)
#4
161 (E, SP, MY) CNP901
#1
(E, SP, MY)
158
154
160
not supplied
13942296513
13942296513
#4
TEL
TEL
not supplied
155 #1 #1 #1
165
#1
156
#1
QQ 376315150 892498299 156
152
A
#1
#1
164 not supplied
157
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
163 165
#1 not supplied
Ref. No.
Part No.
Description
* 151 * 152 153 153 * 154
1-663-994-11 A-4398-049-A 3-703-244-00 4-966-266-01 A-4392-679-A
TRANS BOARD KEY CON BOARD, COMPLETE BUSHING (FBS001), CORD (E,SP,MY,CH) BUSHING (S)(FBS002), CORD (IA) POWER BOARD, COMPLETE (E,SP,MY,IA)
* 154 * 155 156 157 * 158
A-4403-679-A A-4398-990-A 1-782-563-11 X-4941-228-1 A-4392-662-A
POWER BOARD, COMPLETE (CH) MAIN BOARD, COMPLETE WIRE (FLAT TYPE)(29 CORE) FOOT (F22125H-M) SURROUND BOARD, COMPLETE (E,SP,MY,IA)
* 158 * 159 * 160
A-4392-663-A SURROUND BOARD, COMPLETE (CH) 1-782-562-11 WIRE (FLAT TYPE)(13 CORE) 4-988-533-11 HOLDER, PCB
www
.
Remark
Ref. No.
Part No.
! 161 ! 161
1-569-007-11 ADAPTOR, CONVERSION 2P (IA) 1-569-008-11 ADAPTOR, CONVERSION 2P (E,SP,MY)
Description
* 162 * 163 * 164 165 166
1-666-126-11 1-665-406-11 A-4398-587-A 4-944-316-01 1-500-386-11
VIDEO POWER BOARD VIDEO OUT BOARD VIDEO BOARD, COMPLETE HOLDER, PC BOARD FERRITE CORE (CH)
xiaoy u163. com * 167 ! CNP901 ! CNP901 ! CNP901 ! T501
3-703-150-11 1-558-943-41 1-575-651-21 1-782-510-11 1-431-418-11
— 100 —
http://www.xiaoyu163.com
WIRE CLAMP (CH) CORD, POWER (IA) CORD, POWER (E,SP,MY) CORD, POWER (CH) TRANSFORMER, POWER
Remark
376315150 892498299
376315150 892498299
TEL 13942296513
CDM37L-5BD21AL
159
QQ
QQ
#1
http://www.xiaoyu163.com
QQ 376315150 892498299 8-5. TC MECHANISM SECTION-1 (TCM-220WR2)
207
TEL
TEL
201 208
13942296513
13942296513
205 209 #5 #5
203
206
205
207 202 not supplied
204
#2
Ref. No.
Part No.
www 201 202 203 204 205
X-4947-943-1 X-4947-944-1 4-959-231-11 4-959-232-11 3-354-963-01
.
xiaoy u163. com Description
Remark
HOLDER (L) ASSY, CASSETTE HOLDER (R) ASSY, CASSETTE SPRING (L), TORSION SPRING (R), TORSION DAMPER
Ref. No.
Part No.
Description
* 206 207 208 209
4-980-439-01 3-354-957-01 3-354-953-01 3-354-954-01
FULCLUM, HOLDER JOINT (LOCK LEVER) LEVER (LOCK LEVER L) LEVER (LOCK LEVER R)
— 101 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
#5
http://www.xiaoyu163.com
QQ 376315150 892498299
8-6. TC MECHANISM SECTION-2 (TCM-220WR2)
271
#6
(including pA)
269 275
rA
#6
265
272
264
not supplied HP101 (including rA)
262 274 263 261
253 258
256
269
259
255
265
274
264
262
266
273
not supplied HRPE101 (including rB)
268
256 255
rB
274 257
QQ 376315150 892498299 263 261
259
not supplied
252
251
#9
260
not supplied
252
Ref. No.
254
251 #9
Description
251 252 253 254 255
3-908-560-01 3-919-684-01 X-3373-113-1 3-009-956-01 3-908-558-02
SPRING, AZIMUTH ADJUSTMENT SCREW, AZIMUTH ADJUSTMENT SLIDER (HEAD) ASSY SPRING, HEAD TOGGLE FITTING BLOCK, HEAD
256 * 257 258 259 260
3-908-557-02 3-908-559-01 3-908-555-01 3-917-143-11 3-388-848-01
ROTARY BLOCK, HEAD STOPPER, AZIMUTH SLIDER (REV SLIDER) SPRING, TENSION SCREW (P2X6)(B TIGHT)
261 262 263 264
3-939-371-01 X-3369-909-1 X-3369-908-1 3-908-613-01
SPRING (1), TENSION PINCH LEVER (REV) ASSY PINCH LEVER (FWD) ASSY GEAR (S), REEL
.
253
not supplied
Part No.
www
258
Remark
Ref. No. 265 266 267 268 269 * 271 272 273 274 275 HP101
Part No.
Description
3-917-141-01 SPRING, COMPRESSION X-3371-305-1 3-669-465-01 X-3370-173-1 3-939-862-01 A-2007-131-A
REEL (T) ASSY WASHER (1.5), STOPPER TU ASSY CLIP AUDIO BOARD, COMPLETE
3-930-972-01 3-917-142-01 3-355-808-02 3-938-863-01 1-500-093-11
DETENT, HALF SPRING, COMPRESSION PINCH ROLLER STOPPER HEAD, MAGNETIC (PLAYBACK)
xiaoy u163. com
HRPE101 1-500-094-11 HEAD, MAGNETIC (REC/PB/ERASE)
— 102 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
TEL 13942296513
not supplied
274 269
not supplied
QQ
QQ
254
rA
267 260
13942296513
13942296513
257
266
TEL
TEL
rB
273
http://www.xiaoyu163.com
QQ 376315150 892498299 8-7. TC MECHANISM SECTION-3 (TCM-220WR2) pA: MOTOR board (Suppplied with AUDIO board)
M2
324 pA
319
318
321 #11
320
317
321
310
TEL
TEL
#10
302
#10
309
310
316
325
#9
313 315 308 323 305
312
307
322
319
304
314 314
#8
303 #7
301 302
#7 M1
Ref. No.
not supplied
Part No.
Description
301 302 303 304 305
3-908-597-01 3-908-608-11 X-3372-930-3 X-3370-169-1 3-928-047-01
CAM (A) SCREW, STEP ARM (A) ASSY, FR FLYWHEEL (AR) ASSY PULLEY, TENSION
306 307 308 309 310
3-908-599-01 3-908-601-01 3-908-603-01 X-3367-593-1 3-908-605-01
LEVER (REV-A) SPRING (REV LEVER), TORSION LEVER (TRIGGER A) FLYWHEEL (BF) ASSY SPRING (TRIGGER), TORSION
311 312 313 314
3-908-609-01 3-913-845-11 3-913-846-11 X-3370-171-1
www
.
Remark
Ref. No. 315
Part No.
Description
3-908-600-01 LEVER (REV-B)
* 316 317 318 319 320
1-650-669-11 3-908-598-01 X-3372-931-3 3-911-114-12 3-908-604-01
LEAF SWITCH BOARD CAM (B) ARM (B) ASSY, FR SPRING (FR), TORSION LEVER (TRIGGER B)
321 322 323 * 324 325
3-911-115-01 3-917-176-11 X-3370-172-1 A-2007-131-A X-3371-441-1
WASHER, STOPPER BELT (B) FLYWHEEL (AF) ASSY AUDIO BOARD, COMPLETE CHASSIS ASSY, MECHANICAL
xiaoy u163. com GEAR, TRIGGER BELT (A) BELT (FR) FLYWHEEL (BR) ASSY
M1 M2
X-3371-223-1 MOTOR ASSY (CAPSTAN) A-2004-410-A MOTOR ASSY (TRIGGER)
— 103 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
306 307
13942296513
13942296513
311
http://www.xiaoyu163.com
QQ 376315150 892498299
8-8. CD MECHANISM SECTION (CDM37L-5BD21AL)
352
351
351
358
351
355 353 354
356 357 #1
360
TEL
TEL
361 360
373 372
362
375
374
368 367
368
369
369 not supplied
359 #1
363
365 361 370 #1
#1
Ref. No.
#1
Description
351 352 353 354 355
4-987-976-01 4-944-490-01 A-4660-978-A 4-978-421-01 4-978-425-01
SCREW, STEP BELT (TIMING) GEAR (PULLEY) ASSY GEAR (MID) ROLLER (CAM)
356 * 357 358 359 360
4-978-420-01 1-452-925-11 4-978-417-01 4-993-142-01 X-4947-960-1
CAM (HOLDER) MAGNET ASSY TABLE, DISC PULLEY (L), PRESS ROLLER ASSY
361 362 363 364
4-978-583-01 4-978-418-01 4-980-385-01 A-4673-765-A
BRACKET (BU) CHASSIS HOLDER (SW) CD MOTOR BOARD, COMPLETE
www
.
371
364
Part No.
* * * *
366
Remark
Ref. No. 365
Part No.
Description
4-978-426-01 INDICATOR (NO.)
* 366 * 367 368 369 * 370
1-659-059-13 1-659-058-13 4-933-134-01 4-958-593-01 4-978-419-01
LED BOARD TABLE SENSOR BOARD SCREW (+PTPWH M2.6X6) SPRING (BU), COMPRESSION HOLDER (BU-5)
371 372 373 374
4-917-583-71 4-989-493-01 4-989-494-01 4-989-819-01
BRACKET, YOKE SLIDER (37) SCREW (SLIDER), STEP SPRING, TENSION
375 M201
4-989-491-21 COVER, LENS A-4660-977-A MOTOR ASSY (TABLE)
xiaoy u163. com — 104 —
http://www.xiaoyu163.com
Remark
376315150 892498299
TEL 13942296513
376315150 892498299
QQ 376315150 892498299 368
M201
QQ
QQ
352
13942296513
13942296513
360
http://www.xiaoyu163.com
QQ 376315150 892498299 8-9. BASE UNIT SECTION (BU-5BD21AL)
401
402
TEL
TEL
#12
405
404
M102
404
406
407
408
Ref. No.
Part No.
! 401 402 403 404 405
8-820-020-03 1-769-069-11 4-917-567-01 4-951-940-01 4-917-565-01
www
.
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
xiaoy u163. com Description
Remark
OPTICAL PICK-UP KSS-213D/Q-NP WIRE (FLAT TYPE)(16 CORE) GEAR (M) INSULATOR (BU) SHAFT, SLED
Ref. No.
Part No.
Description
406 * 407 408 M101 M102
4-917-564-01 A-4673-557-A 4-951-620-01 X-4917-523-4 X-4917-504-1
GEAR (P), FLATNESS BD BOARD, COMPLETE SCREW (2.6X8), +BVTP MOTOR ASSY (SPINDLE) MOTOR ASSY (SLED)
— 105 —
http://www.xiaoyu163.com
Remark
376315150 892498299
376315150 892498299
M101
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
13942296513
13942296513
403
http://www.xiaoyu163.com
SECTION 9 ELECTRICAL PARTS LIST
QQ 376315150 892498299 AUDIO
Note:
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
When indicating parts by reference number, please include the board name.
• Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • RESISTORS All resistors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable
Part No.
A-2007-131-A AUDIO BOARD, COMPLETE ********************* (including MOTOR board)
Description
Remark
Part No.
Description
Remark
< CONNECTOR > CN601 CN602 * CN651
1-695-382-31 PIN, CONNECTOR (PC BOARD) 21P 1-564-718-11 PIN, CONNECTOR (SMALL TYPE) 2P 1-564-521-11 PLUG, CONNECTOR 6P
13942296513
13942296513
< CAPACITOR >
Ref. No.
TEL
TEL
Ref. No. *
• SEMICONDUCTORS In each case, u: µ , for example: uA...: µ A..., uPA...: µ PA..., uPB...: µ PB..., uPC...: µ PC..., uPD...: µ PD... • CAPACITORS uF : µ F • COILS uH : µ H • Abbreviation SP : Singapore model MY : Malaysia model IA : Indonesia model CH : Chinese model
< IC >
CERAMIC ELECT CERAMIC MYLAR ELECT
390PF 100uF 100PF 0.01uF 22uF
10% 20% 10% 5% 20%
50V 6.3V 50V 50V 16V
C311 C313 C314 C315 C331
1-162-289-31 1-162-282-31 1-130-487-00 1-126-233-11 1-137-427-11
CERAMIC CERAMIC MYLAR ELECT FILM
390PF 100PF 0.022uF 22uF 120PF
10% 10% 5% 20% 5%
50V 50V 50V 50V 50V
C332 C333 C401 C402 C403
1-162-288-31 1-162-209-31 1-162-289-31 1-126-968-11 1-162-282-31
CERAMIC CERAMIC CERAMIC ELECT CERAMIC
330PF 27PF 390PF 100uF 100PF
10% 5% 10% 20% 10%
50V 50V 50V 6.3V 50V
C404 C405 C411 C413 C414
1-130-483-00 1-107-715-11 1-162-289-31 1-162-282-31 1-130-487-00
MYLAR ELECT CERAMIC CERAMIC MYLAR
0.01uF 22uF 390PF 100PF 0.022uF
5% 20% 10% 10% 5%
50V 16V 50V 50V 50V
C415 C431 C432 C433 C601
1-126-233-11 1-137-427-11 1-162-288-31 1-162-209-31 1-104-396-11
ELECT FILM CERAMIC CERAMIC ELECT
22uF 120PF 330PF 27PF 10uF
20% 5% 10% 5% 20%
50V 50V 50V 50V 16V
R301 R302 R303 R304 R305
1-247-881-00 1-249-409-11 1-249-433-11 1-247-889-00 1-247-858-11
CARBON CARBON CARBON CARBON CARBON
120K 220 22K 270K 13K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W
C602 C611 C612 C621 C622
1-104-396-11 1-124-907-11 1-124-907-11 1-137-150-11 1-126-961-11
ELECT ELECT ELECT FILM ELECT
10uF 10uF 10uF 0.01uF 2.2uF
20% 20% 20% 5% 20%
16V 50V 50V 100V 50V
R311 R312 R314 R315 R331
1-247-881-00 1-247-807-31 1-247-882-11 1-247-850-11 1-249-430-11
CARBON CARBON CARBON CARBON CARBON
120K 100 130K 6.2K 12K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
C623 C624 C625 C627 C628
1-136-155-00 1-130-481-00 1-130-481-00 1-124-903-11 1-136-153-00
FILM MYLAR MYLAR ELECT FILM
0.015uF 0.0068uF 0.0068uF 1uF 0.01uF
5% 5% 5% 20% 5%
50V 50V 50V 50V 50V
R401 R402 R403 R404 R405
1-247-881-00 1-249-409-11 1-249-433-11 1-247-889-00 1-247-858-11
CARBON CARBON CARBON CARBON CARBON
120K 220 22K 270K 13K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W
47uF 0.022uF
20%
16V 25V
R411 R412 R414 R415 R431
1-247-881-00 1-247-807-31 1-247-882-11 1-247-850-11 1-249-430-11
CARBON CARBON CARBON CARBON CARBON
120K 100 130K 6.2K 12K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
TEL 13942296513
www
C642 C651
1-104-664-11 ELECT 1-161-494-00 CERAMIC
.
IC601 IC602 IC611
8-759-111-44 IC uPC4570C-1 8-759-143-54 IC uPC1330HA 8-759-111-44 IC uPC4570C-1 < COIL >
L331 L431
1-410-780-11 INDUCTOR 27mH 1-410-780-11 INDUCTOR 27mH
QQ 376315150 892498299 < MOTOR >
M2
A-2004-410-A MOTOR ASSY (TRIGGER) < TRANSISTOR >
Q621 Q622 Q623 Q651
8-729-142-46 8-729-142-46 8-729-801-93 8-729-900-65
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2001-LK 2SC2001-LK 2SD1387 DTA144ES
< RESISTOR >
xiaoy u163. com — 106 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1-162-289-31 1-126-968-11 1-162-282-31 1-130-483-00 1-107-715-11
QQ
QQ
C301 C302 C303 C304 C305
http://www.xiaoyu163.com
QQ 376315150 892498299 AUDIO
Ref. No.
Part No.
Description
Remark
R601 R602 R608 R609 R611
1-249-409-11 1-249-409-11 1-249-409-11 1-249-433-11 1-249-409-11
CARBON CARBON CARBON CARBON CARBON
220 220 220 22K 220
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R612 ! R621 ! R622 R623 R624
1-249-409-11 1-212-851-00 1-212-851-00 1-249-432-11 1-249-432-11
CARBON FUSIBLE FUSIBLE CARBON CARBON
220 5.6 5.6 18K 18K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W F 1/4W 1/4W
CN101 CN102
R625 R651 R652 R653
1-249-429-11 1-247-856-00 1-247-856-00 1-249-441-11
CARBON CARBON CARBON CARBON
10K 11K 11K 100K
5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W
IC101 IC102 IC103
F F F
Ref. No. C156 C157 C159 C161
Part No.
Description
1-163-237-11 1-163-145-00 1-163-019-00 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
BD
Remark
27PF 5% 0.0015uF 5% 0.0068uF 10% 0.1uF
50V 50V 50V 25V
F < CONNECTOR > 1-774-115-11 CONNECTOR, (FFC/FPC) 29P 1-770-014-11 CONNECTOR, FFC/FPC 16P < IC > 8-752-369-78 IC CXD2545Q 8-759-176-09 IC BA6392FP 8-752-072-45 IC CXA1821M-T6
TEL
TEL
< MOTOR > < VARIABLE RESISTOR > 1-238-598-11 1-238-598-11 1-238-551-11 1-238-598-11 1-238-598-11
RV441 RV651 RV652
1-238-551-11 RES, ADJ, CARBON 220K 1-238-599-11 RES, ADJ, CARBON 4.7K 1-238-599-11 RES, ADJ, CARBON 4.7K
M101 M102
RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 220K RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K
< TRANSISTOR > Q101
METAL CHIP METAL GLAZE METAL CHIP METAL CHIP METAL GLAZE
15K 100K 15K 33K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R106 R107 R108 R109 R110
1-216-061-00 1-216-061-00 1-216-073-00 1-216-121-91 1-216-025-91
METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL GLAZE
3.3K 3.3K 10K 1M 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R112 R123 R124 R125 R126
1-216-049-91 1-216-073-00 1-216-097-91 1-216-033-00 1-216-033-00
METAL GLAZE METAL CHIP METAL GLAZE METAL CHIP METAL CHIP
1K 10K 100K 220 220
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R127 R131 R132 R134 R135
1-216-033-00 1-216-037-00 1-216-073-00 1-216-049-91 1-216-295-91
METAL CHIP 220 METAL CHIP 330 METAL CHIP 10K METAL GLAZE 1K CONDUCTOR, CHIP (2012)
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R136 R137 R138 R141 R142
1-216-295-91 1-216-295-91 1-216-295-91 1-216-089-91 1-216-081-00
CONDUCTOR, CHIP (2012) CONDUCTOR, CHIP (2012) CONDUCTOR, CHIP (2012) METAL GLAZE 47K METAL CHIP 22K
5% 5%
1/10W 1/10W
R143 R144 R146 R147 R148
1-216-103-00 1-216-103-00 1-216-073-00 1-216-067-00 1-216-001-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
5% 5% 5%
1/10W 1/10W 1/10W
5%
1/10W
< CAPACITOR > C101 C102 C103 C105 C106
1-163-005-11 1-163-038-91 1-163-005-11 1-104-913-11 1-164-346-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP
470PF 0.1uF 470PF 10uF 1uF
C107 C108 C109 C110 C111
1-164-346-11 1-163-035-00 1-163-145-00 1-163-017-00 1-163-251-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 0.047uF 0.0015uF 5% 0.0047uF 5% 100PF 5%
16V 50V 50V 50V 50V
C112 C113 C115 C116 C117
1-163-038-91 1-163-038-91 1-126-607-11 1-126-607-11 1-126-209-11
CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP ELECT
0.1uF 0.1uF 47uF 47uF 100uF
25V 25V 4V 4V 4V
C118 C119 C123 C124 C125
1-163-275-11 1-163-235-11 1-164-232-11 1-164-005-11 1-104-913-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP
0.001uF 22PF 0.01uF 0.47uF 10uF
C140 C141 C151 C153 C154
1-163-038-91 1-163-038-91 1-163-237-11 1-163-038-91 1-164-336-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 27PF 0.1uF 0.33uF
www
.
10% 10% 20%
20% 20% 20% 5% 5%
20%
50V 25V 50V 16V 16V
50V 50V 50V 25V 16V
xiaoy u163. com 5%
25V 25V 50V 25V 25V
R149 R158 R159 R160 R161
1-216-003-11 1-216-109-00 1-216-101-00 1-216-295-91 1-216-308-00
— 107 —
http://www.xiaoyu163.com
180K 180K 10K 5.6K 10
METAL GLAZE 12 METAL CHIP 330K METAL CHIP 150K CONDUCTOR, CHIP (2012) METAL CHIP 4.7
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
376315150 892498299
376315150 892498299
1-216-077-00 1-216-097-91 1-216-077-00 1-216-085-00 1-216-097-91
QQ 376315150 892498299
************************************************************** A-4673-557-A BD BOARD, COMPLETE *******************
R101 R102 R103 R104 R105
QQ
QQ
1-423-980-11 TRANSFORMER, BIAS OSCILLATION
TEL 13942296513 *
8-729-010-08 TRANSISTOR MSB710-R < RESISTOR >
< TRANSFORMER > T621
X-4917-523-4 MOTOR ASSY (SPINDLE) X-4917-504-1 MOTOR ASSY (SLED)
13942296513
13942296513
RV301 RV311 RV341 RV401 RV411
http://www.xiaoyu163.com
QQ 376315150 892498299 BD
Ref. No. R162
CD-A SW
Part No.
CD-B2 SW
CD-B1 SW
Description
1-216-101-00 METAL CHIP
Remark
150K
5%
Ref. No.
1-572-085-11 SWITCH, LEAF (LIMIT)
1-664-019-11 CD-A SW BOARD *************
DIODE DIODE DIODE DIODE
1-247-815-91 1-249-411-11 1-249-413-11 1-249-415-11 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
220 330 470 680 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W
R750 R751
1-247-807-31 CARBON 1-247-807-31 CARBON
100 100
5% 5%
1/4W 1/4W
< SWITCH > S676 S677 S678 S679
SEL5223S-TP15 (CD NON-STOP) SEL5223S-TP15 (VCD) SEL5223S-TP15 (PBC) SEL5223S-TP15 (AUTO PBC)
< RESISTOR > 330 470 680 1K 1.5K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R736 R737 R738 R739 R740
1-249-421-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11
CARBON CARBON CARBON CARBON CARBON
2.2K 1K 1.5K 2.2K 3.3K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W F 1/4W 1/4W
< RESISTOR > R752 R753 R754 R755 R756
1/4W 1/4W 1/4W 1/4W
S661 S662 S663 S664 S665
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (DISC 1) SWITCH, TACTILE (DISC 2) SWITCH, TACTILE (DISC 3) SWITCH, TACTILE (DISC 4) SWITCH, TACTILE (DISC 5)
S666 S667 S668 S669 S670
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (CD FLASH) SWITCH, TACTILE (CD NON-STOP) SWITCH, TACTILE (CD LOOP) SWITCH, TACTILE (ˆ RETURN) SWITCH, TACTILE (PREV)
S671
1-554-303-21 SWITCH, TACTILE (NEXT)
S681 S682 S683 S684 S685
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
S686 S711
1-554-303-21 SWITCH, TACTILE (0) 1-467-968-11 ENCODER, ROTARY (≠ AMS ±)
CN671
F
SWITCH, TACTILE ()) SWITCH, TACTILE (REPEAT) SWITCH, TACTILE (PLAY MODE) SWITCH, TACTILE (1/ALL DISCS) SWITCH, TACTILE (EDIT)
1-506-481-11 PIN, CONNECTOR 2P < DIODE >
D671 D672 D673 D674
8-719-058-03 8-719-058-03 8-719-058-03 8-719-058-03
DIODE DIODE DIODE DIODE
SEL5423E-TP15 (DISC TABLE) SEL5423E-TP15 (DISC TABLE) SEL5423E-TP15 (DISC TABLE) SEL5423E-TP15 (DISC TABLE)
< RESISTOR > R791
1-568-943-11 PIN, CONNECTOR 5P
1-249-412-11 CARBON
390
5%
1/4W F
**************************************************************
xiaoy u163. com
8-719-057-29 DIODE SML78423C-TP15 (· SELECT) 8-719-057-97 DIODE SEL5923A-TP15 (P) 8-719-057-29 DIODE SML78423C-TP15 (· SELECT)
.
F F F
1-664-017-11 CD-LED BOARD ************
< CONNECTOR >
www
1/4W 1/4W 1/4W 1/4W 1/4W
< CONNECTOR >
1-664-020-11 CD-B1 SW BOARD **************
D645 D646 D647
5% 5% 5% 5% 5%
**************************************************************
**************************************************************
< DIODE >
1K 1.5K 2.2K 3.3K 6.8K
QQ 376315150 892498299
*
* CN642
CARBON CARBON CARBON CARBON CARBON
*
A-4673-765-A CD MOTOR BOARD, COMPLETE *************************
*
4-980-385-01 HOLDER (SW)
— 108 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
5% 5% 5% 5%
< SWITCH >
*
1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-427-11
< SWITCH >
TEL 13942296513 100 100 100 100
1-664-021-11 CD-B2 SW BOARD **************
* F F F F
QQ
QQ
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON
SWITCH, TACTILE (· SELECT) SWITCH, TACTILE (p) SWITCH, TACTILE (P) SWITCH, TACTILE (DISC SKIP)
13942296513
13942296513
1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
**************************************************************
R731 R732 R733 R734 R735
R741 R742 R743 R744
Remark
TEL
TEL
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
Description
R745 R746 R747 R748 R749
< DIODE > D641 D642 D643 D644
CD MOTOR
< RESISTOR >
************************************************************** *
Part No.
1/10W
< SWITCH >
S101
CD-LED
http://www.xiaoyu163.com
QQ 376315150 892498299 CD MOTOR
Ref. No.
Part No.
Description
Remark
< CAPACITOR >
C201 C202 C203
1-124-907-11 ELECT 1-164-159-21 CERAMIC 1-124-907-11 ELECT
10uF 0.1uF 10uF
20% 20%
50V 50V 50V
< CONNECTOR > * CN201
1-568-947-11 PIN, CONNECTOR 9P < IC >
IC201
8-759-365-94 IC TA8409S < COIL > 1-408-117-00 INDUCTOR 10uH < MOTOR > A-4660-977-A MOTOR ASSY (TABLE) < RESISTOR >
R205 R206
1-249-427-11 CARBON 1-249-425-11 CARBON
6.8K 4.7K
5% 5%
1/4W F 1/4W F
Description
Remark
C773 C774 C775
1-126-964-11 ELECT 1-126-964-11 ELECT 1-162-294-31 CERAMIC
10uF 10uF 0.001uF
20% 20% 10%
50V 50V 50V
C776 C777 C778 C779 C780
1-162-294-31 1-126-960-11 1-162-305-11 1-162-294-31 1-136-495-11
CERAMIC ELECT CERAMIC CERAMIC FILM
0.001uF 1uF 0.0068uF 0.001uF 0.068uF
10% 20% 30% 10% 5%
50V 50V 16V 50V 50V
C781 C782 C783 C784 C785
1-126-957-11 1-126-957-11 1-126-967-11 1-136-495-11 1-162-305-11
ELECT ELECT ELECT FILM CERAMIC
0.22uF 0.22uF 47uF 0.068uF 0.0068uF
20% 20% 20% 5% 30%
50V 50V 10V 50V 16V
C786 C787 C788 C789 C790
1-162-294-31 1-124-250-11 1-126-960-11 1-161-494-00 1-126-967-11
CERAMIC ELECT ELECT CERAMIC ELECT
0.001uF 0.15uF 1uF 0.022uF 47uF
10% 20% 20%
50V 50V 50V 25V 10V
C791 C794 C795 C798 C799
1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
20%
50V 50V 50V 50V 50V
< SWITCH > < CONNECTOR > S201
1-762-587-11 SWITCH, PUSH (1 KEY)(UP) 1-568-935-11 PIN, CONNECTOR 8P
D761 D762 D763
< CAPACITOR > C691
1-164-159-21 CERAMIC
0.1uF
< IC >
50V IC760 IC761
< CONNECTOR > CN661
8-719-200-82 DIODE 11ES2 8-719-200-82 DIODE 11ES2 8-719-200-82 DIODE 11ES2
8-759-634-51 IC M5218AP 8-759-450-96 IC M65850P
1-506-481-11 PIN, CONNECTOR 2P < JACK > < SWITCH >
S691
J760 J761 J762
1-771-057-11 SWITCH, PUSH (1 KEY)(6 OPEN)
1-770-226-41 JACK (LARGE TYPE)(PHONES) 1-770-226-41 JACK (LARGE TYPE)(MIC 1) 1-770-226-41 JACK (LARGE TYPE)(MIC 2)
************************************************************** < COIL > A-4392-486-A HP/MIC BOARD, COMPLETE **********************
*
L761
1-410-521-11 INDUCTOR 100uH < BASE POST >
< CAPACITOR > C760 C761 C762 C763 C764
1-162-306-11 1-126-961-11 1-162-306-11 1-126-961-11 1-162-294-31
CERAMIC ELECT CERAMIC ELECT CERAMIC
0.01uF 2.2uF 0.01uF 2.2uF 0.001uF
20% 20% 20% 20% 10%
16V 50V 16V 50V 50V
C765 C766 C767 C768 C769
1-162-215-31 1-162-290-31 1-162-215-31 1-126-961-11 1-162-282-31
CERAMIC CERAMIC CERAMIC ELECT CERAMIC
47PF 470PF 47PF 2.2uF 100PF
5% 10% 5% 20% 10%
50V 50V 50V 50V 50V
C770 C771
1-126-961-11 ELECT 1-126-959-11 ELECT
2.2uF 0.47uF
20% 20%
50V 50V
www
.
* LP2
1-690-880-21 LEAD (WITH CONNECTOR) < RESISTOR >
R760 R761 R762 R763 R764
1-249-429-11 1-249-417-11 1-249-429-11 1-249-417-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
10K 1K 10K 1K 100K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W F 1/4W
R765 R766 R767 R768
1-249-417-11 1-249-437-11 1-249-429-11 1-249-431-11
CARBON CARBON CARBON CARBON
1K 47K 10K 15K
5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W
xiaoy u163. com — 109 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
< DIODE >
1-664-016-11 DOOR SW BOARD *************
*
QQ
QQ
* CN701 **************************************************************
13942296513
13942296513
M201
Part No.
HP/MIC
TEL
TEL
L201
Ref. No.
DOOR SW
http://www.xiaoyu163.com
QQ 376315150 892498299 HP/MIC
Ref. No.
KEY CON
Part No.
LEAF SWITCH
Description
Remark
R769
1-247-885-00 CARBON
180K
5%
1/4W
R770 R771 R772 R773 R774
1-247-807-31 1-247-863-91 1-247-863-91 1-247-863-91 1-247-881-00
CARBON CARBON CARBON CARBON CARBON
100 22K 22K 22K 120K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R775 R776 R777 R778 R779
1-247-863-91 1-247-863-91 1-247-863-91 1-249-437-11 1-249-431-11
CARBON CARBON CARBON CARBON CARBON
22K 22K 22K 47K 15K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R782
1-249-429-11 CARBON
10K
5%
1/4W
Ref. No.
Q1401 Q1403
< CAPACITOR >
20% 20% 20% 20%
50V 50V 50V 50V 50V
C1431 C1432 C1433 C1434 C1436
1-130-493-00 1-130-493-00 1-130-493-00 1-162-284-31 1-126-967-11
MYLAR MYLAR MYLAR CERAMIC ELECT
0.068uF 0.068uF 0.068uF 150PF 47uF
5% 5% 5% 10% 20%
50V 50V 50V 50V 10V
C1437 C1438 C1439 C1445 C1446
1-164-159-21 1-126-933-11 1-126-964-11 1-136-165-00 1-136-165-00
CERAMIC ELECT ELECT FILM FILM
0.1uF 100uF 10uF 0.1uF 0.1uF
20% 20% 5% 5%
50V 10V 50V 50V 50V
C1448 C1451 C1454 C1461 C1462
1-126-964-11 1-162-286-21 1-162-286-21 1-162-294-31 1-162-306-11
ELECT CERAMIC CERAMIC CERAMIC CERAMIC
10uF 220PF 220PF 0.001uF 0.01uF
20% 10% 10% 10% 20%
50V 50V 50V 50V 16V
C1466 C1467 C1468 C1472
1-162-600-11 1-162-291-31 1-162-290-31 1-162-600-11
CERAMIC CERAMIC CERAMIC CERAMIC
0.0047uF 560PF 470PF 0.0047uF
20% 10% 10% 20%
16V 50V 50V 16V
TEL 13942296513
CARBON CARBON CARBON CARBON CARBON
22K 22K 10K 4.7K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W F
R1421 R1422 R1431 R1435 R1436
1-249-417-11 1-249-429-11 1-247-903-00 1-247-807-31 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
1K 10K 1M 100 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R1437 R1438 R1448 R1450 R1451
1-249-425-11 1-247-807-31 1-249-429-11 1-249-441-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
4.7K 100 10K 100K 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R1452 R1453 R1457 R1458 R1459
1-249-425-11 1-249-429-11 1-249-424-11 1-249-431-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
4.7K 10K 3.9K 15K 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W
R1460
1-247-863-91 CARBON
22K
5%
1/4W
QQ 376315150 892498299 ************************************************************** 1-650-669-11 LEAF SWITCH BOARD *****************
*
< CONNECTOR > * CN1001 1-568-854-11 SOCKET, CONNECTOR 11P < TRANSISTOR > Q1001 Q1002
8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H2 8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H2 < RESISTOR >
R1001 R1002 R1003 R1004 R1005
1-247-818-11 1-247-820-11 1-249-414-11 1-247-834-11 1-247-818-11
< IC >
www
IC1401 IC1403
L1401
.
S1001 S1002 S1003 S1004 S1005
1-692-832-11 1-692-832-11 1-572-248-11 1-571-281-21 1-571-281-21
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 1/4W
SWITCH, PUSH (1 KEY)(A PLAY) SWITCH, PUSH (1 KEY)(B PLAY) SWITCH, LEAF (A HALF) SWITCH, LEAF (A CrO2) SWITCH, LEAF (REC A)
S1006 S1008 S1009
1-572-248-11 SWITCH, LEAF (B HALF) 1-571-281-21 SWITCH, LEAF (B CrO2) 1-571-281-21 SWITCH, LEAF (REC B)
xiaoy u163. com
8-759-370-84 IC M65847FP-TP 8-759-140-53 IC uPD4053BC < COIL >
300 360 560 1.3K 300
< SWITCH >
< CONNECTOR > CN1401 1-566-999-11 PIN, CONNECTOR 13P
CARBON CARBON CARBON CARBON CARBON
1-410-521-11 INDUCTOR 100uH
**************************************************************
— 110 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
0.1uF 10uF 10uF 10uF 10uF
1-247-863-91 1-247-863-91 1-249-429-11 1-249-425-11 1-249-425-11
QQ
QQ
CERAMIC ELECT ELECT ELECT ELECT
R1413 R1414 R1417 R1418 R1419
13942296513
13942296513
A-4398-049-A KEY CON BOARD, COMPLETE ************************
1-164-159-21 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11
8-729-900-80 TRANSISTOR DTC114ES 8-729-119-78 TRANSISTOR 2SC2785-HFE
TEL
TEL
1-225-366-11 RES, VAR, CARBON 50K (MIC LEVEL) 1-225-366-11 RES, VAR, CARBON 50K (ECHO LEVEL)
C1401 C1403 C1404 C1405 C1406
Remark
< RESISTOR >
************************************************************** *
Description
< TRANSISTOR >
< VARIABLE RESISTOR > RV760 RV761
Part No.
http://www.xiaoyu163.com
QQ 376315150 892498299 LED
Ref. No.
Part No.
Description
*
1-659-059-13 LED BOARD *********
Remark
< DIODE > D201
8-719-032-98 DIODE SEL5820A (DISC No.) < TRANSISTOR >
Q201
8-729-119-78 TRANSISTOR 2SC2785-HFE < RESISTOR >
R201 R202 R203
1-247-863-91 CARBON 1-249-411-11 CARBON 1-249-437-11 CARBON
22K 330 47K
5% 5% 5%
1/4W 1/4W 1/4W
< CAPACITOR > CERAMIC CERAMIC CERAMIC ELECT MYLAR
330PF 100PF 100PF 2.2uF 0.0047uF
10% 10% 10% 20% 5%
50V 50V 50V 50V 50V
C107 C108 C109 C110 C111
1-130-473-00 1-136-159-00 1-126-933-11 1-162-306-11 1-162-306-11
MYLAR FILM ELECT CERAMIC CERAMIC
0.0015uF 0.033uF 100uF 0.01uF 0.01uF
5% 5% 20% 20% 20%
50V 50V 10V 16V 16V
C114 C121 C122 C125 C150
1-162-306-11 1-162-286-21 1-162-286-21 1-109-889-11 1-162-306-11
CERAMIC CERAMIC CERAMIC ELECT CERAMIC
0.01uF 220PF 220PF 1uF 0.01uF
20% 10% 10% 20% 20%
16V 50V 50V 50V 16V
C151 C153 C154 C155 C156
1-162-288-31 1-162-282-31 1-162-282-31 1-126-961-11 1-130-479-00
CERAMIC CERAMIC CERAMIC ELECT MYLAR
330PF 100PF 100PF 2.2uF 0.0047uF
10% 10% 10% 20% 5%
50V 50V 50V 50V 50V
C157 C158 C159 C164 C171
1-130-473-00 1-136-159-00 1-126-933-11 1-162-306-11 1-162-286-21
MYLAR FILM ELECT CERAMIC CERAMIC
0.0015uF 0.033uF 100uF 0.01uF 220PF
5% 5% 20% 20% 10%
50V 50V 10V 16V 50V
C172 C201 C202 C203 C204
1-162-286-21 1-136-167-00 1-136-167-00 1-136-495-11 1-136-495-11
CERAMIC FILM FILM FILM FILM
220PF 0.15uF 0.15uF 0.068uF 0.068uF
10% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C205 C206 C207 C208 C209
1-136-156-00 1-136-156-00 1-130-480-00 1-130-479-00 1-130-474-00
FILM FILM MYLAR MYLAR MYLAR
0.018uF 0.018uF 0.0056uF 0.0047uF 0.0018uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C210 C211 C212
1-126-964-11 ELECT 1-126-964-11 ELECT 1-136-171-00 FILM
10uF 10uF 0.33uF
20% 20% 5%
50V 50V 50V
TEL 13942296513
www
.
C213 C214
1-136-171-00 FILM 1-126-964-11 ELECT
0.33uF 10uF
5% 20%
50V 50V
C215 C230 C231 C234 C235
1-136-153-00 1-136-167-00 1-130-471-00 1-126-925-11 1-164-159-21
FILM FILM MYLAR ELECT CERAMIC
0.01uF 0.15uF 0.001uF 470uF 0.1uF
5% 5% 5% 20%
50V 50V 50V 10V 50V
C237 C238 C239 C241 C242
1-126-964-11 1-162-286-21 1-162-306-11 1-162-306-11 1-126-925-11
ELECT CERAMIC CERAMIC CERAMIC ELECT
10uF 220PF 0.01uF 0.01uF 470uF
20% 10% 20% 20% 20%
50V 50V 16V 16V 10V
C247 C248 C251 C252 C253
1-162-306-11 1-126-964-11 1-136-167-00 1-136-167-00 1-136-495-11
CERAMIC ELECT FILM FILM FILM
0.01uF 10uF 0.15uF 0.15uF 0.068uF
20% 20% 5% 5% 5%
16V 50V 50V 50V 50V
C254 C255 C256 C257 C258
1-136-495-11 1-136-156-00 1-136-156-00 1-130-480-00 1-130-479-00
FILM FILM FILM MYLAR MYLAR
0.068uF 0.018uF 0.018uF 0.0056uF 0.0047uF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C259 C260 C261 C262 C263
1-130-474-00 1-126-964-11 1-126-964-11 1-136-171-00 1-136-171-00
MYLAR ELECT ELECT FILM FILM
0.0018uF 10uF 10uF 0.33uF 0.33uF
5% 20% 20% 5% 5%
50V 50V 50V 50V 50V
C264 C265 C275 C301 C302
1-126-964-11 1-136-153-00 1-162-294-31 1-130-479-00 1-162-290-31
ELECT FILM CERAMIC MYLAR CERAMIC
10uF 0.01uF 0.001uF 0.0047uF 470PF
20% 5% 10% 5% 10%
50V 50V 50V 50V 50V
C303 C304 C305 C307 C308
1-130-495-00 1-126-964-11 1-126-960-11 1-126-964-11 1-126-964-11
MYLAR ELECT ELECT ELECT ELECT
0.1uF 10uF 1uF 10uF 10uF
5% 20% 20% 20% 20%
50V 50V 50V 50V 50V
C309 C310 C351 C352 C353
1-126-960-11 1-126-933-11 1-130-479-00 1-162-290-31 1-130-495-00
ELECT ELECT MYLAR CERAMIC MYLAR
1uF 100uF 0.0047uF 470PF 0.1uF
20% 20% 5% 10% 5%
50V 10V 50V 50V 50V
C355 C357 C358 C359 C360
1-126-960-11 1-126-964-11 1-126-964-11 1-126-960-11 1-126-933-11
ELECT ELECT ELECT ELECT ELECT
1uF 10uF 10uF 1uF 100uF
20% 20% 20% 20% 20%
50V 50V 50V 50V 10V
C401 C402 C403 C404 C405
1-164-159-21 1-164-159-21 1-164-159-21 1-126-933-11 1-126-767-11
CERAMIC CERAMIC CERAMIC ELECT ELECT
0.1uF 0.1uF 0.1uF 100uF 1000uF
20% 20%
50V 50V 50V 16V 16V
0.15uF 0.15uF 3.3uF 3.3uF 0.15uF
5% 5% 20% 20% 5%
50V 50V 50V 50V 50V
QQ 376315150 892498299
xiaoy u163. com C601 C602 C603 C604 C605
1-136-167-00 1-136-167-00 1-126-962-11 1-126-962-11 1-136-167-00
— 111 —
http://www.xiaoyu163.com
FILM FILM ELECT ELECT FILM
376315150 892498299
376315150 892498299
1-162-288-31 1-162-282-31 1-162-282-31 1-126-961-11 1-130-479-00
Remark
QQ
QQ
C101 C103 C104 C105 C106
Description
13942296513
13942296513
A-4398-990-A MAIN BOARD, COMPLETE *********************
*
Part No.
TEL
TEL
**************************************************************
Ref. No.
MAIN
http://www.xiaoyu163.com
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark 50V 50V
C669 C678 C711 C712 C713
1-109-889-11 1-162-294-31 1-126-916-11 1-164-159-21 1-102-518-11
ELECT CERAMIC ELECT CERAMIC CERAMIC
1uF 0.001uF 1000uF 0.1uF 33PF
20% 10% 20%
50V 50V 6.3V 50V 50V
C714 C723 C724 C766 C801
1-102-516-11 1-164-159-21 1-126-933-11 1-162-294-31 1-126-961-11
CERAMIC CERAMIC ELECT CERAMIC ELECT
27PF 0.1uF 100uF 0.001uF 2.2uF
5% 20% 10% 20%
50V 50V 10V 50V 50V
C803 C811 C853 C855 C856
1-126-925-11 1-126-961-11 1-162-294-31 1-162-294-31 1-162-294-31
ELECT ELECT CERAMIC CERAMIC CERAMIC
470uF 2.2uF 0.001uF 0.001uF 0.001uF
20% 20% 10% 10% 10%
10V 50V 50V 50V 50V
C861 C862 C863 C901 C902
1-162-306-11 1-126-964-11 1-126-964-11 1-126-939-11 1-126-768-11
CERAMIC ELECT ELECT ELECT ELECT
0.01uF 10uF 10uF 10000uF 2200uF
20% 20% 20% 20% 20%
16V 50V 50V 16V 16V
C903 C904 C908 C909 C910
1-164-159-21 1-164-159-21 1-126-933-11 1-126-933-11 1-126-964-11
CERAMIC CERAMIC ELECT ELECT ELECT
0.1uF 0.1uF 100uF 100uF 10uF
20% 20% 20%
50V 50V 10V 10V 50V
C911 C913 C914 C915 C916
1-126-768-11 1-126-964-11 1-126-767-11 1-126-964-11 1-126-916-11
ELECT ELECT ELECT ELECT ELECT
2200uF 10uF 1000uF 10uF 1000uF
20% 20% 20% 20% 20%
16V 50V 16V 50V 6.3V
C918 C919 C920 C943 C944
1-126-933-11 1-126-964-11 1-126-933-11 1-162-294-31 1-126-947-11
ELECT ELECT ELECT CERAMIC ELECT
100uF 10uF 100uF 0.001uF 47uF
20% 20% 20% 10% 20%
10V 50V 10V 50V 35V
C951 C952 C953 C961 C991
1-126-967-11 1-136-165-00 1-136-173-00 1-162-306-11 1-162-306-11
ELECT FILM FILM CERAMIC CERAMIC
47uF 0.1uF 0.47uF 0.01uF 0.01uF
20% 5% 5% 20% 20%
10V 50V 50V 16V 16V
C992
1-162-306-11 CERAMIC
0.01uF
20%
16V
C606 C607 C608 C609 C610
1-136-167-00 1-126-963-11 1-126-963-11 1-136-173-00 1-136-173-00
FILM ELECT ELECT FILM FILM
0.15uF 4.7uF 4.7uF 0.47uF 0.47uF
5% 20% 20% 5% 5%
50V 50V 50V 50V 50V
C611 C612 C613 C614 C615
1-126-963-11 1-126-963-11 1-136-173-00 1-136-173-00 1-136-165-00
ELECT ELECT FILM FILM FILM
4.7uF 4.7uF 0.47uF 0.47uF 0.1uF
20% 20% 5% 5% 5%
50V 50V 50V 50V 50V
C616 C617 C618 C619 C620
1-136-165-00 1-136-165-00 1-136-165-00 1-126-960-11 1-126-960-11
FILM FILM FILM ELECT ELECT
0.1uF 0.1uF 0.1uF 1uF 1uF
5% 5% 5% 20% 20%
50V 50V 50V 50V 50V
C621 C622 C623 C624 C625
1-126-923-11 1-126-964-11 1-126-964-11 1-126-964-11 1-126-964-11
ELECT ELECT ELECT ELECT ELECT
220uF 10uF 10uF 10uF 10uF
20% 20% 20% 20% 20%
10V 50V 50V 50V 50V
C626 C627 C628 C629 C630
1-126-923-11 1-136-161-00 1-136-157-00 1-162-292-31 1-126-933-11
ELECT FILM FILM CERAMIC ELECT
220uF 0.047uF 0.022uF 680PF 100uF
20% 5% 5% 10% 20%
10V 50V 50V 50V 10V
C631 C632 C633 C634 C635
1-162-306-11 1-126-964-11 1-136-173-00 1-104-664-11 1-130-467-00
CERAMIC ELECT FILM ELECT MYLAR
0.01uF 10uF 0.47uF 47uF 470PF
20% 20% 5% 20% 5%
16V 50V 50V 25V 50V
C636 C637 C638 C641 C642
1-130-467-00 1-162-306-11 1-162-306-11 1-136-171-00 1-136-159-00
MYLAR CERAMIC CERAMIC FILM FILM
470PF 0.01uF 0.01uF 0.33uF 0.033uF
5% 20% 20% 5% 5%
50V 16V 16V 50V 50V
C643 C644 C645 C646 C647
1-162-306-11 1-126-933-11 1-126-961-11 1-162-286-21 1-162-306-11
CERAMIC ELECT ELECT CERAMIC CERAMIC
0.01uF 100uF 2.2uF 220PF 0.01uF
20% 20% 20% 10% 20%
16V 10V 50V 50V 16V
C648 C649 C650 C651 C652
1-126-923-11 1-136-164-00 1-130-477-00 1-136-164-00 1-136-173-00
ELECT FILM MYLAR FILM FILM
220uF 0.082uF 0.0033uF 0.082uF 0.47uF
20% 5% 5% 5% 5%
10V 50V 50V 50V 50V
C653 C654 C655 C656 C657
1-126-923-11 1-126-960-11 1-126-960-11 1-126-964-11 1-162-306-11
ELECT ELECT ELECT ELECT CERAMIC
220uF 1uF 1uF 10uF 0.01uF
20% 20% 20% 20% 20%
10V 50V 50V 50V 16V
CN401 * CN402 * CN403 * CN701 CN801
1-568-838-11 1-568-830-11 1-568-449-11 1-568-836-11 1-568-832-11
< CONNECTOR > SOCKET, CONNECTOR 21P SOCKET, CONNECTOR 11P HOUSING, CONNECTOR (PC BOARD) 3P SOCKET, CONNECTOR 17P SOCKET, CONNECTOR 13P
C658 C660 C661 C662 C663
1-162-286-21 1-126-933-11 1-162-294-31 1-126-933-11 1-162-294-31
CERAMIC ELECT CERAMIC ELECT CERAMIC
220PF 100uF 0.001uF 100uF 0.001uF
10% 20% 10% 20% 10%
50V 10V 50V 10V 50V
* * * *
CN830 CN851 CN901 CN961
1-568-936-11 1-568-832-11 1-770-734-11 1-564-518-11
PIN, CONNECTOR 9P SOCKET, CONNECTOR 13P CONNECTOR, BOARD TO BOARD 20P PLUG, CONNECTOR 3P
C664 C665 C666
1-126-964-11 ELECT 1-126-964-11 ELECT 1-126-964-11 ELECT
10uF 10uF 10uF
20% 20% 20%
50V 50V 50V
TEL 13942296513
www
QQ 376315150 892498299
xiaoy u163. com < DIODE >
.
5%
D702 D772
8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M
— 112 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
20% 10%
QQ
QQ
10uF 220PF
13942296513
13942296513
1-126-964-11 ELECT 1-162-286-21 CERAMIC
TEL
TEL
C667 C668
http://www.xiaoyu163.com
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remark
8-719-987-63 DIODE 1N4148M 8-719-025-23 DIODE RBA-402-SL 8-719-200-82 DIODE 11ES2
D903 D904 D905 D906 D907
8-719-200-82 8-719-987-63 8-719-200-82 8-719-200-82 8-719-987-63
DIODE DIODE DIODE DIODE DIODE
11ES2 1N4148M 11ES2 11ES2 1N4148M
D908 D941 D942 D951 D952
8-719-200-82 8-719-002-60 8-719-010-43 8-719-987-63 8-719-987-63
DIODE DIODE DIODE DIODE DIODE
11ES2 UZL-33L UZ-5.6BSC 1N4148M 1N4148M
D953 D954
8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M < GROUND TERMINAL >
Description
Remark
Q201 Q202 Q206 Q251 Q252
8-729-119-78 8-729-119-78 8-729-900-36 8-729-119-78 8-729-119-78
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2785-HFE 2SC2785-HFE DTC124ES 2SC2785-HFE 2SC2785-HFE
Q253 Q254 Q256 Q403 Q406
8-729-141-26 8-729-141-26 8-729-900-36 8-729-801-93 8-729-900-80
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC3622A-LK 2SC3622A-LK DTC124ES 2SD1387 DTC114ES
Q407 Q408 Q409 Q601 Q602
8-729-900-80 8-729-119-76 8-729-900-80 8-729-141-26 8-729-141-26
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114ES 2SA1175-HFE DTC114ES 2SC3622A-LK 2SC3622A-LK
Q901 Q906 Q907 Q912 Q941
8-729-119-78 8-729-040-20 8-729-900-63 8-729-900-36 8-729-118-01
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2785-HFE RT1P137L-TP DTA124ES DTC124ES 2SB1116-K
Q951 Q961 Q962
8-729-119-78 TRANSISTOR 2SC2785-HFE 8-729-111-29 TRANSISTOR 2SD1616A-K 8-729-119-76 TRANSISTOR 2SA1175-HFE
13942296513
13942296513
* EPT901 1-537-738-21 TERMINAL, EARTH
Part No.
TEL
TEL
D799 D901 D902
Ref. No.
< IC > IC IC IC IC IC
M5218AP MC14052BCP uPD4053BC M62427FP-A HA12203NT
IC402 IC601 IC602 IC603 IC604
8-759-822-09 8-759-442-96 8-759-442-97 8-759-634-51 8-759-281-42
IC IC IC IC IC
LB1641 LA2786 LV1016 M5218AP TC9210P
IC701 IC861 IC901 IC902 IC903
8-759-486-11 8-759-634-51 8-759-288-53 8-759-231-53 8-759-604-86
IC IC IC IC IC
uPD780016YGF-019-3BA M5218AP LA5617 TA7805S M5F7807L
IC904 IC905 IC951
8-759-604-39 IC M5F78M12 8-759-604-38 IC M5F78M10L 8-759-635-63 IC M51943BSL
< RESISTOR > R101 R102 R103 R104 R105
1-249-417-11 1-249-417-11 1-249-437-11 1-249-417-11 1-247-897-11
CARBON CARBON CARBON CARBON CARBON
1K 1K 47K 1K 560K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W F 1/4W
R106 R107 R108 R109 R121
1-249-437-11 1-249-417-11 1-249-441-11 1-247-815-91 1-249-424-11
CARBON CARBON CARBON CARBON CARBON
47K 1K 100K 220 3.9K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
R122 R123 R124 R125 R126
1-247-887-00 1-249-417-11 1-249-441-11 1-249-421-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
220K 1K 100K 2.2K 100K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W F 1/4W
R127 R128 R129 R130 R151
1-249-421-11 1-249-426-11 1-249-429-11 1-249-441-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
2.2K 5.6K 10K 100K 1K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R152 R153 R154 R155 R156
1-249-417-11 1-249-437-11 1-249-417-11 1-247-897-11 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
1K 47K 1K 560K 47K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W
R157 R158 R159 R171 R172
1-249-417-11 1-249-441-11 1-247-815-91 1-249-424-11 1-247-887-00
CARBON CARBON CARBON CARBON CARBON
1K 100K 220 3.9K 220K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W F 1/4W
R173 R174 R178
1-249-417-11 CARBON 1-249-441-11 CARBON 1-249-426-11 CARBON
1K 100K 5.6K
5% 5% 5%
1/4W F 1/4W 1/4W
QQ 376315150 892498299
TEL 13942296513
< JACK > J101
1-774-411-11 JACK, PIN 6P (VIDEO(AUDIO) IN/OUT, PHONO IN) < COIL >
L601 L602 L604 L769 L770
1-410-509-11 1-410-509-11 1-410-509-11 1-410-521-11 1-410-521-11
L772 L861
1-410-521-11 INDUCTOR 100uH 1-410-521-11 INDUCTOR 100uH
www Q120 Q121 Q122 Q123 Q124
INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR
10uH 10uH 10uH 100uH 100uH
< TRANSISTOR >
8-729-422-57 8-729-141-26 8-729-141-26 8-729-422-57 8-729-900-36
.
xiaoy u163. com TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
UN4111 2SC3622A-LK 2SC3622A-LK UN4111 DTC124ES
— 113 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
8-759-634-51 8-759-000-48 8-759-140-53 8-759-460-02 8-759-460-02
QQ
QQ
IC101 IC102 IC103 IC201 IC401
http://www.xiaoyu163.com
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remark
5% 5%
1/4W 1/4W F
R203 R204 R205 R206 R207
1-249-437-11 1-249-437-11 1-249-441-11 1-247-887-00 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
47K 47K 100K 220K 47K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R208 R209 R210 R211 R212
1-249-429-11 1-249-411-11 1-249-429-11 1-249-421-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
10K 330 10K 2.2K 100K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W
R213 R214 R215 R216 R217
1-249-429-11 1-249-437-11 1-249-441-11 1-247-891-00 1-249-431-11
CARBON CARBON CARBON CARBON CARBON
10K 47K 100K 330K 15K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R222 R223 R230 R231 R232
1-247-903-00 1-247-903-00 1-247-863-91 1-247-863-91 1-247-856-00
CARBON CARBON CARBON CARBON CARBON
1M 1M 22K 22K 11K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R240 R241 R242 R243 R244
1-249-429-11 1-249-429-11 1-249-429-11 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
10K 10K 10K 1K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W F
1-249-417-11 1-249-425-11 1-249-437-11 1-249-437-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
1K 4.7K 47K 47K 100K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W
R256 R257 R258 R259 R260
1-247-887-00 1-249-437-11 1-249-429-11 1-249-411-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
220K 47K 10K 330 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R261 R262 R263 R264 R265
1-249-421-11 1-249-441-11 1-249-429-11 1-249-437-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
2.2K 100K 10K 47K 100K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R266 R267 R273 R301 R304
1-247-891-00 1-249-431-11 1-247-903-00 1-249-435-11 1-249-426-11
CARBON CARBON CARBON CARBON CARBON
330K 15K 1M 33K 5.6K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R305 R306 R307 R308 R309
1-249-417-11 1-247-840-00 1-247-863-91 1-249-421-11 1-249-428-11
CARBON CARBON CARBON CARBON CARBON
1K 2.4K 22K 2.2K 8.2K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W F 1/4W F
www
R351 R354 R355 R356 R357
1-247-863-91 1-249-426-11 1-249-417-11 1-247-840-00 1-247-863-91
CARBON CARBON CARBON CARBON CARBON
.
Part No.
Description
Remark
R358 R359 R401 R402 R403
1-249-421-11 1-249-428-11 1-249-425-11 1-249-425-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
2.2K 8.2K 4.7K 4.7K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R404 R405 R406 R407 R408
1-249-417-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11
CARBON CARBON CARBON CARBON CARBON
1K 47K 47K 47K 47K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R410 R411 R414 R415 R416
1-249-430-11 1-249-426-11 1-249-429-11 1-249-432-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
12K 5.6K 10K 18K 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R417 R419 R454 R455 R456
1-249-441-11 1-249-429-11 1-249-425-11 1-249-425-11 1-249-411-11
CARBON CARBON CARBON CARBON CARBON
100K 10K 4.7K 4.7K 330
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W
R457 R458 R461 R601 R602
1-249-427-11 1-249-429-11 1-247-843-11 1-247-887-00 1-247-887-00
CARBON CARBON CARBON CARBON CARBON
6.8K 10K 3.3K 220K 220K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R603 R604 R605 R615 R621
1-249-417-11 1-249-432-11 1-249-417-11 1-249-441-11 1-249-436-11
CARBON CARBON CARBON CARBON CARBON
1K 18K 1K 100K 39K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/4W
R622 R623 R624 R625 R626
1-249-436-11 1-249-417-11 1-247-903-00 1-249-411-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
39K 1K 1M 330 1K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W F
R627 R628 R630 R631 R632
1-249-417-11 1-249-417-11 1-249-425-11 1-249-431-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
1K 1K 4.7K 15K 100K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W F 1/4W 1/4W
R633 R634 R635 R636 R637
1-249-425-11 1-249-427-11 1-249-441-11 1-249-437-11 1-249-441-11
CARBON CARBON CARBON CARBON CARBON
4.7K 6.8K 100K 47K 100K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W
R638 R639 R640 R641 R642
1-249-441-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
100K 1K 1K 1K 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R645 R646 R650 R651 R700
1-249-429-11 1-249-429-11 1-249-441-11 1-249-417-11 1-249-425-11
CARBON CARBON CARBON CARBON CARBON
10K 10K 100K 1K 4.7K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W F
R704 R705 R720
1-247-807-31 CARBON 1-247-807-31 CARBON 1-249-425-11 CARBON
100 100 4.7K
5% 5% 5%
1/4W 1/4W 1/4W F
QQ 376315150 892498299
xiaoy u163. com 22K 5.6K 1K 2.4K 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 1/4W
F F F F F
— 114 —
http://www.xiaoyu163.com
F F F F
376315150 892498299
376315150 892498299
TEL 13942296513
R245 R252 R253 R254 R255
Ref. No.
QQ
QQ
10K 4.7K
13942296513
13942296513
1-249-429-11 CARBON 1-249-425-11 CARBON
TEL
TEL
R179 R202
http://www.xiaoyu163.com
QQ 376315150 892498299 MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
R961 R962 R963
1/4W 1/4W
R728 R730 R731 R744 R745
1-247-807-31 1-249-431-11 1-249-415-11 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
100 15K 680 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R755 R756 R757 R760 R761
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
100 100 100 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R762 R765 R766 R767 R768
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
100 100 100 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R776 R777 R794 R795 R796
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
100 100 100 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R797 R798 R801 R802 R807
1-247-807-31 1-249-425-31 1-247-807-11 1-249-435-11 1-249-435-11
CARBON CARBON CARBON CARBON CARBON
100 4.7K 100 33K 33K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W F 1/4W 1/4W
R811 R812 R856 R858 R861
1-247-807-31 1-249-435-11 1-249-417-11 1-249-417-11 1-247-886-11
CARBON CARBON CARBON CARBON CARBON
100 33K 1K 1K 200K
5% 5% 5% 5% 5%
R862 R869 R870 R877 R901
1-249-441-11 1-249-429-11 1-247-843-11 1-249-437-11 1-247-895-91
CARBON CARBON CARBON CARBON CARBON
100K 10K 3.3K 47K 470K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R902 R906 R907 ! R908 ! R909
1-249-417-11 1-249-417-11 1-249-429-11 1-215-910-00 1-215-910-00
CARBON CARBON CARBON METAL METAL
1K 1K 10K 68 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 3W 3W
F F
! R910 ! R911 R912 ! R941 R942
1-215-910-00 1-215-910-00 1-249-417-11 1-217-637-11 1-247-863-91
METAL METAL CARBON FUSIBLE CARBON
68 68 1K 1 22K
5% 5% 5% 5% 5%
3W 3W 1/4W 1/4W 1/4W
F F F F F
R943 R944 R945 R948 R951
1-249-425-11 1-247-815-91 1-247-815-91 1-249-417-11 1-249-417-11
CARBON CARBON CARBON CARBON CARBON
4.7K 220 220 1K 1K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W F 1/4W F
TEL 13942296513
www R952 R953 R954 R955 R956
1-249-425-11 1-247-807-31 1-249-437-11 1-249-437-11 1-249-429-11
.
< VARIABLE RESISTOR > RV301 RV351
1-238-598-11 RES, ADJ, CARBON 2.2K 1-238-598-11 RES, ADJ, CARBON 2.2K < VIBRATOR >
X601 X701 X702
1-579-125-11 VIBRATOR, CERAMIC (8MHz) 1-579-233-11 VIBRATOR, CERAMIC (5MHz) 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
************************************************************** *
A-4398-986-A PANEL BOARD, COMPLETE **********************
*
4-986-870-11 HOLDER, FL TUBE < CAPACITOR > C601 C602 C603 C604 C606
1-126-967-11 1-162-306-11 1-126-963-11 1-126-960-11 1-126-960-11
ELECT CERAMIC ELECT ELECT ELECT
47uF 0.01uF 4.7uF 1uF 1uF
20% 20% 20% 20% 20%
50V 16V 50V 50V 50V
C608 C610 C611 C612 C613
1-124-584-00 1-162-306-11 1-162-306-11 1-126-967-11 1-164-159-21
ELECT CERAMIC CERAMIC ELECT CERAMIC
100uF 0.01uF 0.01uF 47uF 0.1uF
20% 20% 20% 20%
10V 16V 16V 50V 50V
C621 C622 C623 C624 C625
1-126-960-11 1-136-161-00 1-126-957-11 1-126-957-11 1-162-306-11
ELECT FILM ELECT ELECT CERAMIC
1uF 0.047uF 0.22uF 0.22uF 0.01uF
20% 5% 20% 20% 20%
50V 50V 50V 50V 16V
C626 C627 C628 C629 C630
1-126-957-11 1-136-159-00 1-162-302-11 1-126-957-11 1-162-293-31
ELECT FILM CERAMIC ELECT CERAMIC
0.22uF 0.033uF 0.0022uF 0.22uF 820PF
20% 5% 30% 20% 10%
50V 50V 16V 50V 50V
C631 C632 C641 C642 C643
1-126-957-11 1-126-957-11 1-162-286-21 1-162-286-21 1-162-286-21
ELECT ELECT CERAMIC CERAMIC CERAMIC
0.22uF 0.22uF 220PF 220PF 220PF
20% 20% 10% 10% 10%
50V 50V 50V 50V 50V
C644 C645 C646 C647 C648
1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
220PF 220PF 220PF 220PF 220PF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C649 C650 C651 C652 C653
1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
220PF 220PF 220PF 220PF 220PF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C654 C655 C656
1-162-286-21 CERAMIC 1-162-286-21 CERAMIC 1-162-286-21 CERAMIC
220PF 220PF 220PF
10% 10% 10%
50V 50V 50V
QQ 376315150 892498299 1/4W F 1/4W 1/4W F 1/4W F 1/4W
F F
xiaoy u163. com CARBON CARBON CARBON CARBON CARBON
4.7K 100 47K 47K 10K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F
1/4W F 1/4W 1/4W 1/4W 1/4W
— 115 —
http://www.xiaoyu163.com
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
376315150 892498299
376315150 892498299
5% 5%
5% 5% 5%
QQ
QQ
100 100
Remark
2.2K 18K 4.7K
13942296513
13942296513
1-247-807-31 CARBON 1-247-807-31 CARBON
Description
1-249-421-11 CARBON 1-249-432-11 CARBON 1-249-425-11 CARBON
TEL
TEL
R726 R727
Part No.
PANEL
http://www.xiaoyu163.com
QQ 376315150 892498299 PANEL
Ref. No.
Part No.
Description
Remark
C690
1-164-159-21 CERAMIC
0.1uF
C693
1-164-159-21 CERAMIC
0.1uF
C695 C696 C697 C698
1-164-159-21 1-164-159-21 1-162-294-31 1-136-165-00
0.1uF 0.1uF 0.001uF 0.1uF
50V (EXCEPT MY) 50V (EXCEPT MY)
Description
Remark
< TRANSISTOR >
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2785-HFE 2SB1116-L 2SB1116-L 2SA1175-FEK 2SA1175-FEK
Q606 Q607 Q608 Q609 Q610
8-729-119-77 8-729-119-77 8-729-119-77 8-729-119-77 8-729-119-77
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA1175-FEK 2SA1175-FEK 2SA1175-FEK 2SA1175-FEK 2SA1175-FEK
< DIODE >
Q611 Q612 Q613 Q614 Q615
8-729-119-77 8-729-119-77 8-729-119-77 8-729-119-77 8-729-119-77
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA1175-FEK 2SA1175-FEK 2SA1175-FEK 2SA1175-FEK 2SA1175-FEK
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SA1175-FEK 2SA1175-FEK 2SA1175-FEK 2SA1175-FEK 2SA1175-FEK
CERAMIC CERAMIC CERAMIC FILM
50V 50V 10% 50V 5% 50V (EXCEPT MY)
SOCKET, CONNECTOR 17P PIN, CONNECTOR 9P PIN, CONNECTOR 7P PIN, CONNECTOR 9P
13942296513
8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63
DIODE DIODE DIODE DIODE DIODE
1N4148M 1N4148M 1N4148M 1N4148M 1N4148M
Q616 Q617 Q618 Q619 Q621
8-729-119-77 8-729-119-77 8-729-119-77 8-729-119-77 8-729-119-77
D606 D607 D611 D612 D613
8-719-987-63 8-719-987-63 8-719-057-29 8-719-057-29 8-719-058-04
DIODE DIODE DIODE DIODE DIODE
1N4148M 1N4148M SML78423C-TP15 (TUNER/BAND) SML78423C-TP15 (TUNER/BAND) SEL5223S-TP15 (ENTER/NEXT)
Q622
8-729-119-77 TRANSISTOR 2SA1175-FEK
D614 D615 D616 D617 D618
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
DIODE DIODE DIODE DIODE DIODE
SEL5223S-TP15 (GROOVE) SEL5223S-TP15 (SUPER WOOFER) SEL5223S-TP15 (EFFECT) SEL5223S-TP15 (ENTER) SEL5223S-TP15 (FILE 1)
D619 D620 D621 D622 D623
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
DIODE DIODE DIODE DIODE DIODE
SEL5223S-TP15 (FILE 2) SEL5223S-TP15 (FILE 3) SEL5223S-TP15 (FILE 4) SEL5223S-TP15 (FILE 5) SEL5223S-TP15 (P.FILE)
D624 D625 D626 D627 D628
8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04
DIODE DIODE DIODE DIODE DIODE
SEL5223S-TP15 (MENU 2) SEL5223S-TP15 (MENU 1) SEL5223S-TP15 (DSP) SEL5223S-TP15 (PRO LOGIC) SEL5223S-TP15 (KEY CONTROL)
D629
8-719-058-04 DIODE SEL5223S-TP15 (PRO LOGIC) < FERRITE BEAD >
FB601
1-412-473-21 INDUCTOR 0UH < FLUORESCENT INDICATOR >
FL601
1-517-617-11 INDICATOR TUBE, FLUORESCENT < IC >
IC601 IC602
8-759-468-17 IC TMP87CM75-6565 8-759-459-84 IC NJL56H400
www
< COIL >
L601
.
R601 R602 R603 R606 R607
1-247-843-11 1-249-427-11 1-247-903-00 1-249-429-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
3.3K 6.8K 1M 10K 10K
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W 1/4W
R608 R609 R610 R611 R612
1-249-429-11 1-249-429-11 1-249-429-11 1-247-843-11 1-247-843-11
CARBON CARBON CARBON CARBON CARBON
10K 10K 10K 3.3K 3.3K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R613 R614 R615 R617 R621
1-249-401-11 1-249-429-11 1-249-429-11 1-249-429-11 1-249-421-11
CARBON CARBON CARBON CARBON CARBON
47 10K 10K 10K 2.2K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W F
R622 R623 R624 R625 R626
1-249-437-11 1-247-895-91 1-249-421-11 1-249-437-11 1-247-895-91
CARBON CARBON CARBON CARBON CARBON
47K 470K 2.2K 47K 470K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 1/4W
R627 R628 R629 R631 R632
1-249-421-11 1-249-437-11 1-247-895-91 1-249-437-11 1-247-895-91
CARBON CARBON CARBON CARBON CARBON
2.2K 47K 470K 47K 470K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W 1/4W 1/4W
R633 R634 R635 R636 R637
1-247-897-11 1-247-897-11 1-247-897-11 1-247-897-11 1-247-895-91
CARBON CARBON CARBON CARBON CARBON
560K 560K 560K 560K 470K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R638 R641 R642
1-249-435-11 CARBON 1-249-419-11 CARBON 1-249-401-11 CARBON
33K 1.5K 47
5% 5% 5%
1/4W 1/4W F 1/4W F
QQ 376315150 892498299
xiaoy u163. com
1-410-509-11 INDUCTOR 10uH
— 116 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
< RESISTOR >
QQ
QQ
D601 D602 D603 D604 D605
13942296513
8-729-119-78 8-729-118-00 8-729-118-00 8-729-119-77 8-729-119-77
TEL
TEL
1-568-836-11 1-568-947-11 1-506-486-11 1-568-947-11
Part No.
Q601 Q602 Q603 Q604 Q605
< CONNECTOR > * CN601 * CN602 CN603 * CN604
Ref. No.
http://www.xiaoyu163.com
QQ 376315150 892498299 PANEL
Ref. No.
Part No.
Description
Remark
1/4W F 1/4W
R645 R646 R647 R648 R649
1-249-407-11 1-249-407-11 1-247-815-91 1-249-411-11 1-249-413-11
CARBON CARBON CARBON CARBON CARBON
150 150 220 330 470
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W F
R650 R651 R652 R653 R654
1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11
CARBON CARBON CARBON CARBON CARBON
680 1K 1.5K 2.2K 3.3K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F F F F
R655 R656 R657 R658 R659
1-249-427-11 1-249-431-11 1-249-419-11 1-249-401-11 1-249-403-11
CARBON CARBON CARBON CARBON CARBON
6.8K 15K 1.5K 47 68
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
F
R660 R661 R662 R663 R664
1-247-807-31 1-249-407-11 1-249-407-11 1-249-419-11 1-249-401-11
CARBON CARBON CARBON CARBON CARBON
100 150 150 1.5K 47
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R665 R666 R667 R668 R669
1-249-403-11 1-247-807-31 1-249-407-11 1-249-407-11 1-249-419-11
CARBON CARBON CARBON CARBON CARBON
68 100 150 150 1.5K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R670 R671 R672 R673 R674
1-249-401-11 1-249-403-11 1-247-807-31 1-249-407-11 1-249-407-11
CARBON CARBON CARBON CARBON CARBON
47 68 100 150 150
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R675 R676 R677 R678 R679
1-247-815-91 1-249-411-11 1-249-413-11 1-249-415-11 1-249-419-11
CARBON CARBON CARBON CARBON CARBON
220 330 470 680 1.5K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W F
R681 R682 R683 R684 R685
1-249-429-11 1-249-421-11 1-247-887-00 1-249-421-11 1-247-815-91
CARBON CARBON CARBON CARBON CARBON
10K 2.2K 220K 2.2K 220
5% 5% 5% 5% 5%
1/4W 1/4W F 1/4W 1/4W F 1/4W
R686 R687 R688 R689 R690
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
100 100 100 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R691 R692 R693 R694 R695
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
100 100 100 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
TEL 13942296513
www
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
.
100 100 100 100 100
5% 5% 5% 5% 5%
5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W
F F F
F F F F F F F F
S601 S602 S603 S604 S605
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (ENTER/NEXT) SWITCH, TACTILE (TUNER MEMORY) SWITCH, TACTILE (TUNING MODE) SWITCH, TACTILE (TUNER/BAND) SWITCH, TACTILE (TUNING +)
S606 S607 S609 S610 S611
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (TUNING –) SWITCH, TACTILE (STEREO/MONO) SWITCH, TACTILE (FUNCTION) SWITCH, TACTILE (GROOVE) SWITCH, TACTILE (GEQ 4)
S612 S613 S614 S615 S616
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (GEQ “) SWITCH, TACTILE (GEQ ”) SWITCH, TACTILE (GEQ $) SWITCH, TACTILE (SUPER WOOFER) SWITCH, TACTILE (SUPER W MODE)
S617 S618 S619 S620 S621
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (KEY CONTROL #) SWITCH, TACTILE (KEY CONTROL ˜) SWITCH, TACTILE (GEQ CONTROL) SWITCH, TACTILE (ENTER) SWITCH, TACTILE (EFFECT)
S622 S623 S624 S625 S626
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (WAVE) SWITCH, TACTILE (KARAOKE PON/MPX) SWITCH, TACTILE (DSP) SWITCH, TACTILE (PRO LOGIC) SWITCH, TACTILE (P FILE, MEMORY)
S627 S628 S629 S630 S631
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (SPECTRUM ANALYZER) SWITCH, TACTILE (DISPLAY/DEMO) SWITCH, TACTILE (POWER) SWITCH, TACTILE (t/CLOCK SET) SWITCH, TACTILE (REC)
S632 S633 S634 S701
1-554-303-21 1-554-303-21 1-554-303-21 1-467-869-11
SWITCH, TACTILE (DAILY 1) SWITCH, TACTILE (DAILY 2) SWITCH, TACTILE (SLEEP) ENCODER, ROTARY (VOLUME)
QQ 376315150 892498299 F F F F
< VIBRATOR > 1-579-125-11 VIBRATOR, CERAMIC (8MHz)
************************************************************** *
A-4392-679-A POWER BOARD, COMPLETE (E,MY,SP,IA) ************************************
*
A-4403-679-A POWER BOARD, COMPLETE (CH) *************************** < CAPACITOR > C101 C102 C103 C104 C105
1-130-781-00 1-130-781-00 1-136-169-00 1-136-169-00 1-162-294-31
FILM FILM FILM FILM CERAMIC
0.22uF 0.22uF 0.22uF 0.22uF 0.001uF
10% 10% 5% 5% 10%
100V 100V 50V 50V 50V
C106
1-162-294-31 CERAMIC
0.001uF
10%
50V
xiaoy u163. com CARBON CARBON CARBON CARBON CARBON
Remark
100 100 100 100
< SWITCH >
X601
R696 R697 R698 R699 R700
CARBON CARBON CARBON CARBON
1/4W 1/4W 1/4W 1/4W 1/4W
— 117 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
5% 5%
Description
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
QQ
QQ
68 100
Part No.
13942296513
13942296513
1-249-403-11 CARBON 1-247-807-31 CARBON
R701 R702 R703 R704
TEL
TEL
R643 R644
Ref. No.
POWER
http://www.xiaoyu163.com
QQ 376315150 892498299 POWER
Ref. No.
Remark
ELECT ELECT ELECT ELECT
100uF 100uF 100uF 4700uF
20% 20% 20% 20%
63V 100V 50V 71V
C152 C153 C154 C201 C202
1-128-493-11 1-128-550-11 1-128-550-11 1-128-582-11 1-162-292-31
ELECT ELECT ELECT ELECT CERAMIC
4700uF 2200uF 2200uF 10uF 680PF
20% 20% 20% 20% 10%
71V 50V 50V 100V 50V
C203 C204 C205 C206 C208
1-162-286-21 1-126-967-11 1-126-967-11 1-128-560-11 1-126-965-11
CERAMIC ELECT ELECT ELECT ELECT
220PF 47uF 47uF 22uF 22uF
10% 20% 20% 20% 20%
50V 50V 50V 100V 50V
C210 C211 C225 C226 C228
1-130-493-00 1-130-493-00 1-162-284-31 1-162-284-31 1-164-159-21
MYLAR MYLAR CERAMIC CERAMIC CERAMIC
0.068uF 0.068uF 150PF 150PF 0.1uF
5% 5% 10% 10%
50V 50V 50V 50V 50V
C232 C251 C252 C253 C254
1-162-284-31 1-128-582-11 1-162-292-31 1-162-286-21 1-126-967-11
CERAMIC ELECT CERAMIC CERAMIC ELECT
150PF 10uF 680PF 220PF 47uF
10% 20% 10% 10% 20%
50V 100V 50V 50V 50V
C255 C256 C260 C261 C299
1-126-967-11 1-128-560-11 1-130-493-00 1-130-493-00 1-161-494-00
ELECT ELECT MYLAR MYLAR CERAMIC
47uF 22uF 0.068uF 0.068uF 0.022uF
20% 20% 5% 5%
50V 100V 50V 50V 25V (CH)
C301
1-126-959-11 ELECT
0.47uF
20%
50V
C302 C303 C304 C305 C331
1-126-923-11 1-126-933-11 1-126-961-11 1-126-933-11 1-126-924-11
ELECT ELECT ELECT ELECT ELECT
220uF 100uF 2.2uF 100uF 330uF
20% 20% 20% 20% 20%
10V 10V 50V 10V 10V
C401 C402 C403 C404 C405
1-126-963-11 1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21
ELECT CERAMIC CERAMIC CERAMIC CERAMIC
4.7uF 0.1uF 0.1uF 0.1uF 0.1uF
20%
50V 50V (CH) 50V (CH) 50V (CH) 50V (CH)
C406 C407 C408 C409 C410
1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21 1-161-494-00
CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC
0.1uF 0.1uF 0.1uF 0.1uF 0.022uF
50V (CH) 50V (CH) 50V (CH) 50V (CH) 25V
C411 C412 C413
1-161-494-00 CERAMIC 1-161-494-00 CERAMIC 1-161-494-00 CERAMIC
0.022uF 0.022uF 0.022uF
25V 25V 25V
TEL 13942296513
< COIL > L401 L402 L403 L404
1-420-872-00 1-420-872-00 1-420-872-00 1-420-872-00
COIL, AIR-CORE (CH) COIL, AIR-CORE (CH) COIL, AIR-CORE (CH) COIL, AIR-CORE (CH)
www
.
Remark
< DIODE >
D101 D102 D104 D105 D110
8-719-510-68 8-719-025-03 8-719-200-82 8-719-200-82 8-719-200-82
DIODE DIODE DIODE DIODE DIODE
D5SBA20F01 RBA-402-SL 11ES2 11ES2 11ES2
D111 D201 D251 D301 D302
8-719-200-82 8-719-815-85 8-719-815-85 8-719-987-63 8-719-987-63
DIODE DIODE DIODE DIODE DIODE
11ES2 1S1585 1S1585 1N4148M 1N4148M
D303 D321 D331 D332 D401
8-719-987-63 8-719-815-85 8-719-987-63 8-719-987-63 8-719-987-63
DIODE DIODE DIODE DIODE DIODE
1N4148M 1S1585 1N4148M 1N4148M 1N4148M
D402 D403 D404 D405 D406
8-719-987-63 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85
DIODE DIODE DIODE DIODE DIODE
1N4148M 1S1585 1S1585 1S1585 1S1585
< EARTH TERMINAL > * EP101 * EP201
1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH < FUSE >
QQ 376315150 892498299 ! F101 ! F102 ! F103 ! F104
1-532-464-31 1-532-464-31 1-532-506-31 1-532-506-31
FUSE, TIME-LAG (2.5A/250V) FUSE, TIME-LAG (2.5A/250V) FUSE, TIME-LAG (6.3A/250V) FUSE, TIME-LAG (6.3A/250V) < FUSE HOLDER >
FH101 FH102 FH103 FH104 FH105
1-533-233-21 1-533-233-21 1-533-233-21 1-533-233-21 1-533-233-21
FH106 FH107 FH108
1-533-233-21 HOLDER, FUSE 1-533-233-21 HOLDER, FUSE 1-533-233-21 HOLDER, FUSE
HOLDER, FUSE HOLDER, FUSE HOLDER, FUSE HOLDER, FUSE HOLDER, FUSE
< IC > IC201 IC301
8-749-922-65 IC STK-4221MK2 8-759-111-68 IC uPC1237HA < TRANSISTOR >
Q201 Q251 Q301 Q323 Q331
8-729-140-84 8-729-140-84 8-729-900-89 8-729-900-63 8-729-900-89
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC1841-PAFAEA 2SC1841-PAFAEA DTC144ES DTA124ES DTC144ES
xiaoy u163. com Q401 Q402 Q403 Q404 Q405
< CONNECTOR >
* CN201
Description
8-729-900-80 8-729-904-39 8-729-040-20 8-729-040-20 8-729-900-80
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114ES DTC114TS RT1P137L-TP RT1P137L-TP DTC114ES
1-766-957-11 CONNECTOR, BOARD TO BOARD 20P
— 118 —
http://www.xiaoyu163.com
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
376315150 892498299
376315150 892498299
1-128-576-11 1-128-563-11 1-104-665-11 1-128-493-11
Part No.
QQ
QQ
C107 C108 C110 C151
Ref. No.
13942296513
13942296513
Description
TEL
TEL
Part No.
http://www.xiaoyu163.com
QQ 376315150 892498299 POWER
Ref. No.
Part No.
Description
Remark
Ref. No.
Description
R408 R409 R410 R411
1-249-437-11 1-249-440-11 1-249-437-11 1-249-437-11
CARBON CARBON CARBON CARBON
R412
Remark 1/4W 1/4W 1/4W 1/4W
1-249-389-11 CARBON
4.7
5%
R413
1-249-389-11 CARBON
4.7
5%
R414
1-249-389-11 CARBON
4.7
5%
R415
1-249-389-11 CARBON
4.7
5%
R416
1-249-389-11 CARBON
4.7
5%
1/4W F (CH) 1/4W F (CH) 1/4W F (CH) 1/4W F (CH) 1/4W F (CH)
R417
1-249-389-11 CARBON
4.7
5%
R418
1-249-393-11 CARBON
10
5%
F F F
R419
1-249-389-11 CARBON
4.7
5%
R420
1-249-389-11 CARBON
4.7
5%
F
R421
1-249-393-11 CARBON
10
5%
R422
1-249-389-11 CARBON
4.7
5%
R423
1-249-389-11 CARBON
4.7
5%
TEL 13942296513
1-219-122-91 1-249-417-11 1-249-437-11 1-249-413-11 1-249-437-11
FUSIBLE CARBON CARBON CARBON CARBON
0.33 1K 47K 470 47K
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W F 1/4W
R206 R208 ! R209 ! R210 R211
1-260-107-11 1-260-107-11 1-212-881-11 1-217-156-00 1-249-417-11
CARBON CARBON FUSIBLE METAL PLATE CARBON
4.7K 4.7K 100 0.22 1K
5% 5% 5% 10% 5%
1/2W 1/2W 1/4W F 5W 1/4W F
R212 R213 R215 R216 R218
1-249-431-11 1-249-441-11 1-260-103-11 1-260-103-11 1-260-076-11
CARBON CARBON CARBON CARBON CARBON
15K 100K 2.2K 2.2K 10
5% 5% 5% 5% 5%
1/4W F 1/4W 1/2W 1/2W 1/2W
R227 ! R250 R251 R252 R253
1-249-425-11 1-217-637-00 1-249-417-11 1-249-437-11 1-249-413-11
CARBON FUSIBLE CARBON CARBON CARBON
4.7K 1 1K 47K 470
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R254 R256 R258 ! R259 ! R260
1-249-437-11 1-260-107-11 1-260-107-11 1-212-881-11 1-217-156-00
CARBON CARBON CARBON FUSIBLE METAL PLATE
47K 4.7K 4.7K 100 0.22
5% 5% 5% 5% 10%
1/4W 1/2W 1/2W 1/4W F 5W
1/4W F (CH) 1/4W F (CH) 1/4W F (CH) 1/4W F (CH) 1/4W F (CH) 1/4W F (CH) 1/4W F (CH)
1-249-417-11 1-249-431-11 1-249-441-11 1-260-076-11 1-260-093-11
CARBON CARBON CARBON CARBON CARBON
1K 15K 100K 10 330
5% 5% 5% 5% 5%
R273 R274 R275 R301 R302
1-260-093-11 1-260-093-11 1-260-093-11 1-249-441-11 1-247-854-11
CARBON CARBON CARBON CARBON CARBON
330 330 330 100K 9.1K
5% 5% 5% 5% 5%
1/2W 1/2W 1/2W 1/4W 1/4W
R303 R304 R305 R306 R307
1-247-854-11 1-249-429-11 1-249-419-11 1-249-441-11 1-247-863-91
CARBON CARBON CARBON CARBON CARBON
9.1K 10K 1.5K 100K 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 1/4W
R308 R309 R310 R311 R312
1-247-863-91 1-247-791-91 1-249-437-11 1-249-429-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
22K 22 47K 10K 10K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R314 R315 R316 R317 R331
1-249-439-11 1-249-439-11 1-249-437-11 1-249-437-11 1-247-890-11
CARBON CARBON CARBON CARBON CARBON
68K 68K 47K 47K 300K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R332 R333 R334 R401 ! R405
1-249-429-11 1-249-431-11 1-249-417-11 1-249-429-11 1-215-886-11
CARBON CARBON CARBON CARBON METAL OXIDE
10K 15K 1K 10K 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W 2W F
! R407
1-215-886-11 METAL OXIDE
100
5%
2W
< RELAY >
1/4W F 1/4W F 1/4W 1/2W 1/2W
RY401 RY402
1-755-142-11 RELAY 1-755-141-11 RELAY
< TERMINAL > TM401 TM402
1-537-842-11 TERMINAL BOARD (FRONT SPEAKER) 1-537-510-11 TERMINAL BOARD (SPEAKER)(6P) (SURROUND SPEAKER)
**************************************************************
www
.
*
A-4392-662-A SURROUND BOARD, COMPLETE (E,MY,SP,IA) **************************
*
A-4392-663-A SURROUND BOARD, COMPLETE (CH) ************************** < CAPACITOR > C601 C602 C603 C604 C605
1-126-963-11 1-162-292-31 1-162-286-21 1-126-967-11 1-126-967-11
ELECT CERAMIC CERAMIC ELECT ELECT
4.7uF 680PF 220PF 47uF 47uF
20% 10% 10% 20% 20%
50V 50V 50V 50V 50V
C606 C608 C610 C611 C613
1-126-968-11 1-126-965-11 1-130-493-00 1-130-493-00 1-161-494-00
ELECT ELECT MYLAR MYLAR CERAMIC
100uF 22uF 0.068uF 0.068uF 0.022uF
20% 20% 5% 5%
50V 50V 50V 50V 25V (CH)
C620 C625 C626 C628
1-126-923-11 1-162-284-31 1-162-284-31 1-164-159-21
ELECT CERAMIC CERAMIC CERAMIC
220uF 150PF 150PF 0.1uF
20% 10% 10%
10V 50V 50V (CH) 50V
xiaoy u163. com F
— 119 —
http://www.xiaoyu163.com
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
376315150 892498299
376315150 892498299
QQ 376315150 892498299
R261 R262 R263 R268 R272
QQ
QQ
! R101 R201 R202 R203 R204
13942296513
5% 5% 5% 5%
TEL
47K 82K 47K 47K
< RESISTOR >
TEL 13942296513
Part No.
SURROUND
http://www.xiaoyu163.com
QQ 376315150 892498299 SURROUND
Ref. No.
Part No.
TABLE SENSOR
Description
TC-A SW
Remark
C651
1-126-963-11 ELECT
4.7uF
20%
50V
C652 C653 C654 C655 C656
1-162-292-31 1-162-286-21 1-126-967-11 1-126-967-11 1-126-968-11
680PF 220PF 47uF 47uF 100uF
10% 10% 20% 20% 20%
50V 50V 50V 50V 50V
C660 C661
1-130-493-00 MYLAR 1-130-493-00 MYLAR
0.068uF 0.068uF
5% 5%
50V 50V
CERAMIC CERAMIC ELECT ELECT ELECT
Ref. No. R654 R655 R656
5% 5% 5%
1/4W 1/2W 1/2W
! R659 ! R660 R661 R662 R663
1-212-881-11 1-217-151-00 1-249-417-11 1-249-431-11 1-249-441-11
FUSIBLE METAL PLATE CARBON CARBON CARBON
100 0.22 1K 15K 100K
5% 10% 5% 5% 5%
1/4W F 2W 1/4W F 1/4W 1/4W
R668 R670 R671 R672
1-260-076-11 1-249-441-11 1-249-441-11 1-249-436-11
CARBON CARBON CARBON CARBON
10 100K 100K 39K
5% 5% 5% 5%
1/2W 1/4W 1/4W 1/4W
1-691-765-11 PLUG (MICRO CONNECTOR) 3P 1-691-770-11 PLUG (MICRO CONNECTOR) 8P 1-691-766-11 PLUG (MICRO CONNECTOR) 4P
< THERMISTOR > THP670 1-807-796-11 THERMISTOR
1N4148M 1N4148M 1N4148M 1N4148M 1N4148M
**************************************************************
13942296513
13942296513
DIODE DIODE DIODE DIODE DIODE
1-659-058-13 TABLE SENSOR BOARD ******************
*
< IC > < EARTH TERMINAL > IC202 * EP601 * EP602
< RESISTOR >
8-749-900-96 IC STK-4142MK2
1/4W F
1-664-012-11 TC-A SW BOARD *************
*
2SC1841-PAFAEA 2SC1841-PAFAEA 2SC2785-HFE DTC124ES
< CONNECTOR > CN612
1-506-486-11 PIN, CONNECTOR 7P < DIODE >
< RESISTOR > R601 R602 R603 R604 R605
1-249-417-11 1-249-437-11 1-249-415-11 1-249-437-11 1-260-103-11
CARBON CARBON CARBON CARBON CARBON
1K 47K 680 47K 2.2K
5% 5% 5% 5% 5%
1/4W F 1/4W 1/4W F 1/4W 1/2W
R606 ! R609 ! R610 R611 R612
1-260-103-11 1-212-881-11 1-217-151-00 1-249-417-11 1-249-431-11
CARBON FUSIBLE METAL PLATE CARBON CARBON
2.2K 100 0.22 1K 15K
5% 5% 10% 5% 5%
1/2W 1/4W F 2W 1/4W F 1/4W
R613 R614 R616 R618 R627
1-249-441-11 1-260-099-11 1-260-099-11 1-260-076-11 1-249-429-11
CARBON CARBON CARBON CARBON CARBON
100K 1K 1K 10 10K
5% 5% 5% 5% 5%
1/4W 1/2W 1/2W 1/2W 1/4W
R628 R630 R642 ! R644 R651
1-247-881-00 1-249-429-11 1-249-429-11 1-217-637-00 1-249-417-11
CARBON CARBON CARBON FUSIBLE CARBON
120K 10K 10K 1 1K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W F 1/4W F
47K 680
5% 5%
1/4W 1/4W F
D631 D632
8-719-057-29 DIODE SML78423C-TP15 (·)(DECK A) 8-719-057-29 DIODE SML78423C-TP15 (ª)(DECK A) < RESISTOR >
R705 R706 R707 R708 R709
1-249-401-11 1-249-403-11 1-247-807-31 1-249-407-11 1-249-407-11
CARBON CARBON CARBON CARBON CARBON
47 68 100 150 150
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
R710 R711 R712 R713 R714
1-247-815-91 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
220 100 100 100 100
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
< SWITCH >
www
R652 R653
.
1-249-437-11 CARBON 1-249-415-11 CARBON
S641 S642 S643 S644 S645
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (·)(DECK A) SWITCH, TACTILE (ª)(DECK A) SWITCH, TACTILE (p)(DECK A) SWITCH, TACTILE (0)(DECK A) SWITCH, TACTILE ())(DECK A)
S646
1-554-303-21 SWITCH, TACTILE (DOLBY NR)
xiaoy u163. com — 120 —
http://www.xiaoyu163.com
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
F F F F
376315150 892498299
376315150 892498299
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
5%
**************************************************************
< TRANSISTOR >
8-729-140-84 8-729-140-84 8-729-119-78 8-729-900-36
820
QQ 376315150 892498299
TEL 13942296513
Q601 Q651 Q670 Q671
1-249-416-11 CARBON
QQ
QQ
R207
< IC > IC601
8-749-924-18 IC PHOTO INTERRUPTER RPI-1391
1-537-738-21 TERMINAL, EARTH (CH) 1-537-738-21 TERMINAL, EARTH
TEL
TEL
8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63
Remark
47K 2.2K 2.2K
< DIODE > D601 D602 D603 D604 D651
Description
1-249-437-11 CARBON 1-260-103-11 CARBON 1-260-103-11 CARBON
< CONNECTOR > CN601 CN602 CN603
Part No.
http://www.xiaoyu163.com
QQ 376315150 892498299 TC-A SW
Ref. No. S647
Part No.
Description
Remark
Ref. No.
TC-B SW
Part No.
! S501
8-719-057-29 8-719-057-29 8-719-058-17 8-719-057-09
Description
Remark
1-762-753-11 SWITCH, VOLTAGE SELECTION (VOLTAGE SELECTOR)(E,SP,IA,CH)
1-664-013-11 TC-B SW BOARD *************
D635 D636 D637 D638
VIDEO
< SWITCH >
1-554-303-21 SWITCH, TACTILE (DIRECTION)
************************************************************** *
TRANS
< TRANSFORMER >
< DIODE >
! T501
DIODE DIODE DIODE DIODE
**************************************************************
SML78423C-TP15 (ª)(DECK B) SML78423C-TP15 (·)(DECK B) LNJ401NPYJA (P)(DECK B) LNJ801LPDJA (r REC)(DECK B)
1-431-418-11 TRANSFORMER, POWER
A-4398-587-A VIDEO BOARD, COMPLETE **********************
*
< RESISTOR >
< CAPACITOR > 5% 5% 5% 5% 5%
1/4W 1/4W 1/4W F 1/4W F 1/4W F
C101 C102 C103 C104 C105
1-163-038-91 1-163-251-11 1-163-241-11 1-163-241-11 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 100PF 39PF 39PF 0.1uF
R720 R721 R722 R723 R724
1-249-419-11 1-249-421-11 1-247-843-11 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON CARBON
1.5K 2.2K 3.3K 100 100
5% 5% 5% 5% 5%
1/4W F 1/4W F 1/4W 1/4W 1/4W
C106 C107 C108 C109 C121
1-163-131-00 1-163-113-00 1-163-038-91 1-126-206-11 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
390PF 68PF 0.1uF 100uF 0.1uF
R725 R726 R727 R728
1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31
CARBON CARBON CARBON CARBON
100 100 100 100
5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W
C122 C123 C124 C125 C126
1-163-091-00 1-163-091-00 1-163-038-91 1-163-038-91 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
8PF 8PF 0.1uF 0.1uF 0.1uF
C127 C128 C129 C151 C152
1-163-017-00 1-163-239-11 1-163-239-11 1-163-038-91 1-163-251-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0047uF 33PF 33PF 0.1uF 100PF
5% 5% 5%
C153 C154 C155 C156 C157
1-163-241-11 1-163-241-11 1-163-038-91 1-163-131-00 1-163-113-00
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
39PF 39PF 0.1uF 390PF 68PF
5% 5%
C158 C159 C181 C201 C202
1-163-038-91 1-126-206-11 1-163-038-91 1-126-607-11 1-163-038-91
CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
0.1uF 100uF 0.1uF 47uF 0.1uF
C203 C204 C205 C206 C207
1-163-038-91 1-163-038-91 1-163-038-91 1-163-227-11 1-163-227-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 10PF 10PF
C208 C209 C210 C211 C212
1-163-038-91 1-163-231-11 1-163-231-11 1-163-038-91 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 15PF 15PF 0.1uF 0.1uF
C213 C251 C252 C271 C272
1-163-038-91 1-124-779-00 1-163-038-91 1-163-038-91 1-124-779-00
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
0.1uF 10uF 0.1uF 0.1uF 10uF
TEL 13942296513 < SWITCH >
S651 S652 S653 S654 S655
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (·)(DECK B) SWITCH, TACTILE (ª)(DECK B) SWITCH, TACTILE ())(DECK B) SWITCH, TACTILE (0)(DECK B) SWITCH, TACTILE (p)(DECK B)
S656 S657 S658 S659
1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21
SWITCH, TACTILE (P)(DECK B) SWITCH, TACTILE (r REC)(DECK B) SWITCH, TACTILE (H SPEED DUB) SWITCH, TACTILE (CD SYNC)
5% 5% 20%
25V 50V 50V 50V 25V 50V 50V 25V 6.3V 25V 50V 50V 25V 25V 25V
QQ 376315150 892498299
************************************************************** 1-663-994-11 TRANS BOARD ***********
*
5% 5% 5%
5%
5% 5%
20% 20%
50V 50V 50V 25V 50V 50V 50V 25V 50V 50V 25V 6.3V 25V 4V 25V
< CONNECTOR > * CN501 CN502
1-564-527-11 PLUG, CONNECTOR 12P 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P < FUSE >
! F501
1-532-504-31 FUSE, TIME-LAG (4A/250V)(E,SP,IA,CH) < FUSE HOLDER >
FH501 FH502
1-533-233-21 HOLDER, FUSE (E,SP,IA,CH) 1-533-233-21 HOLDER, FUSE (E,SP,IA,CH)
www ! R501 ! R502
xiaoy u163. com < RESISTOR >
.
1-219-120-11 FUSIBLE 1-219-120-11 FUSIBLE
0.15 0.15
5% 5%
1/4W F 1/4W F
— 121 —
http://www.xiaoyu163.com
0.5PF 0.5PF
5% 5%
20%
20%
25V 25V 25V 50V 50V 25V 50V 50V 25V 25V 25V 16V 25V 25V 16V
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
376315150 892498299
376315150 892498299
220 330 470 680 1K
QQ
QQ
CARBON CARBON CARBON CARBON CARBON
13942296513
13942296513
1-247-815-91 1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11
TEL
TEL
R715 R716 R717 R718 R719
http://www.xiaoyu163.com
QQ 376315150 892498299 VIDEO
Ref. No.
Part No.
Description
Remark
C273 C274 C275 C276 C301
1-163-038-91 1-163-141-00 1-163-038-91 1-163-243-11 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.001uF 0.1uF 47PF 0.1uF
C302 C303 C304 C305 C306
1-124-779-00 1-163-038-91 1-163-038-91 1-163-038-91 1-163-038-91
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
10uF 0.1uF 0.1uF 0.1uF 0.1uF
20%
C401 C402 C403 C404 C405
1-124-779-00 1-163-038-91 1-163-038-91 1-163-038-91 1-163-038-91
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
10uF 0.1uF 0.1uF 0.1uF 0.1uF
20%
C406 C407 C408 C409 C451
1-163-038-91 1-124-779-00 1-163-038-91 1-163-229-11 1-163-038-91
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 10uF 0.1uF 12PF 0.1uF
C452 C453 C454 C461 C462
1-163-038-91 1-163-038-91 1-124-779-00 1-109-982-11 1-109-982-11
CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 10uF 1uF 1uF
C463 C464 C465 C466 C468
1-163-038-91 1-126-205-11 1-163-038-91 1-163-038-91 1-163-038-91
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 47uF 0.1uF 0.1uF 0.1uF
C469 C470 C501 C502 C503
1-163-038-91 1-126-206-11 1-163-038-91 1-163-101-00 1-163-101-00
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 100uF 0.1uF 22PF 22PF
C504 C505 C506 C701 C702
1-163-117-00 1-163-117-00 1-163-239-11 1-163-038-91 1-163-038-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100PF 100PF 33PF 0.1uF 0.1uF
5% 5% 5%
50V 50V 50V 25V 25V
C703 C704 C705 C706 C751
1-163-239-11 1-163-239-11 1-124-779-00 1-163-038-91 1-124-779-00
CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CHIP
33PF 33PF 10uF 0.1uF 10uF
5% 5% 20% 20%
50V 50V 16V 25V 16V
C752 C771 C772 C801 C802
1-163-038-91 1-163-038-91 1-163-038-91 1-126-206-11 1-126-206-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP
0.1uF 0.1uF 0.1uF 100uF 100uF
20% 20%
25V 25V 25V 6.3V 6.3V
C803 C804 C805 C806 C807
1-163-038-91 1-126-209-11 1-126-204-11 1-126-206-11 1-126-206-11
CERAMIC CHIP ELECT ELECT CHIP ELECT CHIP ELECT CHIP
0.1uF 100uF 47uF 100uF 100uF
20% 20% 20% 20%
25V 4V 16V 6.3V 6.3V
C884 C901 C902
1-163-038-91 CERAMIC, CHIP 1-124-779-00 ELECT CHIP 1-163-038-91 CERAMIC CHIP
0.1 10uF 0.1uF
25V 50V 25V 50V 25V
5%
5%
Ref. No.
Part No.
Description
Remark
C903 C904
1-163-038-91 CERAMIC CHIP 1-163-038-91 CERAMIC CHIP
0.1uF 0.1uF
25V 25V
C908
1-163-038-91 CERAMIC CHIP
0.1uF
25V
< CONNECTOR >
20% 10% 10%
www
.
20% 5% 5%
< TRIMMER > CT401
1-141-539-11 CAP, ADJ 10PF < DIODE >
25V 16V 25V 50V 25V
D701
8-719-018-51 DIODE CL-170R-CD < GROUND TERMINAL >
* EPT884 4-870-539-00 PLATE, GROUND
25V 25V 16V 10V 10V
< FERRITE BEAD >
25V 6.3V 25V 25V 25V 25V 6.3V 25V 50V 50V
FB101 FB102 FB103 FB104 FB105
1-500-445-21 1-543-961-11 1-543-961-11 1-543-961-11 1-543-961-11
INDUCTOR 0UH BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP)
QQ 376315150 892498299 FB106 FB451 FB452 FB453 FB454
1-216-295-91 1-543-961-11 1-543-961-11 1-543-961-11 1-216-295-91
CONDUCTOR, CHIP (2012) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) BEAD, FERRITE (CHIP) CONDUCTOR, CHIP (2012)
FB455 FB801 FB802
1-216-295-91 CONDUCTOR, CHIP (2012) 1-500-184-11 BEAD, FERRITE 1-500-184-11 BEAD, FERRITE < IC >
IC101 IC102 IC103 IC181 IC201
8-759-362-47 8-759-701-39 8-759-701-39 8-759-269-14 8-752-389-31
IC IC IC IC IC
CXD8567AM NJM3404AM NJM3404AM SN74HCT08ANS-E20 CXD1852AQ
IC251 IC271 IC272 IC301 IC401
8-759-368-97 8-759-479-44 8-759-180-84 8-752-384-09 8-752-380-71
IC IC IC IC IC
M5M44260CTP-7S BU6257AFV TC7W74F CXD1854Q CXD1913Q
IC402 IC451 IC452 IC501 IC701
8-759-269-92 8-759-262-00 8-759-262-00 8-759-926-49 8-759-468-15
IC IC IC IC IC
SN74HCU04ANS-E20 MC14576CF MC14576CF SN74HC245ANS HD6433032SK12F
IC751 IC771 IC772 IC801 IC901
8-759-462-71 8-759-927-72 8-759-035-93 8-759-460-72 8-759-467-59
IC IC IC IC IC
HY6264ALJ-70-TR TL1591CP SC7S32F BA033FP uPD780016YGF-012-3BA
xiaoy u163. com 20%
25V 16V 25V
— 122 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
CONNECTOR,FFC(LIF(NON-ZIF))13P CONNECTOR, FFC/FPC 29P PIN, CONNECTOR (PC BOARD) 8P PIN, CONNECTOR (PC BOARD) 5P
QQ
QQ
20%
16V 25V 25V 25V 25V
1-779-416-11 1-766-942-11 1-774-863-11 1-774-731-21
13942296513
13942296513
5%
CN101 CN102 CN103 CN104
TEL
TEL
20%
16V 25V 25V 25V 25V
http://www.xiaoyu163.com
QQ 376315150 892498299 VIDEO
Ref. No.
L101 L251
Part No.
Description
Remark
Part No.
Description
Remark
< COIL >
R220
1-216-073-00 METAL CHIP
10K
5%
1/10W
1-410-377-31 INDUCTOR CHIP 4.7uH 1-410-377-31 INDUCTOR CHIP 4.7uH
R221 R222 R223 R224 R225
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R226 R227 R228 R229 R230
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R231 R232 R233 R234 R235
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R236 R237 R238 R239 R240
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R241 R242 R243 R271 R272
1-216-073-00 1-216-073-00 1-216-295-91 1-216-025-91 1-216-025-91
METAL CHIP 10K METAL CHIP 10K CONDUCTOR, CHIP (2012) METAL GLAZE 100 METAL GLAZE 100
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
< TRANSISTOR > Q701
Ref. No.
8-729-900-53 TRANSISTOR DTC114EK < RESISTOR > 0.5% 0.5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R106 R107 R108 R109 R110
1-216-693-11 1-216-693-11 1-216-081-00 1-216-073-00 1-216-081-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
56K 56K 22K 10K 22K
0.5% 0.5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R111 R121 R122 R123 R124
1-216-081-00 1-216-057-00 1-216-057-00 1-216-065-00 1-216-025-91
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL GLAZE
22K 2.2K 2.2K 4.7K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R125 R126 R127 R128 R129
1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91
METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R130 R151 R152 R153 R154
1-216-041-00 1-216-691-11 1-216-691-11 1-216-679-11 1-216-675-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 47K 47K 15K 10K
5% 0.5% 0.5% 0.5% 0.5%
R155 R156 R157 R158 R159
1-216-675-11 1-216-693-11 1-216-693-11 1-216-081-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 56K 56K 22K 10K
0.5% 0.5% 0.5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R160 R161 R201 R203 R204
1-216-081-00 1-216-081-00 1-216-025-91 1-216-295-91 1-216-025-91
METAL CHIP 22K METAL CHIP 22K METAL GLAZE 100 CONDUCTOR, CHIP (2012) METAL GLAZE 100
5% 5% 5%
1/10W 1/10W 1/10W
5%
1/10W
R206 R207 R208 R209 R210
1-216-295-91 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
CONDUCTOR, CHIP (2012) METAL CHIP 10K METAL CHIP 10K METAL CHIP 10K METAL CHIP 10K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R211 R212 R213 R214 R215
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R216 R217 R218 R219
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
TEL 13942296513
www
.
QQ 376315150 892498299 1/10W 1/10W 1/10W 1/10W 1/10W
R273 R274 R302 R303 R304
1-216-041-00 1-216-049-91 1-216-025-91 1-216-073-00 1-216-073-00
METAL CHIP METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP
470 1K 100 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R305 R306 R307 R308 R309
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R310 R311 R312 R313 R401
1-216-073-00 1-216-073-00 1-216-073-00 1-216-025-91 1-216-047-91
METAL CHIP METAL CHIP METAL CHIP METAL GLAZE METAL GLAZE
10K 10K 10K 100 820
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R402 R403 R404 R405 R406
1-216-025-91 1-216-025-91 1-216-121-91 1-216-047-91 1-216-025-91
METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE
100 100 1M 820 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R407 R451 R452 R453 R454
1-216-025-91 1-216-687-11 1-216-663-11 1-216-651-11 1-216-663-11
METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 33K 3.3K 1K 3.3K
5% 0.5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R455 R456 R457 R458 R459
1-216-635-11 1-216-635-11 1-216-635-11 1-216-295-91 1-216-295-91
METAL CHIP 220 METAL CHIP 220 METAL CHIP 220 CONDUCTOR, CHIP (2012) CONDUCTOR, CHIP (2012)
0.5% 0.5% 0.5%
1/10W 1/10W 1/10W
R460
1-216-295-91 CONDUCTOR, CHIP (2012)
xiaoy u163. com — 123 —
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
47K 47K 15K 10K 10K
QQ
QQ
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
13942296513
13942296513
1-216-691-11 1-216-691-11 1-216-679-11 1-216-675-11 1-216-675-11
TEL
TEL
R101 R102 R103 R104 R105
http://www.xiaoyu163.com
QQ 376315150 892498299 VIDEO
Ref. No.
VIDEO OUT
VIDEO POWER Remark
CONDUCTOR, CHIP (2012) CONDUCTOR, CHIP (2012) CONDUCTOR, CHIP (2012) METAL GLAZE 100K
5%
1/10W
R465 R466 R467 R468 R469
1-216-097-91 1-216-097-91 1-216-624-11 1-216-624-11 1-216-624-11
METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP
100K 100K 75 75 75
5% 5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R470 R471 R501 R502 R503
1-216-049-91 1-216-049-91 1-216-009-91 1-216-009-91 1-216-025-91
METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE
1K 1K 22 22 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R504 R505 R506 R507 R508
1-216-025-91 1-216-025-91 1-216-025-00 1-216-037-00 1-216-037-00
METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP METAL CHIP
100 100 100 330 330
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R509 R510 R511 R701 R702
1-216-037-00 1-216-047-91 1-216-043-91 1-216-057-00 1-216-065-00
METAL CHIP METAL GLAZE METAL GLAZE METAL CHIP METAL CHIP
330 820 560 2.2K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R704 R705 R706 R707 R708
1-216-073-00 1-216-057-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 2.2K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R709 R711 R712 R713 R714
1-216-073-00 1-216-295-91 1-216-025-91 1-216-025-91 1-216-025-91
METAL CHIP 10K CONDUCTOR, CHIP (2012) METAL GLAZE 100 METAL GLAZE 100 METAL GLAZE 100
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R715 R716 R717 R718 R719
1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91 1-216-025-91
METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE METAL GLAZE
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R720 R721 R722 R723 R724
1-216-025-91 1-216-025-91 1-216-081-00 1-216-025-91 1-216-073-00
METAL GLAZE METAL GLAZE METAL CHIP METAL GLAZE METAL CHIP
100 100 22K 100 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R725 R726 R727 R728 R902
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-295-91
METAL CHIP 10K METAL CHIP 10K METAL CHIP 10K METAL CHIP 10K CONDUCTOR, CHIP (2012)
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R903 R904 R905 R906 R907
1-216-025-91 1-216-073-00 1-216-073-00 1-216-073-00 1-216-085-00
METAL GLAZE METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 10K 10K 10K 33K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R908 R909 R910 R911
1-216-085-00 1-216-085-00 1-216-085-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
33K 33K 33K 10K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
Description
Remark
R912
1-216-073-00 METAL CHIP
10K
5%
1/10W
R913 R914 R915 R916 R917
1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R919 R920 R921
1-216-073-00 METAL CHIP 1-216-073-00 METAL CHIP 1-216-073-00 METAL CHIP
10K 10K 10K
5% 5% 5%
1/10W 1/10W 1/10W
< VIBRATOR > X101 X201 X202 X401 X701
1-767-518-11 1-767-055-11 1-767-361-11 1-767-519-11 1-767-211-11
VIBRATOR, CRYSTAL (33MHz) VIBRATOR, CERAMIC (45MHz) VIBRATOR, CERAMIC (28.63636MHz) VIBRATOR, CRYSTAL (27MHz) VIBRATOR, CERAMIC (10MHz)
X901
1-767-144-21 VIBRATOR, CERAMIC (5MHz)
**************************************************************
TEL 13942296513
www
1-665-406-11 VIDEO OUT BOARD ***************
*
< CAPACITOR > C9001 C9002 C9003 C9007
1-126-926-11 1-126-926-11 1-126-925-11 1-102-972-00
ELECT ELECT ELECT CERAMIC
1000uF 1000uF 470uF 91PF
20% 20% 20% 5%
10V 10V 10V 50V
QQ 376315150 892498299 < CONNECTOR >
* CN9001 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P < JACK > J9001 J9002
1-774-227-11 JACK, PIN 1P (VIDEO OUT) 1-778-773-11 TERMINAL, S (S VIDEO OUT) < COIL >
L9001
1-408-397-00 MICRO INDUCTOR 1uH < RESISTOR >
R9001 R9002 R9003 R9004 R9005
1-249-429-11 1-249-429-11 1-249-429-11 1-249-429-11 1-247-863-91
CARBON CARBON CARBON CARBON CARBON
10K 10K 10K 10K 22K
5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W
< SWITCH > S9001
1-571-589-11 SWITCH, SLIDE (SYSTEM SELECT)
************************************************************** 1-666-126-11 VIDEO POWER BOARD *****************
*
xiaoy u163. com < CAPACITOR >
.
C9001 C9002 C9003
1-126-964-11 ELECT 1-126-933-11 ELECT 1-126-919-11 ELECT
— 124 —
http://www.xiaoyu163.com
10uF 100uF 6800uF
20% 20% 20%
50V 16V 6.3V
376315150 892498299
376315150 892498299
1-216-295-91 1-216-295-91 1-216-295-91 1-216-097-91
Part No.
QQ
QQ
R461 R462 R463 R464
Ref. No.
13942296513
13942296513
Description
TEL
TEL
Part No.
http://www.xiaoyu163.com
QQ 376315150 892498299 VIDEO POWER
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
C9004 C9005
1-126-964-11 ELECT 1-126-935-11 ELECT
10uF 470uF
20% 20%
50V 6.3V
ACCESSORIES & PACKING MATERIALS *******************************
C9006
1-126-933-11 ELECT
100uF
20%
16V
1-475-166-11 1-501-374-11 1-501-659-41 3-860-240-11 3-860-240-31
< CONNECTOR > CN9001 1-564-506-11 PLUG, CONNECTOR 3P * CN9002 1-564-507-11 PLUG, CONNECTOR 4P
Remark
COMMANDER, STANDARD (RM-SV909) ANTENNA, LOOP (IA) ANTENNA (FM)(IA) MANUAL, INSTRUCTION (ENGLISH) (IA) MANUAL, INSTRUCTION (CHINESE) (IA)
4-983-536-01 COVER, BATTERY (for RM-SV909) < IC > ************************************************************** IC9001 IC9002
8-759-231-53 IC TA7805S 8-759-231-53 IC TA7805S
************* HARDWARE LIST *************
< TRANSISTOR > TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SB1094-LK DTC124ES 2SB1094-LK DTC124ES
7-685-646-79 7-685-871-01 7-685-872-09 7-685-650-79 7-685-862-09
SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTT 3X6 (S) SCREW +BVTT 3X8 (S) SCREW +BVTP 3X16 TYPE2 N-S SCREW +BVTT 2.6X6 (S)
#6 #7 #8 #9 #10
7-685-131-19 7-685-534-19 7-621-775-10 7-685-533-19 7-623-921-01
SCREW +BTP 2.6X4 TYPE2 N-S SCREW +BTP 2.6X8 TYPE2 N-S SCREW +B 2.6X4 SCREW +BTP 2.6X6 TYPE2 N-S RING, RETAINING, CAPSTAN
#11 #12
7-621-775-00 SCREW +B 2.6X3 7-621-255-15 SCREW +P 2X3
< RESISTOR > R9001 R9002 R9003 R9004
1-249-421-11 1-249-413-11 1-249-421-11 1-249-413-11
CARBON CARBON CARBON CARBON
2.2K 470 2.2K 470
5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W
F F F F
************************************************************** MISCELLANEOUS *************
5 6 58 59 120
1-233-545-11 1-769-974-11 1-773-163-11 1-769-949-11 1-773-051-11
ENCAPSULATED COMPONENT WIRE (FLAT TYPE)(13 CORE) WIRE (FLAT TYPE)(21 CORE) WIRE (FLAT TYPE)(11 CORE) WIRE (FLAT TYPE)(17 CORE)
156 ! 161 ! 161 166 * 357
1-782-563-11 1-569-007-11 1-569-008-11 1-500-386-11 1-452-879-11
WIRE (FLAT TYPE)(29 CORE) ADAPTOR, CONVERSION 2P (IA) ADAPTOR, CONVERSION 2P (E,SP,MY) FERRITE CORE (CH) MAGNET
! 401 402 ! CNP901 ! CNP901 ! CNP901
8-820-020-03 1-769-069-11 1-558-943-41 1-575-651-21 1-782-510-11
OPTICAL PICK-UP KSS-213D/Q-NP WIRE (FLAT TYPE)(16 CORE) CORD, POWER (IA) CORD, POWER (E,SP,MY) CORD, POWER (CH)
FL601 1-517-617-11 HP101 1-500-093-11 HRPE101 1-500-094-11 M1 X-3371-223-1 M2 A-2004-410-A
INDICATOR TUBE, FLUORESCENT HEAD, MAGNETIC (PLAYBACK) HEAD, MAGNETIC (REC/PB/ERASE) MOTOR ASSY (CAPSTAN) MOTOR ASSY (TRIGGER)
M101 M102 M201 M901 ! T501
X-4917-523-4 X-4917-504-1 A-4660-977-A 1-698-792-11 1-431-418-11
www
QQ 376315150 892498299
MOTOR ASSY (SPINDLE) MOTOR ASSY (SLED) MOTOR ASSY (TABLE) FAN, DC TRANSFORMER, POWER
xiaoy u163. com
**************************************************************
.
— 125 —
http://www.xiaoyu163.com
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
#1 #2 #3 #4 #5
13942296513
13942296513
8-729-141-83 8-729-900-36 8-729-141-83 8-729-900-36
TEL
TEL
Q9001 Q9002 Q9003 Q9004
http://www.xiaoyu163.com
HCD-V8800
QQ 376315150 892498299 TEL
TEL
13942296513
13942296513
9-920-932-11 (SP)
.
xiaoy u163. com Sony Corporation
Home A&V Products Company
— 126 —
http://www.xiaoyu163.com
97G0922-1 Printed in Japan © 1997. 7 Published by General Engineering Dept. (Shibaura)
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
